2016 Ford Focus: engine stalls while driving

Filed Nov 3, 2026 · TX

I am filing this complaint regarding my 2016 Ford Focus S and concerns about a potentially recurring safety defect associated with Ford’s safety recall involving the canister purge valve. My vehicle experienced a no-start condition and stalling. The vehicle became inoperable and had to be towed to an authorized Ford dealership for inspection. These symptoms are particularly concerning because the recall information describes the possibility of engine stalling and difficulty restarting the vehicle. The dealership informed me that the recall had previously been performed on my vehicle. However, despite the recall repair, my vehicle experienced symptoms consistent with those described in the recall. The dealership was able to start the vehicle when it arrived and stated that it could not reproduce the problem. The dealership subsequently performed diagnostic testing on a dyno but claimed that the issue was unrelated to the recall. No definitive cause for the no-start and stalling condition was identified. I was charged $219 for the diagnostic testing. I am concerned that the dealership’s inability to reproduce an intermittent problem does not establish that the underlying safety defect has been corrected or that the current symptoms are unrelated to the recalled component. A vehicle that unexpectedly stalls or fails to restart creates a serious safety risk. If the engine stalls while driving, the driver could lose power and potentially lose power steering assistance and normal brake assistance. The vehicle could become disabled in traffic, at an intersection, or in another dangerous location. A vehicle that unexpectedly fails to restart could also leave the driver stranded in an unsafe location.The problem was intermittent, which may explain why the dealership was unable to reproduce it during its inspection. I am requesting that the federal safety agency investigate whether the recall remedy is adequately addressing this safety concern and reimbursement of a diagnostic and tow fee.

Filed Oct 13, 2026 · Engine, Fuel system · KY

The vehicle is subject to the federal safety agency Safety Recall Campaign 18V‑735 (Ford Recall 18S32) regarding a defective Canister Purge Valve (CPV) that causes fuel vapor saturation, excessive fuel tank vacuum, fuel tank deformation, and engine stalling.The vehicle presented with an active check engine light for diagnostic trouble code P0420 (Catalyst System Efficiency Below Threshold). Ford technical service instructions under Recall 18S32 explicitly link code P0420 to a stuck-open CPV dumping unmetered fuel vapors into the exhaust stream. The franchised dealership initially performed only a software calibration without replacing the mechanical valve.Upon return, the dealership confirmed the defect and replaced the CPV under recall warranty at no charge on Repair Order # 872120. However, dealership service management refused to inspect the catalytic converter for secondary fuel-wash damage unless an unauthorized $220 customer diagnostic fee was paid. The technician cleared the diagnostic trouble codes in the stall without executing the required OBD-II drive cycle. Repair Order # 872120, Line C explicitly documents: "VEHICLE RELEASED FOLLOWING COMPLETION OF RECALL 18S32 WHERE CPV WAS REPLACED. P0420 STATUS PENDING DRIVE CYCLE COMPLETION". Following completion of the required drive cycles, code P0420 returned immediately. Secondary catalytic converter degradation is documented damage resulting directly from the recalled component. Dealership service management has refused to return calls, disconnected phone contact, and ignored written inquiries to avoid submitting the required manufacturer Prior Approval warranty claim for secondary recall remedy. The vehicle and service records are available for inspection upon request.

Filed Sep 20, 2026 · Transmission · TN

The DPS6 transmission started out shuddering in low gears even after clutch replacement early on. This made pulling out into traffic slower than it should be. Received “transmission overheating” message “pull over for 5 minutes” in heavy traffic. Prior to the message car would shudder and lose power. This happened suddenly going at highway speeds on the interstate. Replaced clutch actuators and TCM only to have the clutch adaptive learn procedure fail and after inspection by the dealer was told needs new transmission. These problems have been present at very low mileage and Ford now wants to charge a ridiculous amount to replace transmission that should have been fixed long ago. Several times the car stalled in traffic almost causing me to get in accidents.

Filed Aug 31, 2026 · Fuel system · MO

The contact owns a 2016 Ford Focus. The contact stated that the vehicle stalled while in active traffic. There was no warning light illuminated. Prior to visiting the dealer, the vehicle was taken to two independent mechanics and the vehicle was inspected. The contact was informed that the fuel tank had collapsed. The vehicle was subsequently taken to an authorized dealer for the repair. The dealer diagnosed the vehicle with a failed canister purge valve, but the fuel tank was not damaged. The dealer replaced the canister purge valve and EVAP parts. However, shortly after the repair, the vehicle stalled while driving in traffic. The vehicle was taken to another Ford dealer; however, the dealer experienced the same issue. The manufacturer was notified of the failure and referred the contact back to the dealer for assistance. The contact referenced the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline); but the recall repair was already performed on the vehicle. The failure was not repaired. The vehicle had lost motive power and would not restart and had to be towed. The failure mileage was unknown.

