2016 Ford Focus: engine overheating

Filed Sep 20, 2026 · Transmission · TN

The DPS6 transmission started out shuddering in low gears even after clutch replacement early on. This made pulling out into traffic slower than it should be. Received “transmission overheating” message “pull over for 5 minutes” in heavy traffic. Prior to the message car would shudder and lose power. This happened suddenly going at highway speeds on the interstate. Replaced clutch actuators and TCM only to have the clutch adaptive learn procedure fail and after inspection by the dealer was told needs new transmission. These problems have been present at very low mileage and Ford now wants to charge a ridiculous amount to replace transmission that should have been fixed long ago. Several times the car stalled in traffic almost causing me to get in accidents.

Filed Jul 7, 2026 · Electrical, Fuel system · PA

Transmission overheated. Transmission fluid leaked but the computer in the car didn't let me know there was a leak. Couldn't move my car into reverse so I had to get a tow to Ford. They said it was a Transmission leak which caused the overheating. But once the car received Transmission fluid the car did not go into reverse. Clutch failed.

Filed Feb 5, 2026 · Transmission · TX

The vehicle experienced failure of the DPS6 dual-clutch automatic transmission. The transmission began slipping during acceleration, hesitating between gear engagement, and triggering a “Transmission Overheat” warning. Eventually, the vehicle lost the ability to reliably shift between Drive and Reverse and would not consistently engage gears. The vehicle can start and move forward but cannot reliably switch directions within the same ignition cycle. The vehicle is available for inspection. The transmission malfunction created safety concerns due to delayed or failed acceleration when entering traffic. The vehicle hesitated and slipped under throttle input, which could prevent timely acceleration when merging or crossing intersections. Additionally, the inability to reliably shift between Drive and Reverse could create hazardous situations in parking lots or emergency maneuvering scenarios. The sudden transmission overheat warning and gear disengagement could result in loss of power in traffic. The issue has been confirmed by an independent mechanic who diagnosed transmission failure. The vehicle has a known history of prior clutch replacement under similar symptoms. The transmission malfunction is consistent with documented DPS6 transmission failures in 2016 Ford Focus models. The vehicle has been inspected by an independent service center. The manufacturer has not inspected the vehicle. Prior to failure, the vehicle exhibited shuddering during acceleration from a stop, particularly at low speeds. This condition has been intermittently present for several years following a prior clutch replacement. In the days leading up to failure, the vehicle experienced difficulty accelerating and hesitation under throttle. A “Transmission Overheat” warning message appeared while driving. After cooling, the vehicle temporarily resumed operation but subsequently lost reliable gear engagement.

Filed Jan 27, 2026 · Electrical, Engine · CA

I am writing to file a formal complaint regarding an ongoing mechanical issue with my 2016 Ford Focus. Although my vehicle currently shows zero active recalls, I have experienced a recurring and concerning problem. Each time I turn on the air conditioning and the air begins to blow cold, my engine temperature rises significantly and causes the vehicle to overheat. This issue occurs consistently and makes it unsafe to operate the vehicle while using the air conditioning. Overheating poses a serious safety risk and may lead to engine damage or sudden breakdowns. Given that this problem appears to be directly connected to the operation of the air conditioning system, I am concerned that this may be a known defect or design issue that has not been addressed through a recall. I am requesting that this issue be formally documented, investigated, and addressed. I would appreciate guidance on next steps, including inspection, repair options, or whether this issue has been reported by other 2016 Ford Focus owners. Thank you for your time and attention to this matter. I look forward to your prompt response.

Filed Jan 14, 2026 · Transmission · 55,000 miles · NC

The contact owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle unexpectedly stalled with the message "Transmission Overheating" displayed. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The contact stated that the failure persisted. The manufacturer was not contacted regarding the failure. The failure mileage was 55,000.

