Ford Focus overheating problems

Filed Sep 29, 2026 · Transmission · FL

Transmission overheating warning light Transmission clutch stuck open recommended to change out “actuator A” but did not solve. Clutch fork needs replacement

Filed Sep 20, 2026 · Transmission · TN

The DPS6 transmission started out shuddering in low gears even after clutch replacement early on. This made pulling out into traffic slower than it should be. Received “transmission overheating” message “pull over for 5 minutes” in heavy traffic. Prior to the message car would shudder and lose power. This happened suddenly going at highway speeds on the interstate. Replaced clutch actuators and TCM only to have the clutch adaptive learn procedure fail and after inspection by the dealer was told needs new transmission. These problems have been present at very low mileage and Ford now wants to charge a ridiculous amount to replace transmission that should have been fixed long ago. Several times the car stalled in traffic almost causing me to get in accidents.

Filed Sep 3, 2026 · Transmission · 133,283 miles · GA

The contact owns a 2014 Ford Focus. The contact stated that while driving approximately 30 MPH and coming to a stop, the vehicle unexpectedly stalled, and the transmission was slipping with the message “Transmission Overheated - Stop Vehicle” displayed. There was an abnormal odor coming from the vehicle while stopped. The contact stated that the vehicle was restarted, shifted to neutral, and remained stopped for 10 minutes before the vehicle returned to normal operation. The failure had occurred several times. Eventually, the vehicle was unable to be started. The vehicle was towed to the dealer, where it was diagnosed and determined that the clutch actuator and throw-out bearing had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 133,283.

Filed Sep 2, 2026 · Transmission · IA

The contact owns a 2013 Ford Focus. The contact stated that the transmission failed, and the vehicle lost motive power, and the vehicle was stuck in the middle of traffic. The contact referenced several satisfaction programs for the issue; however, the VIN was not included in the repair. The vehicle was towed back to the residence due to it not being able to operate. The contact stated there was an unknown warning light on the instrument panel. The contact stated that the transmission had overheated. The manufacturer was notified of the failure. The vehicle was taken to an independent mechanic, and it was confirmed with transmission failure.

Filed Aug 29, 2026 · Transmission · GA

The transmission on my 2017 Ford Focus started not shifting correctly. It would shudder, slip and hesitate when shifting. At times when it did get up to speed it would unexpectedly downshift and go into limp mode. The automobile is not safe to drive and is now parked at my residence. A warning would flash up on the dash that stated the transmission was overheating and for me to pull over to a safe location as I recall. On October 22, 2025 the automobile was delivered to a local Ford dealership for a diagnostic system check. Per the diagnostic test report a PPT G was performed and found it necessary to replace the transmission due to a failed B clutch shift fork. The estimate quote for a transmission replacement along with some other repairs was $10,000.00. I had the car towed to my home and it now sits in my driveway until and if a recall is issued. According to an article published by MSN. com that enough complaints were filed that Ford extended warranty coverage, issued a long series of software and hardware fixes, and settled a class action covering roughly two million Focus an Fiesta cars. I have in my possession the invoice for the diagnostic testing which was performed. I however do not know how to upload the invoice for your review, but would be willing to take it to the service department for them to do it.

Filed Jul 15, 2026 · Engine · 178,000 miles · NY

The contact owns a 2017 Ford Focus. The contact stated that while driving at an undisclosed speed, the low engine oil pressure warning light illuminated, and the contact stopped driving the vehicle. The vehicle was taken to the dealer, where the engine oil pump, the engine, and the coolant gasket housing were replaced under the federal safety agency Campaign Number: 23V905000 (Engine and Engine Cooling); however, the vehicle started overheating. The vehicle was taken back to the dealer several times, and the contact was eventually informed that diagnostic trouble codes indicating an overheating failure were retrieved when the vehicle was initially taken to the dealer. The contact stated that the dealer stated that the overheating failure was not related to the recall repair. No further assistance was provided. The manufacturer was notified of the failure and a case was filed; the contact was advised to take the vehicle to another dealer for a second assessment, and the manufacturer would follow up with the initial dealer based on the assessment. The failure mileage was approximately 178,000.

Filed Jul 7, 2026 · Electrical, Fuel system · PA

Transmission overheated. Transmission fluid leaked but the computer in the car didn't let me know there was a leak. Couldn't move my car into reverse so I had to get a tow to Ford. They said it was a Transmission leak which caused the overheating. But once the car received Transmission fluid the car did not go into reverse. Clutch failed.

Filed May 15, 2026 · Engine · FL

Last July my car was overheating and breaking down as I was driving on I4 to work one morning which it overheated and broke down which was the precursor the last time My engine blew in December 2024 which the engine was already repaired January 2022 (Dumphy Ford,Pa), December 2022 (Tropical Ford, Fl) then I got notices there is a recall with the oil pump and belt since February 2023 however the remedy parts were not available and kept getting notices that the parts would be in by fall 2024 then it kept getting pushed back when they would be available, meanwhile my car broke down again July 2024 which the engine needed to be replaced and was covered because oil and coolant was leaking into the engine due to the recall and they still didn’t have parts available and then car broke down again December 2024 which Tropical Ford covered because the recall parts were still not available. So in July 2025 they attempted to fix it and I picked it up and it overheated again and they kept it till September 2025 and fixed a bunch of things like transmission, recall and other things and now the car began to overheat again and took it to [XXX] and now they are saying the engine is blown again… I believe the recall failed and I shouldn’t have to pay for the 5Th engine replacement INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 26, 2026 · Engine, Transmission · PA

Bought in 2024 ..few days later car wouldn’t change gears transmission overheats shutters jerks and won’t go when giving gas at times. Had the car in 5 times to fix, didn’t work.. I’ve almost been in accidents one of which was with a tractor trailer This car is a death trap had to quit job due to this .. and have a 7500.00 loan on a car I can barely drive. I want this loan paid off and given a check or car that has no problems and is reliable plus compensation for lost wages Im also willing to file suit immediately if this isn’t taken care of IMMEDIATELY!!!!

Filed Mar 16, 2026 · Engine · TX

Engine light is on with the code reading the clutch and the transmission is overheating with sticking gears as I drive