2018 Ford Focus: engine overheating

Filed May 15, 2026 · Engine · FL

Last July my car was overheating and breaking down as I was driving on I4 to work one morning which it overheated and broke down which was the precursor the last time My engine blew in December 2024 which the engine was already repaired January 2022 (Dumphy Ford,Pa), December 2022 (Tropical Ford, Fl) then I got notices there is a recall with the oil pump and belt since February 2023 however the remedy parts were not available and kept getting notices that the parts would be in by fall 2024 then it kept getting pushed back when they would be available, meanwhile my car broke down again July 2024 which the engine needed to be replaced and was covered because oil and coolant was leaking into the engine due to the recall and they still didn’t have parts available and then car broke down again December 2024 which Tropical Ford covered because the recall parts were still not available. So in July 2025 they attempted to fix it and I picked it up and it overheated again and they kept it till September 2025 and fixed a bunch of things like transmission, recall and other things and now the car began to overheat again and took it to [XXX] and now they are saying the engine is blown again… I believe the recall failed and I shouldn’t have to pay for the 5Th engine replacement INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 16, 2026 · Engine · TX

Engine light is on with the code reading the clutch and the transmission is overheating with sticking gears as I drive

Filed Feb 7, 2026 · Engine · NY

At 80000miles I noticed misfires and replaced original spark plugs per spec At 107578, misfires occurred, when I pulled plugs pos 1 was completely worn out, as well as pos 4.Codes were seen P0304 and P0301. Car ran well after replacement. I have been troubled by loss of coolant lately and could find no leaks. Also temp gauge in dash “wanders” Being retired I can’t afford to go to dealership. I believe spark plugs should not wear out after approx 25000 miles No overheating of engine has occurred . I drive about 12000/yr. Car is available to be seen. Dealer has not seen car Concerned problem could cause engine failure. Thank you

Filed Jan 22, 2026 · Engine, Fuel system · RI

The malfunctioned component Engine Oil Pump failed while driving on highway causing the vehicle to both overheat and stall all at once, causing the vehicle to stop running in the middle of a main highway forcing me and another pedestrian to push the car into a gas station, out of the way of oncoming traffic, Ford did send out a recall notice for the Failed Oil Pump in December 2025 the same month my vehicle broke down. The vehicle was inspected by a mechanics shop, Master Muffler & Brake repair shop in Wareham Ma. as well as Empire Ford of New Bedford, Master Muffler & Brake concluded that the Head Gasket had blown, and Empire Ford of New Bedford concluded the issue was due to a cracked engine block. Prior to any issue there had been no warning signs then once the 2018 Ford Focus began to stall an overheating warning light as well as the check engine light began to flash at the same exact time as the vehicle itself breaking down.

Filed Jan 2, 2026 · Engine · 74,947 miles · NY

The contact owns a 2018 Ford Focus. The contact received a notification of the federal safety agency Campaign Number:Â 23V905000(Engine and Engine Cooling), and the vehicle was taken to the dealer for the recall repair. The dealer informed the contact that the engine was replaced; however, the contact stated that after the recall repair, the vehicle started to overheat. The contact added coolant to the vehicle, but the failure persisted. The contact stated that the vehicle was not experiencing the failure prior to the recall repair. The vehicle was taken back to the dealer, where it was diagnosed with coolant contamination. The dealer replaced two reservoirs and cleaned out the coolant. The contact stated that upon attempting to start the vehicle in the driveway, the vehicle failed to start. The vehicle was towed to an independent mechanic, where the spark plugs were removed, and the mechanic noticed that there was coolant leak on the spark plugs. The mechanic determined that the engine had seized. The contact sent pictures of the failure to the dealer, who advised that they would need to diagnose the vehicle. The vehicle was then towed to the dealer, but was not yet diagnosed due to the cost. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 74,947.