Filed Jun 26, 2025 · Engine · WV

The dual clutch for the 2016 Ford Focus SE. This model is showing an open recall on active listings but not showing up in a search via VIN. Yes the vehicle is still available for inspection. The vehicle’s transmission overheats which has left us stranded, on the interstate and regular roads, maybe times. The vehicle has broken down multiple times in the middle of the road and put us at risk of a collision. I have verified with the dealer that this is a problem with these specific cars but only after I had purchased it. The problem started right away after purchase by showing on the dash that the transmission was overheating but that same message would go back off, resulting in the dealer refusing to take a look at it under warranty. I’ve seen many other customers complain of this problem and eventually end up losing a lot of money because Ford and the dealer will not do anything to fix it. They wouldn’t even look at the vehicle to confirm that this was the problem but instead gave me the 1-800 number for Ford and then Ford told me to take it back up to the dealer who refused to even take a complaint.

Filed Jun 23, 2025 · Transmission · 82,000 miles · IA

The contact owns a 2016 Ford Focus. The contact stated that while idling at a stop sign and attempting to accelerate, the transmission failed to shift into gear and the vehicle failed to respond. The contact shifted to park until the transmission shifted to drive. The message that the transmission was overheating was displayed and informed the contact to park the vehicle. The vehicle was taken to the dealer, who diagnosed that the traction control module and clutch had failed. The contact related the failure to the federal safety agency Campaign Numbers: 18V845000 (Power Train) and 18V169000 (Power Train); however, the VIN was not included in the recalls. The vehicle was not repaired. The manufacturer was informed of the failure, and a case was opened. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 82,000.

Filed Jun 19, 2025 · Transmission · VA

Purchased 2016 Ford Focus SE with 132,000 Mi on Wednesday June 11, 2025. Drove with no problem when I took it for a long test drive. Drove it Thursday June 12, 2025 with no problem. On Friday June 13, 2025 I thought I felt a little slippage going from 1st to 2nd gear. On Friday June 14, 2025 my 17yr old daughter drove it to the beach and while driving back home she got a msg "Transmission Overheating". She pulled over and called me. I was able to put the key 2 clicks into the starting position and switch to neutral where I got a msg " Transmission now Ready". I then put my scanner on it and was it read Shift Error PO7A3, Clutch "A" Disengagement P286F, Clutch "B" Stuck Engaged P287A. I took it to the dealer I bought it from but it was a As Is Purchase. Now I am stck even though Ford and the dealer knew about these problems.

Filed Apr 7, 2025 · Transmission · 100,000 miles · NJ

The contact owns a 2016 Ford Focus. The contact stated that while her husband was driving approximately 50 MPH, the vehicle failed to accelerate as intended. The contact stated that the message "Transmission Overheating" was displayed. The vehicle was pulled over to the side of the road and then towed to a dealer to be diagnosed. The vehicle was diagnosed with internal clutch failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,000.

Filed Mar 24, 2025 · Transmission · 96,000 miles · GA

The contact owns a 2016 Ford Focus. The contact stated that while accelerating, the vehicle shuddered and jerked for 2 seconds before shifting into gear. The contact stated that the check engine warning light was illuminated, with the message “Transmission Overheating - Pull Over for Safety” displayed on the instrument panel. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was informed that the clutch was faulty and needed to be replaced. The vehicle was not repaired. The contact stated that the clutch had been replaced three times. The vehiclehad previously been repaired under Customer Satisfaction Program: 19N08. The manufacturer was notified of the failure. The approximate failure mileage was 96,000.

Filed Feb 8, 2025 · Transmission · TN

At times will not go into reverse and shifts very hard. It will randomly shut off while driving and transmission overheating will pop up.

Filed Jan 2, 2025 · Transmission · NC

The contact owns a 2016 Ford Focus. The contact stated that while driving 45 MPH, the gear shifter shifted into park(P) independently. The contact pulled over and shifted back to drive(D). In addition, while driving up or down hill, the overheating warning light illuminated, and the vehicle stalled. The contact pulled over and waited for the engine to cool down; however, the failure recurred after driving a short distance. The failure occurred on four separate occasions. The failure became progressively worse, and the vehicle was no longer being driven. A dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.