2012 Ford Focus: sudden loss of power

Filed Sep 1, 2026 · Engine · WA

I am submitting this complaint because Ford dealers do not appear to be following Ford Motor Company's published procedure for Customer Satisfaction Program 24N07. I visited two Ford service departments in [XXX] and [XXX]. Both told me they must first perform their own diagnostic evaluation before replacing the canister purge valve (CPV) under 24N07, and that I may be responsible for a diagnostic fee if they do not confirm the issue. Both dealers justified this requirement by stating that it was mandated by Ford corporate. This appears inconsistent with Ford's XXX communication to all U.S. Ford and Lincoln dealers. The 24N07 Technical Instructions already provide a decision process: Step 1 directs technicians to check for specified DTCs, including P0443, OR determine whether the customer reports hesitation, rough idle, or loss of power. Step 2 asks whether any Step 1 condition is present. If yes, Step 3 directs the technician to replace the CPV. (PAGE 16) Nowhere in this procedure does Ford require a separate comprehensive EVAP diagnosis before replacement. Ford's labor operation also includes checking for DTCs as part of the 24N07 service. (PAGE 16) This is especially concerning because CPV-related symptoms can be intermittent. A vehicle may have rough idle, hesitation, loss of power, or a qualifying DTC, but operate normally during the dealer's diagnostic session. Under the dealers' approach, the owner may then be charged a diagnostic fee and still be denied the 24N07 repair. Similar experiences have been reported by other Focus owners online, including diagnostic-fee warnings of approximately $199, $210, $225, and $400. I ask the federal safety agency to review whether Ford dealers are properly implementing 24N07 and whether dealers are adding diagnostic requirements not contained in Ford's December 4, 2024 instructions. Ford 24N07: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 3, 2026 · Fuel system · AZ

Days after changing the purge valve on my car, because it had failed. I was driving on the freeway confident because my screen said 15 m left before running out of gas, then the engine stalled and lose power. The lights were on but the engine stopped running while driving on the freeway. Turned out I had runned out of gas but the computer was misreading it.

Filed Apr 28, 2026 · Electrical, Engine · GA

Beginning in approximately May 2025, the vehicle began displaying diagnostic trouble codes identified by independent auto parts retailers and service providers. These codes indicated potential issues within the engine, electrical, and powertrain systems. The vehicle was subsequently brought to a dealership for diagnostic evaluation and remained there from approximately May 15 through May 19, 2025. During this time, the dealership reported that no diagnostic codes were present and did not resolve the reported issue. However, the vehicle had recently exhibited repeatable symptoms, including entering “limp mode” and triggering diagnostic trouble codes, prior to being delivered to the dealership. Similar codes and issues were again identified after the dealership visit. The vehicle has experienced multiple incidents of entering “limp mode,” resulting in sudden loss of power and reduced drivability while in operation. This condition occurred without reliable warning and created unsafe driving situations, including the inability to maintain normal traffic flow. Due to safety concerns, the vehicle has not been driven under normal conditions since approximately May 2025 and has been limited to short, local movements only. The issue poses a safety risk to the driver, passengers, and surrounding traffic due to unexpected loss of power and inconsistent system diagnostics. The problem appears to be ongoing and unresolved. Independent diagnostic records and service visit documentation are available upon request.

Filed Aug 8, 2025 · Electrical, Transmission · TX

I own a 2012 Ford Focus with approximately 51,000 miles. The transmission warning light came on, and I was informed by a repair shop that the transmission control module (TCM) and gears need repair. This vehicle uses the PowerShift dual-clutch transmission (DPS6), which has been the subject of a class-action lawsuit and multiple extended warranties due to widespread failures. The car exhibits jerking, delayed acceleration, and loss of power, which create dangerous driving conditions, particularly when merging into traffic or crossing intersections. Ford informed me I am outside the warranty period and refused to assist, despite this being a well-documented, recurring safety issue for which they have admitted fault in other cases. I am reporting this issue because it poses a serious safety hazard, and I believe the TCM defect should be subject to a mandatory recall. Ford is shifting the burden of a known manufacturing defect onto consumers, and this needs to be addressed before someone is injured.

