2014 Ford Focus: engine stalls while driving

Filed Oct 5, 2026 · Fuel system · CA

The vehicle has a recurring fuel-level/distance-to-empty (DTE) malfunction that has caused it to run completely out of fuel and lose motive power while the instrument cluster indicates substantial remaining range. This has occurred four times. On the first three occasions, the vehicle ran out of fuel while displaying approximately 28-30 miles DTE. On two occasions, including the most recent, the engine shut off unexpectedly in the roadway and other motorists had to help push the disabled vehicle out of traffic. During the most recent incident, the vehicle displayed approximately 35 miles DTE when the engine shut off. There was no sputtering, warning message, warning lamp, or other indication that the vehicle was actually out of fuel. I previously brought the vehicle to an independent repair facility specifically for the inaccurate fuel/DTE indication and occasional stall-like behavior. Fuel trims were checked and no obvious cause was identified. I subsequently learned that Ford Safety Recall 18S32 had been performed on this vehicle in 2021, before I owned it. That recall addressed excessive fuel-tank vacuum/possible tank deformation and identified symptoms including inaccurate fuel gauge, inaccurate DTE, and possible stalling. I then brought the vehicle to an authorized Ford dealer and repeatedly identified the inaccurate fuel/DTE condition as my primary concern, including providing it in writing. The dealer performed a PCM update under another campaign, but the fuel-level/DTE malfunction was not diagnosed or repaired. After that dealer visit, the vehicle again ran out of fuel and shut off in the roadway, this time while displaying approximately 35 miles DTE. Roadside assistance was requested. The vehicle is available for inspection. Ford has been notified and an Automotive Safety case opened. The cause remains UNKNOWN. My concern is repeated unexpected loss of motive power while the vehicle indicates usable fuel remains.

Filed Sep 3, 2026 · Transmission · 133,283 miles · GA

The contact owns a 2014 Ford Focus. The contact stated that while driving approximately 30 MPH and coming to a stop, the vehicle unexpectedly stalled, and the transmission was slipping with the message “Transmission Overheated - Stop Vehicle” displayed. There was an abnormal odor coming from the vehicle while stopped. The contact stated that the vehicle was restarted, shifted to neutral, and remained stopped for 10 minutes before the vehicle returned to normal operation. The failure had occurred several times. Eventually, the vehicle was unable to be started. The vehicle was towed to the dealer, where it was diagnosed and determined that the clutch actuator and throw-out bearing had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 133,283.

Filed Jul 28, 2026 · Transmission · 100,000 miles · OH

The contact owns a 2014 Ford Focus. While the contact’s son was driving at an undisclosed speed, the vehicle stalled. The vehicle was towed from the scene of the failure. The dealer was contacted and diagnosed the vehicle with a transmission module failure. The vehicle was repaired. The contact associated the failure with an unknown recall associated with the powertrain; however, the VIN was not under recall. The manufacturer was made aware of the failure but offered no assistance with repairing the vehicle. The failure mileage was approximately 100,000.

Filed Jul 21, 2026 · Engine, Transmission · 96,000 miles · PA

The contact owns a 2014 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The contact stated that the gear shifter was shifted from neutral(N), to park(P), and then to drive(D) for the vehicle to accelerate as needed. The check engine warning light was illuminated. The contact researched and became aware of an unknown recall; however, the VIN was not associated with a recall related to the failure. The vehicle was taken to a dealer where it was diagnosed and determined that the transmission clutch needed to be replaced. The vehicle was repaired. The vehicle was taken back to the dealer where it was diagnosed and determined that the powertrain control module needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 96,000.

Filed Apr 16, 2026 · Transmission · 74,000 miles · TX

The contact owns a 2014 Ford Focus. The contact stated that the vehicle was repaired under Manufacturer Recall Number: 14M02. However, after the repair was completed, the vehicle started stalling while driving at various speeds, and the transmission failed to shift above second gear. The failure was intermittent but was a recurring failure. The vehicle was taken to the same dealer several times; however, the dealer was unable to repair the vehicle. The vehicle was taken to another dealer, who scanned the vehicle and retrieved DTC: P0606 and P0702. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 74,000.