Filed Dec 16, 2025 · Electrical, Engine · AR

Vehicle experienced a highway-speed overheat and automatic engine shutdown. Inspection revealed antifreeze intrusion into the under-hood engine fuse box, causing widespread fuse degradation and electrical failure. This occurred following recall-related service. Vehicle lost power and is unsafe to operate due to electrical contamination and fire risk. Manufacturer and dealer have been unresponsive.

Filed Oct 5, 2025 · Engine · VA

My wife was driving her car home from work when her car suddenly overheated in light traffic. She pulled over and called me. I came by and we saw that the coolant level was low, so we filled it up to the normal level and she drove it another 20 minutes back to our home. She said it was shuddering the whole way back. I started it in the driveway later that evening and a large amount of white smoke came out of the exhaust pipe and the engine still seemed to be misfiring. I tried starting it again the next day and it would crank but not start. It seems to be an issue with the engine, my guess is a ruptured head gasket. The shuddering caused by the misfires made the car unstable to drive especially if it died while she was at speed with other cars around. The car was towed to a dealer over 30 days ago and they said that it may be related to the open recall, but they won't know until they tear it down. Which they still haven't done. There were no engine codes or prior lamp indications until the overheating event.

Filed Sep 29, 2025 · Engine, Transmission · 8,899 miles · OH

The contact owns a 2018 Ford Focus. The contact stated that while driving at various speeds, the vehicle was jerking and hesitating while depressing the accelerator pedal. The vehicle was taken to the dealer, where an unknown transmission repair was performed; however, the failure persisted. The local dealer and an unknown dealer were contacted and offered to take the vehicle in a trade-in, but the contact declined. The vehicle was taken to Marcino Enterprises LLC, where it was test-driven, and the failure recurred. The dealer diagnosed that the transmission fluid was contaminated with metal shavings and had become brown. Additionally, the contact stated that the engine overheated. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 8,899.

Filed Jul 29, 2025 · Transmission · 99,500 miles · TX

The contact owns 2018 Ford Focus. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle hesitated to respond. The message "Transmission Is Overheating" was displayed. Additionally, the contact stated that the vehicle had failed to reverse as intended. The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure the federal safety agency Campaign Number: 18V845000(Power Train); however, the VIN was not included in the recall. The manufacturer was notified of the failure, but the contact was informed through a voicemail message that no assistance would be provided. The failure mileage was 99,500.

Filed Jun 23, 2025 · Engine, Transmission · 198,000 miles · AL

The contact owns a 2018 Ford Focus. The contact stated while driving 35 MPH, the engine overheated and the vehicle stalled. The contact stated that the engine was revving and the message to pull over was displayed. The contact turned on the hazard lights and waited for the engine to cool down. The contact stated that the vehicle was making an abnormal clunking noise. Additionally, the transmission was slipping, and the gears were sticking. The vehicle was taken to the local dealer, who confirmed there were no associated recalls on the VIN for the failures. The vehicle was diagnosed, and it was determined that the engine mount, transmission, canister, water pump, and axle needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to an independent mechanic. The manufacturer was contacted and confirmed that the vehicle was out of warranty. The failure mileage was approximately 198,000.

Filed May 27, 2025 · Acceleration, Steering · NC

My vehicle was inspected in order to determine why my vehicle is stalling, jerking, not going into reverse and giving a warning message that the car is overheating. My spouse and I were told the transmission control module needs to be replaced. Upon reading about my car's maje and midel, I learned this is a problem with 2018 Ford cars. It stalls and almost cuts off in traffic which is very dangerous

Filed May 20, 2025 · Transmission · 66,000 miles · MI

The contact owns a 2018 Ford Focus. The contact stated that the transmission was slipping and failed to properly shift into the intended gear. The contact stated that the engine was overheating, causing the vehicle to become inoperable. The check engine warning light was illuminated. The vehicle was taken to a certified mechanic who diagnosed and determined that the dual clutch had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 66,000.