2014 Ford Flex engine problems

Filed Jan 24, 2026 · Electrical, Engine · CA · fire

After reporting to work on [XXX], I discovered that the front of my vehicle was on fire. Emergency services were immediately contacted, and employees on site attempted to contain the fire using fire extinguishers. The fire department arrived shortly thereafter and successfully extinguished the fire. Despite these efforts, the vehicle was ultimately deemed a total loss. Later that day, my sister advised me to review footage from our Ring camera from that morning. The video shows visible sparks coming from underneath my vehicle prior to my departure. At that time, I drove approximately nine miles to work, unaware of any issue with the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 22, 2025 · Driver assistance, Engine · 120,000 miles · OH

The contact owns a 2014 Ford Flex. The contact stated that occasionally, while attempting to reverse, the image on the back over prevention camera was displayed upside down. Additionally, the check engine warning light remained illuminated. The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 120,000.

Filed Apr 30, 2025 · Engine, Steering · 130,400 miles · IL

The contact owns a 2014 Ford Flex. The contact stated that while driving at various speeds; the vehicle lost automotive power and the steering wheel was pulling to the left and was difficult to turn in either direction. No warning light was illuminated. An appointment with the local independent dealer was scheduled to inspect the vehicle. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the Year, Make, and Model being outside the selected VIN range. Upon further investigation, the contact related the failure to an unidentified the federal safety agency Campaign; however, the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 130,400.

Filed Mar 15, 2023 · Engine, Fuel system · MN

Driving down road at 45MPH, vehicle lost power, motor quite running. Due to being on 4 lane divided road, and cars all around, I quickly hit my hazard lights, put it in neutral and coasted best I could and was able to turn on a side road to safety. This was very dangerous. Dash lights were on, no warning lights, messages before, during or after event. Tried restarting vehicle and it cranked away. Figured out had to repush the push start button to keep it from cranking away longer. Towed to local Ford dealer. They determined cause to be Fuel Pump Driver Module failed, (explains engine stop since there was no fuel supply, and needed replacement. In addition I had another issue, they found water pump was leaking out weep hole. I then discovered they built the water pump into the engine block, behind the timing chain. It takes 13 hours to replace, and if you don't replace, the water goes into the engine oil. Very bad design, knowing it would need to be replaced. Cost over $2500 and 1 week to change a water pump! Ridiculous. I know a class action lawsuit has been filed-while not a safety issue directly, I think many people will not change it (due to expense), and then the engine blows up while driving creating a safety hazard.

Filed Jan 31, 2023 · Engine · 100,000 miles · GA

The contact owns a 2014 Ford Flex. The contact stated that while the vehicle was parked in the garage, there was fluid leaking underneath. No warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the water pump assembly and timing chain needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The approximate failure mileage was 100,000.

Filed Jan 20, 2023 · Engine · 130,000 miles · FL

The contact owns a 2014 Ford Flex. The contact stated while approaching the vehicle, he noticed a fluid leak underneath the engine. The contact took the vehicle to an independent mechanic and was informed that the water pump and timing chain needed to be replaced. The vehicle was not repaired. The contact called the local dealer and made them aware of the failure. The manufacturer had not been informed of the failure. The failure mileage was approximately 130,000.

Filed Oct 20, 2022 · Electrical, Engine · CA

Approximately 2 months ago car would not start. Towed to dealer on Friday. Dealer evaluated it on Monday but car resumed starting. Retrieved car. This morning problem returned. Having already done a lot of research on this apparently common issue it seems most of the time it is the fuel pump control module located behind the plastic trim on the passenger side B pillar. A replacement part was acquired from a Ford Parts Dealer and installed into the car. Car starts and runs fine now.

Filed Feb 12, 2021 · Engine · 70,000 miles · FL

Same issue as recall 16s46 with faulty turbo oil supply line leaking. Ford covers mfg years 2016-2017, but is denying coverage for the subject 2014.

Filed Oct 29, 2020 · Engine · 130,000 miles · NC

Low engine oil pressure light flashes with oil smell and squeaking pulley that holds serpentine belt. Burning oil smell, dealer replaced oil sending unit, water pump and replaced valve cover gaskets.

Filed Aug 13, 2020 · Engine · SC

My car indicated that the engine coolant was over temperature while sitting in a parking lot.. I had coolant added with 50% water. The coolant leaked completely out within 24 hours and started alerting me of the same problem