2021 Ford F-350 SD: fuel pump failure

Filed Oct 7, 2026 · Engine, Fuel system · MI

Failed Component & Availability for Inspection: The Bosch CP4 high-pressure fuel pump (HPFP) failed internally, shedding metallic debris throughout the entire fuel system. This matches the exact defect in the federal safety agency Recall 24V‑957 and Ford Safety Recalls 24S78 and 26S17. The failing CP4 pump and eight injectors were replaced on 03/14/2026 (Eastpointe Invoice #5997) due to contamination. The truck is located at Bob Maxey Ford in Detroit, MI, and is available for inspection alongside work orders from an authorized Ford dealership and two independent facilities. Safety Risk: The failure caused an abrupt, total loss of motive power on an active highway off-ramp, followed by an immediate no-start stall. Coasting without motive power across traffic lanes created an imminent collision hazard before the truck was towed by Troy’s Towing on 06/05/2026 (Invoice #34647). Problem Confirmation: •03/14/2026: Eastpointe replaced the failed CP4 pump and eight injectors (Inv #5997). •04/07/2026: Bill Brown Ford pulled DTC P228F, found debris on the regulator screen, and advised full fuel system replacement (RO #80302). •04/29/2026: Eastpointe confirmed metal contamination upon teardown (Inv #6342). •05/14/2026: Diesel’s Place found metal shavings on the regulator valve (Inv #2118). •Current: Bob Maxey Ford scanned DTC P0087 but reported no debris, contradicting prior documentation. Inspections: Bill Brown Ford inspected the vehicle on 04/07/2026 and documented debris. Bob Maxey Ford retrieved DTC P0087—a qualifying code for full fuel system replacement under Ford Recall 26S17—yet Ford Corporate denied coverage based on their claim of no metal shavings. Warning Signs & Timeline: In March 2026, the Check Engine Light illuminated with severe engine jerking (pump/injectors replaced 03/14). Bill Brown Ford confirmed DTC P228F and screen debris on 04/07. Metal shavings were reconfirmed on 05/14, leading to a highway stall/no-start on 06/05 and a stored DTC P0087 at Bob Maxey.

Filed Oct 2, 2026 · Fuel system · 89,545 miles · CA

The contact owns a 2021 Ford F-350 SD. The contact stated that while driving 50 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The engine seized, and the vehicle was pulled over to the shoulder of the roadway. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the dealer, where it was diagnosed with high-pressure fuel pump failure. The contact was informed that the high-pressure fuel pump needed to be replaced. In addition, the contact was informed that a repair request had been submitted to the manufacturer; however, the request was denied. The contact was informed that the failure codes displayed were not associated with an unrepaired recall. The contact received notification of the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel). The manufacturer was contacted by phone, and a case was filed. The failure mileage was approximately 89,545.

Filed Sep 3, 2026 · Fuel system · TX

The high pressure fuel pump failed sending metal shavings through out the entire fuel system. I had no heads up and the failure left me stranded on top of a bridge. I called 911 twice and finally the cops showed up and wrecker towed me off the bridge. Ford is aware of this known issue with this make and model, and even put a recall partial recall / quick fix to increase the flow around the pump to keep it cooler. I had the quick fix recall completed but it did not prevent the failure and me being stranded on a bridge.

Filed Aug 19, 2026 · Fuel system · 30,000 miles · ID

The contact owns a 2021 Ford F-350 SD. The contact received notification of the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel). The contact stated that while driving 20 MPH, the message "Reduced Power" was displayed, and the check engine warning light was illuminated. The vehicle stalled and failed to restart. The vehicle was towed to a dealer and was diagnosed with failures of the CP4 fuel pump, cycloid filters, and contamination of the entire fuel system. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.

Filed Aug 6, 2026 · Fuel system · WA

Vehicle went into limp mode and we towed it to the dealership. They ran diagnostics and found that the fuel filter was causing a fault for water in the fuel filter. They replaced the fuel filter and ran diagnostics again and it flagged failure for Low pressure fuel pump. They replaced the low pressure fuel pump and reran diagnostics. When they reran diagnostics it flagged for High pressure fuel pump failure and now they are in the process of tearing it down to the point of failure to find out the cause. My vehicles vin was not included in the original recall and believe that it should have been included.

Filed Jun 11, 2026 · Fuel system · 195,000 miles · TX

The contact owns a 2021 Ford F-350. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended. The vehicle was driven to the shoulder of the road, where it lost motive power. The message "Reduced Engine Power" was displayed, and the check engine warning light was illuminated. The contact stated that the failure occurred while a fifth wheel RV was hitched to the vehicle. The vehicle was towed to the dealer, where it was diagnosed that the high-pressure fuel pump had failed and needed to be replaced. The vehicle was not repaired. The contact was informed that the manufacturer denied covering the repair under the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel) due to a contaminated fuel system; however, the dealer confirmed that the fuel system was not contaminated. The dealer submitted information to the manufacturer advising that the fuel system was not contaminated. Additionally, a case was filed; however, the contact was denied coverage. The failure mileage was approximately 195,000.

