2019 Ford F-350 SD: fuel pump failure

9 of the 467 complaints about the 2019 Ford F-350 SD describe fuel pump failure.

owner complaints: 9
of this car's complaints: 2%
recalls: 0

Is there a fix? 1 service bulletin covers this area of the car. See below

Fuel pump failure by model year

2023
1
2022
5
2021
20
2020
19
2019
9
2018
6
2017
15
2016
10
2015
6
2014
1
2011
2
2010
1
2008
5
2006
4
2005
3
2004
3
2003
3
2002
2
2001
1
2000
2
1999
1

What owners say

Filed Jun 26, 2026 · Fuel system · PA

This model has the same Bosh CP4 high pressure fuel pump as the recalled models 2020-2022 and in fact being older the catastrophic failure risk is higher due to additional mileage. If this part fails the engine shuts off with loss of steering and braking even when pulling 15-20K pounds. The safety concern for this year is the same or greater then newer models.

Filed Mar 21, 2025 · Fuel system · 154,000 miles · NJ

The contact owns a 2019 Ford F-350. The contact stated that while driving at 70 MPH, the vehicle lost motive power. The low fuel pressure warning light was illuminated. The vehicle was started. The vehicle was driven to the shoulder of the roadway. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the vehicle had been to the dealer several times for the failure. In addition, the low-pressure fuel pump was replaced in 2024; however, the failure reoccurred. In addition, the contact stated that the vehicle was taken to the dealer more than fourteen times regarding the failure. The contact stated that the failure occurred while the vehicle was driven above 50 MPH. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 154,000.

Filed Feb 26, 2025 · Fuel system · AZ

The CP4 fuel pump failed causing the entire fuel system to be replaced. It is the same pump that is covered in the recall for 2020-2024 6.7 engines.

Filed Feb 7, 2025 · Fuel system · 65,788 miles · FL

The contact owns a 2019 Ford F-350. The contact stated while routine maintenance was being completed on the vehicle by a certified mechanic, the contact was informed that there were metal shavings inside the fuel pump. The mechanic informed the contact that the fuel pump needed to be replaced. The vehicle had not been repaired. The contact searched online and became aware of the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel) and related the failure to the recall. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 65,788.

Filed Jan 30, 2025 · Engine, Fuel system · TX

the CP4 fuel pump sent metal shavings into the fuel injectors and the engine quit. no warning light came on at all. the entire fuel system had to be rebuilt. This happened in the middle of the night on [XXX] in shreveport LA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 13, 2024 · Engine · 164,000 miles · MD

The contact owns a 2019 Ford F-350. The contact stated that the vehicle started to lose motive power while driving 70 MPH. The "Power Reduced Mode" message was displayed, and the contact activated the hazard lights and pulled over to the shoulder of the highway. The contact restarted the vehicle however, the failure persisted while driving back to the residence. After arriving to the residence, the contact used a code reader and retrieved a code for a fuel system leak. The contact had the vehicle towed to a dealer where a diagnostic test was performed. The contact received a call from the dealer and was informed that there were metal shards from the fuel pump found in the fuel tank. The contact was provided an estimate for the repair. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 164,000.

Filed Sep 17, 2024 · Fuel system · 58,000 miles · OH

The contact owns a 2019 Ford F-350. The contact stated while driving approximately 45 MPH, the vehicle lost motive power without warning. The contact coasted to the roadside and replaced the fuel filters. The vehicle started but remained idling without the proper RPM. The contact was able to get the vehicle to drive at slower speeds only. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the fuel return line was malfunctioning due to the high-pressure fuel pump failure. The contact was informed that the fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 58,000.

Filed Jun 3, 2023 · Fuel system · NY

Fuel Filter Failed and Is available for inspection: Driving back from Gloucester Ma to Cohoes NY, pulled into Charlton Ma rest stop on I90 parking in truck area fueling lot noticed fluids leaking from engine compartment, upon further inspection found fuel filter spraying diesel fuel all over engine compartment and components. My life, my passengers and surrounding personnel may have been injured or killed if went un noticed for too long while parking next to fuel pumps when engine was running or driving along I 90. There were no warning lights indicating loss of fuel pressure or any sort of engine light on. Luckily I noticed it before it could get out of hand and happened during a week day during business hours a local ford dealer, IDA Ford in Auburn Ma had a fuel filter kit in stock: They also stated they just had another customer a few days earlier with the same issue. Had to Uber to and from dealer to get parts to repair. Poured water on engine to break down diesel fuel over engine to drive back to NY and not cause a fire. Looking online for a recall and don’t see my year of vehicle but just 2021????

Filed Jun 3, 2023 · Fuel system · NY

Fuel filter and is available for inspection-Driving back to Cohoes NY from Gloucester Ma pulled into Charlton Ma rest stop to use the restrooms, while getting ready to leave started vehicle and got out waiting for passengers noticed fluids leaking from engine compartment, while inspecting found it was diesel fuel and spraying out of fuel filter on top of engine block. Then noticed a trail of diesel fuel from my path going into rest stop. I parked next to the fuel pumps if that had ignited my life, my passenger and the people in the rest stop life would’ve been endangered. Luckily I caught it before anything happened. I was able to reach a local ford dealer for parts and Uber to and from and repaired. Pouring water over engine to dilute remaining fuel over engine. No warning or engine light came on warning of loss of fuel pressure.