2021 Ford F-350 SD: sudden loss of power

Filed Aug 19, 2026 · Fuel system · 30,000 miles · ID

The contact owns a 2021 Ford F-350 SD. The contact received notification of the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel). The contact stated that while driving 20 MPH, the message "Reduced Power" was displayed, and the check engine warning light was illuminated. The vehicle stalled and failed to restart. The vehicle was towed to a dealer and was diagnosed with failures of the CP4 fuel pump, cycloid filters, and contamination of the entire fuel system. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.

Filed Jul 8, 2026 · Electrical · MN

I was driving my truck home when it completely shut off, I lost all power to everything, including the power steering brakes. When I got home, I did some research on the Internet to see possible causes. Apparently there is a service bulletin for the fuse box having water getting into it from the cowl of the hood, which states it can do exactly what happened to my truck? You can also keep your truck running and not shutting off and just to hold host of other safety issues with the service bulletin. . So I brought my truck in to get diagnosed by Ford and they did indeed say it was the fuse box under the hood that got water into it and shorted it out. Ford would not cover this part even though I have a factory extended warranty, annoying this is a common issue for 2020 to 2022 Ford trucks they issued a recall on expeditions in a couple other vehicles, but not Ford trucks specifically the super duties. How is this? OK that they don’t tell a customer who purchased a vehicle that this could potentially happen and then when it happens, they refuse to cover anything even though it’s their fault why it happened.

Filed Jun 11, 2026 · Fuel system · 195,000 miles · TX

The contact owns a 2021 Ford F-350. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended. The vehicle was driven to the shoulder of the road, where it lost motive power. The message "Reduced Engine Power" was displayed, and the check engine warning light was illuminated. The contact stated that the failure occurred while a fifth wheel RV was hitched to the vehicle. The vehicle was towed to the dealer, where it was diagnosed that the high-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired. The contact was informed that the manufacturer denied covering the repair under the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel) due to a contaminated fuel system; however, the dealer confirmed that the fuel system was not contaminated. The dealer submitted information to the manufacturer advising that the fuel system was not contaminated. Additionally, a case was filed; however, the contact was denied coverage. The failure mileage was approximately 195,000.

Filed May 1, 2026 · Fuel system · TX

Vehicle Safety Complaint – 2021 Ford F-350 I am submitting this complaint regarding a safety-related failure involving my 2021 Ford F-350. While driving under normal conditions, the vehicle suddenly entered “limp mode,” resulting in a significant and immediate loss of power. Approximately 20 miles later, the vehicle completely shut down, leaving me stranded and requiring the truck to be towed to Gene Messer Ford for diagnosis and repair. The failure created a potentially dangerous situation, as the loss of power limited my ability to maintain safe speeds and respond to surrounding traffic conditions. After the vehicle was delivered to the dealership, it took approximately one week for inspection and an additional two weeks to complete repairs. During the repair process, I was informed that newly installed components—including the fuel rail and two fuel injectors—were defective and required replacement again. This raises concerns about whether the root cause of the failure was properly identified and whether contamination or systemic failure within the fuel system was present. I am also aware of widely reported issues involving high-pressure fuel pump (HPFP) failures in Ford diesel engines, which can result in catastrophic damage to the entire fuel system, including injectors, fuel rails, and lines. Given the nature of my vehicle’s failure and the components involved, I am concerned that this incident may be related to a broader, known defect. This type of failure—sudden loss of power followed by complete shutdown—poses a serious safety risk, particularly if it occurs at highway speeds or in high-traffic conditions. I am requesting that this complaint be reviewed as part of a broader investigation into potential fuel system defects in Ford diesel trucks. I believe this issue may warrant further scrutiny and possible recall action to prevent similar incidents.

Filed Jul 7, 2025 · Engine · UT

There is an active recall on my truck and it is affecting my ability to use my truck for work purposes. I am not allowed to used a vehicle with an open, active recall, therefore I cannot use my truck. This recall has been active for more than six months and a remedy has not yet been identified. I am posting a complaint to try and speed up the recall process, which if I understand correctly is a software update for the engine to reduce biodiesel buildup in the engine which "could" cause loss of power.

Filed May 25, 2025 · Engine, Fuel system · CA

Ongoing Fuel System Failures Related to Recall 24S78 – Request for Escalated Review To Whom It May Concern, My name is [XXX] , and I am the owner of two 2021 Ford F-350 6.7L Power Stroke Diesel trucks, both of which are affected by Recall 24S78 / the federal safety agency Campaign 24V957 concerning biodiesel deposit accumulation in the fuel system and a pending PCM software update. Vehicle Information: VIN [XXX] VIN [XXX] Both vehicles have already experienced critical failures that directly align with the described defect in the recall, including: Failure of the CP4 high-pressure fuel pump Repeated clogging of the water/fuel separator filter Loss of power, extended crank times, and intermittent no-start conditions These issues occurred prior to the recall remedy being available and have compromised vehicle performance and safety. I am requesting: A full inspection and evaluation of the fuel systems under the scope of Recall 24S78 once the software becomes available. Coverage or reimbursement for repair or replacement of the CP4 pump and related components if found to be caused by biodiesel-related damage as described in the recall. A formal service record entry acknowledging these failures for future reference and eligibility under the recall. Escalation of this issue to a Ford regional service manager, if needed. Given the significant safety risk and the known failure history of the CP4 fuel system, I ask that Ford address this matter thoroughly and beyond a software update, if necessary. Please confirm receipt of this inquiry and advise me on next steps. I can be reached at: Phone: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 17, 2025 · Fuel system · 112,000 miles · TX

The contact owns a 2021 Ford F-350. The contact stated that while driving at an undisclosed speed, the loss of power warning light illuminated. The contact parked the vehicle and turned off the vehicle. The contact attempted to restart the vehicle however, the vehicle failed to start as intended. The vehicle was towed to the dealer where it was diagnosed with a contaminated fuel system. The contact was informed that the fuel system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact received notification of the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure; however, the manufacturer was unable to confirm when parts would become available. The failure mileage was approximately 112,000. VIN tool confirms parts not available.

Filed Feb 4, 2025 · Fuel system · 113,000 miles · LA

The contact owns a 2021 Ford F-350. The contact received notification of the federal safety agency Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving on the interstate at 75 MPH, the vehicle started to lose motive power. The contact veered to the right to exit the highway while the vehicle was losing power and eventually stopped. The check engine warning light was illuminated. The vehicle was towed to the dealer to be diagnosed. The dealer diagnosed the vehicle with a fuel system shutdown and high-pressure fuel pump failure. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle would not be repaired until the second quarter of 2025. The failure mileage was approximately 113,000. VIN tool confirms parts are not available.

Filed Jul 28, 2024 · Acceleration, Engine · CA · fire

On highway for 2 hours, pulling 5th wheel trailer. Diesel Particulate Filter Cleaning alert went on. Immediately truck lost power, a few other alerts flashed on the screen that couldn't read in time then alert that truck was being put in Neutral which it did. Smoke coming out of engine compartment. Barely coasted to stop on side of freeway. Quickly turned from white smoke to brown. Barely enough time to get me, wife and dog out of the cab before flames coming out of engine. Engine and cab completely burned out.