Ford Focus brake failure problems

Filed Oct 4, 2026 · Brakes, Transmission · MI

I am reporting severe, life-threatening pre-existing safety defects involving the mechanical braking system and the dual-clutch transmission assembly on my 2017 Ford Focus. After purchasing the vehicle from a dealership under the fraudulent written assurance that a safety inspection was completed, I was forced to drive the vehicle a long distance across state lines with my pregnant fiancée and my [XXX] daughter inside. Immediately upon arrival, a certified multi-point mechanical safety inspection at a Ford facility uncovered that the vehicle was completely unroadworthy and posed an immediate hazard to public safety. The safety inspection documented a catastrophically failing transmission clutch assembly, completely rusted-out and failing rear brake rotor/pad assemblies, bad wheel hub bearings, and severely degraded drive belts. The immediate degradation of the dual-clutch power train and the mechanical brake failures under highway conditions created an extreme physical safety risk, including potential wheel lockup and immediate power loss on the highway. I request that this failure list be officially attached to the ongoing federal defect investigation for this vehicle model's power train and braking components to protect other consumers from fatal highway failures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 20, 2026 · Brakes, Electrical · PA · crash · 1 injury

[XXX] driving her 2016 ford focus hit me [XXX] she claims her btakes did not work hitting multiple times she hit me so hard her car flew many feet back. I believe her car was defective it was alittle snowy but nothing bad. [XXX] said her brakes did not work at all. Me and multiple cars were able to come to complete stop with no skidding i have toyota rav4. I think her car might have been told my car needed repairs. I was severely injured severe permanent concussion brain neck back shoulder arm hand chest back muscle nerve damage. Dunno if [XXX] was also injured INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 25, 2025 · Brakes · AL · crash · 2 injuries

The brakes went to the floor and the whole car locked up. When I pressed the brakes to slow down it felt like something on the brakes just fell apart. I was in a car accident because of this I hit another car no no

Filed Jun 20, 2025 · Brakes, Engine · 160,000 miles · MI

The contact owns a 2016 Ford Focus. The contact stated while driving approximately 70 MPH, the "Oil Pump" message became displayed, and the vehicle decelerated and stalled. Additionally, during the failure there was a loud knocking sound coming from the engine. The contact stated that the brakes failed to function properly while the brake pedal was depressed. The vehicle was towed to the local dealer who determined that the engine had failed; however, the cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 160,000.

Filed May 29, 2024 · Brakes, Transmission · GA

On [XXX] 2023, while driving on [XXX] near Dalton GA the brakes did not work. As i exited from the highway i could not stop the car, the brakes did not work. No warning lights showed up on the dashboard. I had to engage the emergency break to get the vehicle to stop. When i had the vehicle towed to the dealership for repairs it was discovered that two of the 3 pistons were not working, the break pump failed and the oil pump failed. If i had to stop suddenly on the highway, i would not have been able to do this. I would have likely crashed into something. This recall needs to be elevated as Ford has still not notified anyone of the needed repairs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 3, 2024 · Brakes, Driver assistance · IA

Intermittent loss of brake pressure. ABS would activate and leave the brake pedal feeling soft and having low brake pressure. This problem would randomly fix itself and then randomly happen again while braking normally or after the ABS would engage. Sometime the problem would last for weeks until suddenly the brake pedal would be firm and have strong brake pressure.

Filed Feb 17, 2024 · Brakes, Engine · GA

While driving on I75 the car started to act funny. No issue indicating lights came on the dash board. I exited the highway and the brakes did not work. I was able to get the car to eventually stop without damaging anyone. I had to use the hand break. My foot had the break peddle all the way to the floor and that would not stop the car. Once the car was stopped the check engine light came on when i tried to start the car. The car was towed to the nearby Ford dealership who determined the oil pump failed which caused the turbo to fail and 2 of the 3 pistons to fail. Engine, oil pump and turbo all had to be replaced. The break pump also had to be replaced. These were all related to the oil pump failure. This could have been so much worse had i had to slow down or come to a sudden stop on the highway. Or if there was any oncoming traffic at the exit intersection i had to go through without breaks.

Filed Feb 5, 2024 · Transmission · 80,000 miles · MI

The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the brakes failed to function as intended. The contact depressed the brake pedal and the vehicle stalled. Additionally, the contact stated that when the accelerator pedal was depressed, the vehicle failed to accelerate as intended. The vehicle was taken to the dealer where the vehicle was diagnosed with a failed clutch pack and that the clutch pack needed to be replaced. The contact was informed that the failure was not eligible to be covered under warranty because the failure was not severe. The vehicle was not repaired. The contact was informed that if the repair was paid for out of pocket, to keep the receipt to be eligible for reimbursement later. The manufacturer was made aware of the failure and advised the contact to report the failure to the federal safety agency Hotline. The failure mileage was approximately 80,000.

Filed Sep 25, 2023 · Brakes, Engine · IN

Vehicle has less than 70,000 miles on it. While driving lost oil pressure and brakes. Yes available for inspection. When pressure was lost and brakes failed I could not have stopped to avoid an accident. Multiple articles on the pump failure. Spoke with Ford they say not their problem. No warning. Engine light came on with brake light while driving. Car has been sitting parked. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 4, 2023 · Brakes · MA

[Two incidents involving the same ABS control module. Early January 2023 and Late May 2023] ABS control module failed while going downhill (valve stuck open). Resulted in the brake pedal going to the floor. Had to stop by downshifting and the using hand brake. Whenever brake pedal is pressed after this, it goes a random distance to the floor with no pressure before applying some brake. Ford quoted me a 1 year lead time on replacing the part (and mentioned this is part of a pending recall. This recall will come out after they redesign a new module). They refused my request for a rental/loaner vehicle until it is fixed. I brought it to an independent garage to get the unit replaced. After that, my brake pedal worked as expected for a few months. Last week, the pedal went to the floor again. I brought it to a Ford dealership, and they confirmed that the new module already experienced the same failure as the original one. It is currently at the dealership, who will not have a part to repair my car again until August. I was refused a loaner vehicle by both the dealership and corporate Ford over this PENDING SAFETY RECALL, where they are unable to fix my car. I was told by they dealership that they won't stop me from driving my car in the mean time if I feel safe doing so. It is not safe, so I am leaving the car at the dealership. I do not have a date for when a new revision module will be made, along with official recall. Ford is refusing to reimburse me for my initial repair until they get around to officially announcing the recall. I also found out from them that they reprogrammed the ABS control module back in March 2013 while they reprogrammed a different module (I only new about the TCM reprogram). This means they knew the ABS module had issues 10 years ago, a month after I bought the car. They did nothing for 10 years despite the Fusions having the exact same issue. This is a blatant disregard for the safety of their customers' safety.