Filed May 1, 2026 · Fuel system · TX

Vehicle Safety Complaint – 2021 Ford F-350 I am submitting this complaint regarding a safety-related failure involving my 2021 Ford F-350. While driving under normal conditions, the vehicle suddenly entered “limp mode,” resulting in a significant and immediate loss of power. Approximately 20 miles later, the vehicle completely shut down, leaving me stranded and requiring the truck to be towed to Gene Messer Ford for diagnosis and repair. The failure created a potentially dangerous situation, as the loss of power limited my ability to maintain safe speeds and respond to surrounding traffic conditions. After the vehicle was delivered to the dealership, it took approximately one week for inspection and an additional two weeks to complete repairs. During the repair process, I was informed that newly installed components—including the fuel rail and two fuel injectors—were defective and required replacement again. This raises concerns about whether the root cause of the failure was properly identified and whether contamination or systemic failure within the fuel system was present. I am also aware of widely reported issues involving high-pressure fuel pump (HPFP) failures in Ford diesel engines, which can result in catastrophic damage to the entire fuel system, including injectors, fuel rails, and lines. Given the nature of my vehicle’s failure and the components involved, I am concerned that this incident may be related to a broader, known defect. This type of failure—sudden loss of power followed by complete shutdown—poses a serious safety risk, particularly if it occurs at highway speeds or in high-traffic conditions. I am requesting that this complaint be reviewed as part of a broader investigation into potential fuel system defects in Ford diesel trucks. I believe this issue may warrant further scrutiny and possible recall action to prevent similar incidents.

Filed Apr 8, 2026 · Fuel system · TX

Repair remedy has not been addressed. Leaving the vehicle owners footing the bill when a fuel system problem arises. It's been since 2024 and FMC has not done anything about it. Dec 20,2024 Manufacturer Recall Number24S78 the federal safety agency Recall Number24V957 Recall StatusRecall Incomplete, remedy not yet available Summary YOUR VEHICLES HIGH-PRESSURE FUEL PUMP MAY FAIL, WHICH MAY RESULT IN EXTENDED CRANKING WITHOUT STARTING WHILE THE VEHICLE IS PARKED, ANDOR A LOSS OF MOTIVE POWER WHILE DRIVING. PRIOR TO LOSS OF MOTIVE POWER YOU MAY EXPERIENCE A CHECK ENGINE LIGHT, NOISE, ANDOR REDUCED ENGINE PERFORMANCE. Safety Risk A LOSS OF MOTIVE POWER INCREASES THE RISK OF A CRASH. Remedy PARTS AND SOFTWARE ARE NOT AVAILABLE TO REPAIR YOUR VEHICLE. FORD MOTOR COMPANY HAS AUTHORIZED YOUR DEALER TO UPDATE THE POWERTRAIN CONTROL MODULE PCM AND THE TRANSMISSION CONTROL MODULE TCM SOFTWARE, AND TO CHECK FOR THE PRESENCE OF CERTAIN DIAGNOSTICS TROUBLE CODES DTCS IN THE PCM WHICH COULD LEAD TO ADDITIONAL DIAGNOSTICS, FREE OF CHARGE. Manufacturer's Notes IF YOU HAVE ANY QUESTIONS REGARDING THIS RECALL, OR BELIEVE ANY OF THIS INFORMATION IS INACCURATE, PLEASE CONTACT FORD DIRECTLY AT 800‑392‑3673 OR LINCOLN AT 800‑521‑4140. If the manufacturer has failed or is unable to remedy this safety recall for your vehicle in a timely manner, please contact the federal safety agency Vehicle Safety Hotline at: 1‑888‑327‑4236 or TTY: 1‑888‑275‑9171 or file an online complaint with the federal safety agency.

Filed Nov 5, 2025 · Fuel system · 132,900 miles · CA

The contact owns a 2021 Ford F-350. The contact received notification of the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed with the cruise control activated, the contact heard an abnormally loud popping and clicking sound. The check engine warning light was illuminated. The message "Decreased Engine Power" was displayed, and the vehicle experienced a loss of drive power. The contact coasted off the road and came to a complete stop. The message "Shift to Neutral" was displayed. The contact turned off the vehicle and let it cool down for five minutes. The vehicle failed to restart. The vehicle was towed to an independent mechanic, who determined that the high-pressure fuel pump had failed. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 132,900.

Filed Aug 21, 2025 · Fuel system · 280,000 miles · TX

The contact owned a 2021 Ford F-350. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power and was unable to accelerate as needed. The contact was able to reach to drive to the residence, where the failure persisted. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure high-pressure fuel pump (HPFP). The vehicle was repaired. After investigating the failure, the contact attributed it to the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel). The VIN was included, but parts were not yet available. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The contact had since sold the vehicle. The failure mileage was 280,000.

Filed Aug 1, 2025 · Fuel system · UT

I have a fuel leak on this vehicle that seams to coming from fuel filter housing or fuel pump.

Filed Jul 17, 2025 · Fuel system · 100,000 miles · FL

The contact owns a 2021 Ford F-350 Commercial Vehicle. The contact received notification of the federal safety agency Campaign Number: 24V957000(Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated that the vehicle had failed to start. The vehicle was towed to an independent mechanic, where it was diagnosed that the fuel pump had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted for the recall repair and informed the contact that the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000. VIN tool confirms parts not available.