Ford Focus stalling problems

Filed Nov 3, 2026 · TX

I am filing this complaint regarding my 2016 Ford Focus S and concerns about a potentially recurring safety defect associated with Ford’s safety recall involving the canister purge valve. My vehicle experienced a no-start condition and stalling. The vehicle became inoperable and had to be towed to an authorized Ford dealership for inspection. These symptoms are particularly concerning because the recall information describes the possibility of engine stalling and difficulty restarting the vehicle. The dealership informed me that the recall had previously been performed on my vehicle. However, despite the recall repair, my vehicle experienced symptoms consistent with those described in the recall. The dealership was able to start the vehicle when it arrived and stated that it could not reproduce the problem. The dealership subsequently performed diagnostic testing on a dyno but claimed that the issue was unrelated to the recall. No definitive cause for the no-start and stalling condition was identified. I was charged $219 for the diagnostic testing. I am concerned that the dealership’s inability to reproduce an intermittent problem does not establish that the underlying safety defect has been corrected or that the current symptoms are unrelated to the recalled component. A vehicle that unexpectedly stalls or fails to restart creates a serious safety risk. If the engine stalls while driving, the driver could lose power and potentially lose power steering assistance and normal brake assistance. The vehicle could become disabled in traffic, at an intersection, or in another dangerous location. A vehicle that unexpectedly fails to restart could also leave the driver stranded in an unsafe location.The problem was intermittent, which may explain why the dealership was unable to reproduce it during its inspection. I am requesting that the federal safety agency investigate whether the recall remedy is adequately addressing this safety concern and reimbursement of a diagnostic and tow fee.

Filed Oct 13, 2026 · Engine, Fuel system · KY

The vehicle is subject to the federal safety agency Safety Recall Campaign 18V‑735 (Ford Recall 18S32) regarding a defective Canister Purge Valve (CPV) that causes fuel vapor saturation, excessive fuel tank vacuum, fuel tank deformation, and engine stalling.The vehicle presented with an active check engine light for diagnostic trouble code P0420 (Catalyst System Efficiency Below Threshold). Ford technical service instructions under Recall 18S32 explicitly link code P0420 to a stuck-open CPV dumping unmetered fuel vapors into the exhaust stream. The franchised dealership initially performed only a software calibration without replacing the mechanical valve.Upon return, the dealership confirmed the defect and replaced the CPV under recall warranty at no charge on Repair Order # 872120. However, dealership service management refused to inspect the catalytic converter for secondary fuel-wash damage unless an unauthorized $220 customer diagnostic fee was paid. The technician cleared the diagnostic trouble codes in the stall without executing the required OBD-II drive cycle. Repair Order # 872120, Line C explicitly documents: "VEHICLE RELEASED FOLLOWING COMPLETION OF RECALL 18S32 WHERE CPV WAS REPLACED. P0420 STATUS PENDING DRIVE CYCLE COMPLETION". Following completion of the required drive cycles, code P0420 returned immediately. Secondary catalytic converter degradation is documented damage resulting directly from the recalled component. Dealership service management has refused to return calls, disconnected phone contact, and ignored written inquiries to avoid submitting the required manufacturer Prior Approval warranty claim for secondary recall remedy. The vehicle and service records are available for inspection upon request.

Filed Oct 8, 2026 · Acceleration, Fuel system · OR

when the vehicle accelerates too quickly or up a very gradual hill, barely any slope, it will slow to a stop. this is in line with the current recalls with other Ford focus 2018s likely caused by the Canister Purge Valve. it has the exact same symptoms, poor fuel economy, rough idling so much so the entire vehicle shakes, and the dangerous part- stalling. I have now stalled 4 times and have been in and out of multiple mechanics for this issue and no one can seem to identify the root and it's getting costly. now they are saying it might be the canister purge valve but if it is I think it should be covered despite my vin not being perfectly aligned because it's ultimately the same issue with the same vehicle, make and model.

Filed Oct 5, 2026 · Fuel system · CA

The vehicle has a recurring fuel-level/distance-to-empty (DTE) malfunction that has caused it to run completely out of fuel and lose motive power while the instrument cluster indicates substantial remaining range. This has occurred four times. On the first three occasions, the vehicle ran out of fuel while displaying approximately 28-30 miles DTE. On two occasions, including the most recent, the engine shut off unexpectedly in the roadway and other motorists had to help push the disabled vehicle out of traffic. During the most recent incident, the vehicle displayed approximately 35 miles DTE when the engine shut off. There was no sputtering, warning message, warning lamp, or other indication that the vehicle was actually out of fuel. I previously brought the vehicle to an independent repair facility specifically for the inaccurate fuel/DTE indication and occasional stall-like behavior. Fuel trims were checked and no obvious cause was identified. I subsequently learned that Ford Safety Recall 18S32 had been performed on this vehicle in 2021, before I owned it. That recall addressed excessive fuel-tank vacuum/possible tank deformation and identified symptoms including inaccurate fuel gauge, inaccurate DTE, and possible stalling. I then brought the vehicle to an authorized Ford dealer and repeatedly identified the inaccurate fuel/DTE condition as my primary concern, including providing it in writing. The dealer performed a PCM update under another campaign, but the fuel-level/DTE malfunction was not diagnosed or repaired. After that dealer visit, the vehicle again ran out of fuel and shut off in the roadway, this time while displaying approximately 35 miles DTE. Roadside assistance was requested. The vehicle is available for inspection. Ford has been notified and an Automotive Safety case opened. The cause remains UNKNOWN. My concern is repeated unexpected loss of motive power while the vehicle indicates usable fuel remains.

