2012 Ford Focus: engine stalls while driving

Filed Aug 26, 2026 · Transmission · 112,200 miles · OH

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly decelerated and stalled. The vehicle was able to restart but failed to move. The message "Transmission Failure" was displayed. The vehicle was towed to the residence and was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that the vehicle was not covered under the Customer Satisfaction Program: 14M02 (Transmission Control Module Extended Warranty Coverage). The failure mileage was approximately 112,200.

Filed Aug 25, 2026 · Transmission · 70,000 miles · OH

The contact owns a 2012 Ford Focus. The contact stated that while driving approximately 60 MPH, the check engine warning light illuminated, with an abnormal sound coming from the vehicle before the vehicle stalled. The contact stated that an independent mechanic arrived on the scene to reset the clutches, and the vehicle was taken to an independent mechanic. The contact used an OBD scanner and retrieved information that the clutch position sensor A, clutch position sensor B, the actuator control circuit, the shift control circuit, and several other unknown parts needed to be replaced. The vehicle was not repaired. The contact researched and was made aware of an unknown Customer Satisfaction Program; however, the vehicle was not included. A dealer was contacted and confirmed that the vehicle was not included. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Filed Aug 21, 2026 · Fuel system · MN

SAFETY DEFECT AND RECALL REMEDY REFUSAL REPORT: My 2012 Ford Focus is actively experiencing severe safety failures matching the known defects in Ford Recall Campaign 26S40 (the federal safety agency Campaign Number 26V369) for the canister purge valve. While operating the vehicle, the engine suddenly stalled, creating an immediate highway safety hazard. Diagnostic scans show critical low fuel pressure. A physical inspection reveals that the fuel tank and the attached heat shield are severely warped and deformed. This structural damage is a direct result of the defective purge valve sticking open, creating an excessive internal vacuum that collapsed the fuel delivery module and tank assembly. I had the vehicle towed to an authorized Ford dealership (Apple Ford in White Bear Lake, MN). The dealership service department is actively refusing to honor or perform the mandated remedy under the federal safety agency Campaign 26V369. The technician stated that because a previous, legacy software update was noted in their system, "nothing more can be done." This directly violates the June 2026 re-recall mandate, which was issued precisely because previous software fixes were incomplete or improperly performed. Furthermore, the dealership is attempting to charge me an unauthorized diagnostic fee for an open safety recall inspection, refusing to inspect the physically collapsed gas tank, and making verbal, undocumented claims about frame rust to avoid performing the safety remedy. The vehicle is currently stranded at the dealership, unrepaired, and remains an active safety hazard. I am requesting that the federal safety agency investigate this dealership's refusal to comply with a federal safety recall mandate and force Ford Motor Company to replace the damaged fuel system components as required by law.

Filed Aug 19, 2026 · Fuel system · TX

My complaint is for serious safety concerns on my 2012 Ford Focus and the handling of recall 18S32 and 26S40 by Ford Motor Company. My fuel tank is visibly deformed in the exact strap area described in the recall, and I have physical proof and photographs confirming this. On XXX, a Ford technician found deformation during dispatch by local dealer to complete Recall 26S40. When I brought the vehicle to Viva Ford in [XXX], service manager and his master tech confirmed problem. They began avoiding the repair of course. Called Ford and they gave the same horrible customer service. Insistent that there were no recalls. Escalated to BBB and Ford had the audacity to simply reply that because there were no open recalls they would not be moving forward with a repair. Ford issued recall because many Focus vehicles were incorrectly marked as “repaired” by recall 18S32 years ago and they were actually never even repaired at all. Ford has publicly acknowledged these “phantom fixes.” While 26S40 is only a software patch, it does not eliminate eligibility for a tank replacement. In fact, in the service manager at the dealership even sent me official Ford literature which I will attach that states a claim can be made for related repairs needed that stemmed from these original recalls. Because the original software fix was never properly applied, my canister purge valve likely stuck open for years, causing the tank deformation that falls directly under recall 18S32 and the subsequent 26S40 where the Service Manager and Master Technician have confirmed my problem. I have never received a fuel‑tank recall repair, yet my tank is deformed and unsafe because it can fall off from my vehicle while in motion and cause me to stall abruptly. This is the safety issue at hand. Both Ford and Viva Ford dealership are refusing to repair it despite evidence and recall criteria that match my vehicle’s condition. I am appalled at their avoidance to fix my problem. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

Filed Aug 11, 2026 · Engine, Fuel system · 130,000 miles · TX

The contact owns a 2012 Ford Focus. The contact stated that the vehicle previously failed the vehicle state inspection due to the check engine warning light being illuminated. Additionally, the vehicle stalled intermittently while driving. The contact had to pull over, wait, and then restart the vehicle. The vehicle was taken to the dealer, who performed an unknown recall repair for the canister purge valve, but the failure persisted. The vehicle was then taken to the second dealer, Group 1 Ford of Southwest Houston (6445 Southwest Fwy, Houston, TX 77074), who performed another unknown recall repair for the canister purge valve, but the failure reoccurred. The contact later received notification of the federal safety agency Campaign Number: 26V369000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealers were made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.