Filed May 26, 2026 · Electrical, Engine · PA

We bought this vehicle from Carvana in February 2023. Since very early on owning this vehicle, the engine hesitated and stuttered when trying to shift from first to second gear, and would lunge forward slightly. In December 2024, I received a letter from Ford Motor Company about a customer satisfaction program, Campaign 24N07. The letter addressed the symptoms my vehicle exhibited, including engine hesitation, engine running rough, and engine stalling at low speeds, though the check engine light was not on. The letter states that Ford Motor Company provides a one-time replacement of the canister purge valve, given these symptoms and the check engine light being on. When I called all the local Ford dealerships, they refused to do it because the check engine light was not on, and that Ford Motor Company issued this as a customer satisfaction program, rather than a safety recall.Everything that was listed in Campaign 24N07 is MOST DEFINITELY a safety issue, and should not be taken lightly. It is highly concerning that Ford Motor Company didn’t think to consider ENGINE ISSUES a safety recall. The class action lawsuit Vargas et al v. Ford Motor Company had a deadline of November 4, 2020, which was 2 years and 3 months prior to us buying the vehicle, so any vehicles of the affected years and models should have been either repaired, or not allowed to be sold unless the repairs were done by an authorized Ford dealership. This information was not told to us when we bought the vehicle.On May 25, 2026, while driving, the engine fault and steering assist fault warnings came on, as well as the check engine light. When we were able to safely park the car, we discovered the entire power train is non operational. The engine no longer turns over, and we are now having to buy a new car.

Filed May 5, 2026 · Engine, Fuel system · PA

Ford Motor issued two safety recalls regarding this, but has since closed them without providing a safe resolution for consumers. July 8 2019 Ford issued Ford Safety Recall program 19S22 (following 18S32) for stuck open canister purge valve (CPV). This can result in a failure to bleed the vacuum from the gas tank, and deforms the gas tank upon failure. This has been confirmed, reproduced, and recalled by Ford before, but continues to happen nationwide to Ford Focus ST owners as a small subset of their vehicles. A stuck open CPV can result in a number of codes. In my case, I got a P1450, Ford-Specific check engine light on the MIL. This can cause inability to start, along with rough idle and stalling while driving. Ford reports closing these safety recalls and provides no further support for the issue.

Filed Feb 11, 2026 · Acceleration, Engine · 150,000 miles · AR

The contact owns a 2016 Ford Focus. While operating the vehicle, the vehicle was shaking abnormally while idling, while low on fuel, while driving long distances, or while driving uphill. The vehicle shut off unexpectedly intermittently. On several occasions, the RPM increased; however, the vehicle failed to respond, and the vehicle eventually stalled. The accelerator pedal was depressed to the floorboard, but the vehicle failed to respond. The brake pedal became firm. The contact stated that the vehicle stopped and restarted several times or shut down unintendedly. After refueling, the contact had to wait for approximately 2 to 10 minutes before the vehicle responded as needed. Occasionally, the contact had to wait for over an hour before the vehicle was restarted. The check engine warning light illuminated intermittently and later turned off. While depressing the accelerator pedal, the engine revved excessively without the vehicle responding as needed. An abnormal sound was coming from the vehicle. The Oxygen sensor error code was displayed. The failure persisted over time. The vehicle was previously repaired at an unknown dealer under the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline). Additionally, the high-pressure fuel pump was replaced. The local dealer was not contacted regarding the current failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 150,000.

Filed Jan 14, 2026 · Transmission · 55,000 miles · NC

The contact owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle unexpectedly stalled with the message "Transmission Overheating" displayed. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The contact stated that the failure persisted. The manufacturer was not contacted regarding the failure. The failure mileage was 55,000.

Filed Jan 13, 2026 · Engine, Fuel system · SC

Fuel purge valve is malfunctioning. Vehicle loses power and is sluggish. Idles very rough and sometimes has a loss of power. My car has been at Ford twice in the last six months and problem still isn't fixed. Complete engine was replaced about a year and a half ago due to recall issue which I don't want happening again. I do not feel safe driving this car. I made an appointment with Ford a month ago for tomorrow for same stalling issue. I went to drop off and explain I wanted the repairs done for the recall to see if that fixed the problem. I filled up my gas tank on Sunday. The car wouldn't start and engine light came on saying engine failure service now. I let it sit for about ten minutes and it hesitantly cranked and engine light went off but accelerates slower with loss of power. It keeps doing this intermittently and sometimes loses power, and struggles when idling. I cut off let sit and then is okay until I pump gas again. I told the service repair person what happened and handed him the key to drop off the vehicle. He said if the light was not on at the time he would not be able to fix it and they couldn't schedule my vehicle for any additional recalls that are greatly needed for the car. It is running terrible. It idles and intermittently loses power while driving. Evan at Ford (Greer) response was to wait until it got bad enough that the engine light came on and stayed on. This was at D&D Ford in Greer, SC. He said it was Ford's policy the light had to be on to replace under recall with no charge. I told him it is unsafe to drive if it gets any worse it could cause an accident. I have two children and his recommendation to wait until it gets worse was appalling. He kept backlashing Ford and stated he doesn't work for Ford he works for D&D and only represents Ford. I said to him he was not representing Ford very well and that it was highly unlikely they would agree with his statements. I asked for documation of this policy--it contradicts what he says.

Filed Dec 18, 2025 · Fuel system · CO

The car is stalling randomly with no engine lights coming on

Filed Oct 9, 2025 · Fuel system · TX

Fuel pump went out and caused car to stall and leave me stranded on the side of the road when dash indicator showed 23 miles left to travel. I had this fixed through the dealership Drive Time sent me to mechanic shop as was still under dealership warranty.

Filed Aug 15, 2025 · Engine · 10,000 miles · MI

The contact owns a 2016 Ford Focus. The contact stated that the vehicle stalled while driving at various speeds and while idling. The contact was able to pull over to the side of the road. The vehicle failed to restart and had to be towed several times. The contact stated while driving 70-75 MPH, the vehicle stalled. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed with oil pump and fuse failure. The manufacturer was notified of the failure and related the failure to the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling). The VIN was included in the recall. The contact was charged a fee for the repair. The vehicle was not yet repaired. The failure mileage was approximately 10,000.