Filed Oct 5, 2026 · Fuel system · 57,800 miles · NM

The contact owns a 2015 Ford Focus. The contact stated that the vehicle was previously repaired under the federal safety agency Campaign Number: 26V369000 (Fuel System, Gasoline); however, the failure occurred after the recall repair. While starting and driving at an undisclosed speed, the check engine warning light illuminated. The vehicle stalled after refueling, and the RPM fluctuated while idling. The contact turned off the vehicle and waited before restarting the vehicle. Additionally, the contact discovered that the fuel tank was deformed. The contact retrieved DTC: P1450. The vehicle was taken to the dealer, who determined that the canister vent valve needed to be replaced. The dealer informed the contact that the failure was not associated with the recall. The manufacturer was notified of the failure by phone. The failure mileage was approximately 57,800.

Filed Sep 29, 2026 · Transmission · OH

Back in July 2026 there was a rerecall for the 2018 recall that was not done correctly and my vehicle was not recalled for this when in fact that my vehicle should have it shows n I have proof that the recall number for that recall is the same recall they did on my vehicle but yet logged in under fuel tank defective but the recall number from 2018 match the new recall numbers issued in July for the recall that was performed in 2018 but yet I keep being told my Vin is not in the recently issued when it is decently is and should be cuz the recall number match and that is exactly what the issue is with my vehicle i have called since Feb 2026 about this issue and ever since the rerecall was issued but never showing my vehicle and it should be n I have proof that it match the recall numbers but logged in as different the. It should. Also my info is been correct since I got in feb2025 n yet only recall that was ever mailed was for a back up cam and that issued April 2026 n went to pervious owner which is my father address not mine like should I have proof of several recall that has been put out by either yall or manufacturer that never repaired or was never told it had my slef or my father when he purchased it I 2020 may n gave to me in feb2025 an was told that if he got car in 2020 that the dealer ship would fix the issue so was told after if it keep shuttering.Go to open rd safe give gas start at low gear n move up as speed increase it will clean off shutter will stop but yet still comes back so I have that along with it sticking in one gear idle in park high n then all sudden battery dies stalled got jump then lost reverse when out on a main rd real scary cuz if busy like normal it did that someone could been hurt cuz the problem that is causing issues is from 2018 recall that is july26 new recall number for the 2018 recall done didn't include mine should been i got proof big safety issue so parked cant drive risky need revised an fixed free an correct

Filed Sep 23, 2026 · Transmission · NC

My car had been driving fine. Until one day I leave my house and crank my car up and it does not go into reverse. It loses engine power and stalled into traffic. This is an on going issue as you can see stories from other people with the same make and model as my car with the same issue. No warning signs, hasn’t been checked out but I have contacted Ford and they only cover models with this issue 2012-2016. I think it should cover 2018 as well.

Filed Sep 20, 2026 · Transmission · TN

The DPS6 transmission started out shuddering in low gears even after clutch replacement early on. This made pulling out into traffic slower than it should be. Received “transmission overheating” message “pull over for 5 minutes” in heavy traffic. Prior to the message car would shudder and lose power. This happened suddenly going at highway speeds on the interstate. Replaced clutch actuators and TCM only to have the clutch adaptive learn procedure fail and after inspection by the dealer was told needs new transmission. These problems have been present at very low mileage and Ford now wants to charge a ridiculous amount to replace transmission that should have been fixed long ago. Several times the car stalled in traffic almost causing me to get in accidents.

Filed Sep 3, 2026 · Transmission · 133,283 miles · GA

The contact owns a 2014 Ford Focus. The contact stated that while driving approximately 30 MPH and coming to a stop, the vehicle unexpectedly stalled, and the transmission was slipping with the message “Transmission Overheated - Stop Vehicle” displayed. There was an abnormal odor coming from the vehicle while stopped. The contact stated that the vehicle was restarted, shifted to neutral, and remained stopped for 10 minutes before the vehicle returned to normal operation. The failure had occurred several times. Eventually, the vehicle was unable to be started. The vehicle was towed to the dealer, where it was diagnosed and determined that the clutch actuator and throw-out bearing had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 133,283.

Filed Sep 3, 2026 · Engine, Fuel system · IA

There was supposedly a recall of 2012-2018 Ford focuses such as mine, which is a 2018, but somehow my car is not included in this recall even though it seems to be affected by the same problem. I believe it to have a faulty purge valve (forgive me if I am not precise in my terminology) as it stalls after I get gas and try to start it up. I have to rev the engine to get it to stay on. I cannot stop after I get it started because it roughly idles and seems like it will shut back off if I do, which makes this a little dangerous as well as damaging for my car. I am distressed that my car is not included in this recall because I desperately need to repair it before I ruin my engine but I cannot because I don't have any money.