Filed Jul 11, 2026 · Engine · HI

On XXX I received email from CARFAX regarding my vehicle recall "26S40 PCM REPROGRAMMING FOR FUEL TANK DEFORMATION”. I contacted Ford Cutter Hawaii answering spoke with [XXX] over the phone regarding the recall, she asked me to forward the email then she after she read the email she dismissed the information as not reliable as it came from Carfax. She will only follow up if I got recall notice in the mail. XXX my car stalled in the middle of freeway and got towed. At the time the reading of fuel is low but not empty. The car started and only run for 1-2 seconds before it died again. That is very similar symptoms described in the recall information: "Safety Risk THIS MAY RESULT IN AN ENGINE STALL WHILE DRIVING WITHOUT WARNING OR WITHOUT THE ABILITY TO RESTART AND CAN INCREASE THE RISK OF A CRASH.” End of complain. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 3, 2026 · Fuel system · AZ

Days after changing the purge valve on my car, because it had failed. I was driving on the freeway confident because my screen said 15 m left before running out of gas, then the engine stalled and lose power. The lights were on but the engine stopped running while driving on the freeway. Turned out I had runned out of gas but the computer was misreading it.

Filed Jun 16, 2026 · ID

Vehicle stalls while driving at low speeds and during acceleration. The engine loses power unexpectedly in traffic and may shut off completely while in motion. RPMs increase without corresponding acceleration and the vehicle fails to shift or respond normally. Check engine light is on with fuel/emissions-related codes. Fuel gauge is inaccurate and vehicle has unexpectedly run out of fuel even when gauge showed remaining fuel. The vehicle also hesitates, jerks, and feels unstable when stopping or turning. These issues have been present since shortly after purchase and have continued for approximately one year. Vehicle is unsafe to operate due to risk of stalling in traffic.

Filed Mar 10, 2026 · Transmission · OK

The transmission begin to stall and would not shift. The motor would get to high RPMS and then shift hard into the next gear. I was able to pull over and the TCM error code popped up on the dash. I was able to get the car to the dealer. I was notified that the TCM failed and Ford would no longer cover this failed part. The car is a 2012 Focus with only 69,000 miles. Dealership is wanting $2,116.00 to fix.

Filed Jan 22, 2026 · Fuel system · OH

After receiving program #24N07 on 12/04/2024, my 2012 ford focus was stalling out while downshifting to stops and after refueling, this happened around the 1st week of December of 2025 about a year after getting it repaired by the Ford dealership in my area. Replaced it myself this time, but sort of crazy to have to replace yet another purge valve just a year after.

Filed Jan 5, 2026 · Transmission · OH

I am the owner of a 2012 Ford Focus SE with approximately 54,000 miles. Beginning around 44,000 miles, the vehicle exhibited transmission shuddering, harsh engagement, and improper downshifting consistent with known DPS6 Transmission Control Module (TCM) defects. Prior to the expiration of Ford Customer Satisfaction Program 14M02 on June 30, 2025, I confirmed coverage through Ford’s recall website and presented the vehicle to an authorized Ford dealership on May 27, 2025 (documented in Carfax). The dealership declined repair, stating no diagnostic trouble codes or warning indicators were present and incorrectly advised that customer satisfaction programs do not expire. On December 18, 2025, while driving at highway speed, the vehicle experienced sudden loss of drivability. Traction control was disabled, hill assist became unavailable, engine RPM increased abnormally, and the vehicle stalled in traffic. The instrument cluster displayed “Transmission Malfunction – Service Now.” The vehicle would not restart and required towing from the roadway, creating a hazardous traffic situation. The dealership later diagnosed a complete TCM failure and provided a repair estimate of approximately $1,800. Ford Motor Company has publicly acknowledged widespread TCM defects in 2012–2016 Ford Focus vehicles and issued multiple recalls and customer satisfaction programs, including later supplements authorizing TCM replacement rather than software reprogramming. Despite my documented attempt to obtain service before the program deadline, Ford denied coverage solely due to expiration. Ford corporate denied goodwill assistance, refused supervisor escalation, and asserted that a TCM software reprogramming performed in 2016 at approximately 19,000 miles resolved the issue. Software reprogramming does not correct the underlying hardware defect and only delays failure. This vehicle has experienced repeated transmission-related failures under 54,000 miles and remains disabled at the dealers

Filed Sep 16, 2025 · Fuel system · NC

Everytime I go to get fuel the car will not crank it makes a terrible noise then cranks but its slow. The pressure in tank causes it to stall out.