Filed Jan 2, 2025 · Electrical, Steering · OH · 1 injury

During some Christmas shopping within the past few weeks, my cars power steering went out completely with no warning or sounds to repair or seek assistance. Not only was my life in danger, but the safety of others in the vehicles surrounding me. I couldn't even turn my wheel if I tried. There have been other instances in other cars where I could strong arm the wheel and be ok, but there was absolutely nothing I could do about turning the wheel whatsoever! When my dad came with power steering fluid, we discovered that these cars don't even have a reservoir for power steering fluid and that this was more than likely a battery or module issue or worse the power steering pump. This is ridiculous that there is no service light or warning that the power steering is going out or losing power. Ford should fix this because it seems like this is an ongoing issue with Fords in general

Filed Jan 2, 2025 · Steering · ID

Received Steering Assist Fault message. Vehicle has lost power steering ability without warning causing a safety issue

Filed Jul 29, 2023 · Fuel system · CA

My car is often displaying a pending P1450 (unable to bleed up fuel tank vacuum) check engine light code. Whenever, I fill my car with gas, it take a few tries to get the car to start. My car has also lost power several times while driving without warning - and took a while to re-start. I had to have my fuel tank replaced as it deformed and leaked gas to the point where it was un-fixable. Car symptoms of not starting after being filled with gas and losing power at random times while in operation have not been solved with the replacement of a brand new fuel tank. The P1450 error code still continues to come up suggesting a purge valve problem that will be expensive to fix, in addition to the fuel tank that has already needed to be replaced.

Filed Jul 27, 2023 · AR

sudden loss of power. would not stay in gear. took it to the ford dealer and they had to replace the TCM.

Filed Feb 8, 2023 · Steering · 50,000 miles · PA

The contact owns a 2012 Ford Focus. The contact stated while driving 30-35 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact was able to veer across a parking lot. The contact stated after investigating the failure online, she turned off the vehicle for a moment. The contact then restarted the vehicle while turning the steering wheel and the vehicle responded as needed; however, the failure reoccurred increasingly while driving. The message "Loss of Power Steering Assist" was displayed. The vehicle was towed to an independent mechanic, where it was diagnosed that the electronic power steering rack and pinion and outer tie rod needed to be replaced. The contact related the failure to Ford Campaign Number: 15S08. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 50,000.

Filed Dec 27, 2022 · Transmission · IL

Transmission failure again after already having vehicle serviced by Ford dealership in Cedar Rapids Iowa due to fuel issue from what they said was the issue. Still showing same coded and same issues with hard shifting and vibration and loss of power while trying to drive. Nearly cause daughter to be in multiple accidents. Issue started at around 40k miles and still happening and put over $10k in parts in this car now. Including new exhuast manifold and catalytic converter, O2 sensor, new fuel pressure sensors, new throttle body and other parts all done by dealerships. Getting old chasing parts. Now another shop said I was told all wrong and it's been a Transmission issue this entire time and ford just didn't want to fix it.

Filed Dec 22, 2022 · Transmission · MI

Ford has acknowledged a problem with the Transmission Control Module (2012 Focus SEL) soon after this car was released. "Failure" caused the car to lose power while driving on the highway three seperate times. Warning light came on, but would go off after letting the car cool down. In 2015 and 2019 they sent notice to dealers, and to owners, to pay for replacement of this part if it failed up to 10 years or 150,000 miles. The issue for me is that my module finally required replacement (per dealer) after the "10 year point" at 89,700 miles. Software updates were done by Ford earlier for this issue, mine in 2019. (delivery was May 2012, replacement November 2022) I was also part of a class action lawsuit for this issue which Ford closed at the same "10 year point" leaving many customers now responsible for the replacement out of pocket, for me $1100, (part $967.21 - $300 core return charge, labor $428.99) or you have an undriveable vehicle. The second, even more frustrating, issue is that there are no Ford parts available to the dealer to even do this repair. I contacted Ford Customer Care directly, a case number was issued, was told they would "escalate my part request" but waiting period was minimum 4-6 weeks, unable to help me. Due to the lack of parts, I had to pay myself for a aftermarket module to be installed (thus now no coverage for labor charges per dealer for using an aftermarket part) after one month waiting for a Ford part, car sitting at the dealer, that two dealers told me would not available for months, if at all. As they KNEW this part was defective, replacement should have been done to all affected vehicles before they would fail, not making owners at risk for when the inevitable failures would occur.

Filed Aug 30, 2022 · Steering · 75,000 miles · PA

The contact owns a 2012 Ford Focus. The contact stated while driving 15 MPH, the vehicle lost power steering functionality. The contact was able to pull over safely. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the Electronic Stability Programme (ESP) needed to be replaced. The manufacturer was not contacted. The failure mileage was 75,000.