Filed Feb 26, 2026 · Electrical, Engine · WI

Transmission failure, lots of jerking. Also I think there are some electrical components messed up. As when my car is off no keys in the ignition, it sounds as if the engine try to turn over. Also when no keys in the ignition loud clicking noise comes from down by the transmission. Received multiple information dashboards messages started about 2 years ago.”Trasmission Failure” Only happened once each year in the past 2 years. I’d let the car sit for the weekend and then it would be fine to drive. Also related to this issue when the loud clicking noise comes from the Transmission while the car is off when I go to start the car it won’t turn over have to pump the gas pedal or put it in neutral and it will turn over. Also have had other dashboard messages a lot recently, but haven’t drove my car in 2 weeks as it’s unsafe as will stall up at stoplights. These include “Transmission overheated”. Brought it to Advanced Auto part to try getting codes to see what’s wrong, but all that would pop up on their reader was “Error”. Date below is when i received the first Transmission failure message. Happened again in May 2025, and now the car is undrivable as of February 10 2026. Video I’m attaching is the noise the transmission makes when the car is turned off with no keys in the ignition. Will not let me upload it. Can send it in an email when you respond. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 2, 2026 · Fuel system · 145,000 miles · CA

The contact owns a 2014 Ford Focus. The contact stated that after refueling, the vehicle shook abnormally and stalled. The vehicle was restarted and driven to the residence. The contact referenced the federal safety agency Campaign Number: 18V735000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was taken to a dealer; however, the vehicle was not repaired, and the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 145,000.

Filed Jan 8, 2026 · Fuel system · 190,000 miles · MI

The contact owns a 2014 Ford Focus. Upon investigation, the contact found notifications of the federal safety agency Campaign Numbers: 18V735000 (FUEL SYSTEM, GASOLINE) and 20V331000 (LATCHES/LOCKS/LINKAGES) associated with the VIN. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle stalled. The vehicle was shifted into neutral(N) and coasted to the side of the road. The check engine warning light illuminated. The contact waited for one to two hours before restarting the vehicle. The accelerator pedal was depressed at the same time while starting the vehicle. The vehicle was taken to the dealer; however, the contact was informed that the vehicle was serviced under the federal safety agency Campaign Number: 18V735000 (Fuel System, Gasoline) in 2019. The vehicle was not inspected, diagnosed, or repaired. The contact was the second owner of the vehicle and was unsure if the previous owner had repaired the vehicle under the recall. The contact searched on the website, and the website indicated that the recall was incomplete. The contact stated that the failure had become worse. The manufacturer was not made aware of the issue. The failure mileage was approximately 190,000.

Filed Oct 14, 2025 · Engine · WA

I just bought my focus from CarMax and it shudders when I pull out. It makes me feel like the car will stall.

Filed Sep 28, 2025 · Transmission · KY

I am having an issue with the duel transmission. My car has been stalling making it unsafe. It has been giving me a warning saying the transmission is overheating even just driving short distances. The clutch A has been getting stuck and not dis engaging causing the car not to be able to shift gears. I have spent all of the money I have on this car and can’t afford to pay money to get it fixed when ford is aware of the issues when it was manufactured. They have issued recalls and are responsible to fix the problem. The recall needs to be extended so that hard working tax payers like me don’t feel screwed over by ford and out of so much money. I feel taken advantage of. And I’m broke , stuck with a car that is unsafe to me or others on the road.

Filed Aug 29, 2025 · Engine, Transmission · 136,000 miles · WI

The contact owns a 2014 Ford Focus. The contact stated that while depressing the accelerator pedal, the vehicle failed to respond as needed. The contact stated that while driving at various speeds, the engine overheated, and the vehicle hesitated and stalled. The check engine warning light illuminated. The dealer was contacted. The vehicle was taken to the dealer to be diagnosed, and the contact was informed that the clutch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and offered no assistance. The approximate failure mileage was 136,000.

Filed Aug 18, 2025 · Transmission · 81,000 miles · PA

The contact owns a 2014 Ford Focus. The contact stated that while depressing the accelerator pedal, the vehicle failed to properly accelerate. The vehicle decelerated and stalled. The vehicle failed to restart and was later towed to the local Pep Boys Service Center. The service mechanic diagnosed the vehicle and determined that the TCM was faulty and needed to be replaced. The vehicle was not repaired and was later towed to the local dealer. The local dealer also stated that the TCM was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the vehicle was not eligible for the Extended Warranty for the failure. The failure mileage was 81,000.