2015 Ford Focus: engine overheating

Filed Mar 26, 2026 · Engine, Transmission · PA

Bought in 2024 ..few days later car wouldn’t change gears transmission overheats shutters jerks and won’t go when giving gas at times. Had the car in 5 times to fix, didn’t work.. I’ve almost been in accidents one of which was with a tractor trailer This car is a death trap had to quit job due to this .. and have a 7500.00 loan on a car I can barely drive. I want this loan paid off and given a check or car that has no problems and is reliable plus compensation for lost wages Im also willing to file suit immediately if this isn’t taken care of IMMEDIATELY!!!!

Filed Dec 10, 2025 · Electrical, Engine · GA

I was getting ready to leave the grocery store and I crank up my car and I had a light come on stating that my car was overheating transmission turn off the car and as I tried to pull out of the parking lot, the car would barely accelerate it would barely go to mountain and it was stuttering up the heels I had to turn off the vehicle. Let it sit for five minutes to let it cool off and then I had to crank the car back up and then it started to drive again, but I did get a indication on my front dash stating that it was transmission

Filed Nov 25, 2025 · Electrical, Transmission · MD

Transmission overheating and internal wear (metal particles in fluid) following electrical/TCM malfunction in Ford Focus DPS6. Transmission failure recurred after earlier repair under 14M02. Current failure includes overheating messages, shudder, and loss of safe drivability. Ford acknowledges issue relates to known PowerShift defect but refuses coverage. Vehicle unsafe.

Filed Sep 19, 2025 · Acceleration, Engine · CO

The car would not shift into a gear, would not shift gear to propel itself in traffic causing a safety issue. A warning light would come on saying the transmission was getting overheated. Ford of Glenwood Springs Colorado refused to look at the car because of its age despite the recall on the clutch for the year, make and model of the car. A NAPA shop determined the clutches were out. NAPA quoted $4,253 to fix the problem. I called Ken Garff Ford in Fort Collins Colorado at 4809 S. College Avenue to get this fixed under the recall. They said my VIN number wasn't covered, and the cost would be $6,000. I called Ford 1‑866‑436‑7332 spoke to Ron employee #2192738 and was told he would document the call but could not do anything. Ford is aware of the safety issue we simply want them to standby their product and fix the problem or reimbursing us for the repairs to avoid a further hardship to get to work. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 15, 2025 · Transmission · 109,100 miles · NJ

The contact owns a 2015 Ford Focus. The contact stated that while driving approximately 20-30 MPH, the transmission started slipper while shifting out of 2nd gear with the message "Transmission Overheating" and the check engine warning light was illuminated. The vehicle was taken to a local Auto Zone and a diagnostic scanner retrieved DTC: P090C and P207A. The local dealer was contacted; however, the vehicle was not diagnosed nor repaired. The contact was informed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 109,100.

Filed Aug 6, 2025 · Transmission · 109,007 miles · NC

The contact owns a 2015 Ford Focus. The contact stated that while driving at a roundabout at 20 MPH, the "Transmission Overheating - Please Pull Over to a Safe Location" was displayed, and the contact pulled over for 30 minutes for the transmission to cool down. However, after restarting the vehicle and attempting to drive, the contact noticed that the transmission was slipping between 1st and 2nd gear. The contact proceeded to pull over and the vehicle was towed to a local dealer where it was diagnosed, and the contact was advised that the dual clutch assembly and the fuel rail pressure sensor were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 109,007.

Filed Jul 28, 2025 · Transmission · 90,000 miles · OH

The contact owns a 2015 Ford Focus. The contact stated that the vehicle shuddered or hesitated while idling. Additionally, the failure also occurred while driving at various speeds. The contact stated that the transmission intermittently failed to shift as designed, and the vehicle stalled while driving. The vehicle was occasionally coasted or pushed to the side of the road, and several attempts were made to restart the vehicle. However, the failure recurred while driving at various speeds or while the vehicle was idling. The failure had become more persistent. The contact stated that on another occasion, while driving approximately 50 - 55 MPH, the vehicle went into LIMP Mode. The vehicle was towed to the residence. The “Service Vehicle Soon” and an unknown warning were illuminated. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the TCM had failed, causing the transmission to overheat, reaching over 1,000 degrees, causing damage to the shifting forks. The wiring harness was burned due to the failure. The mechanic stated that the PCM had caused damage to the forward gears. The vehicle was repaired; however, the failure persisted. The dealer was contacted and confirmed that the VIN was not under recall. The dealer referred the contact to the manufacturer for assistance. The manufacturer was informed of the failure and confirmed that the VIN was not under recall or covered under warranty. The manufacturer opened a case and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 90,000.

Filed Jul 11, 2025 · Transmission · 143,000 miles · IN

The contact owns a 2015 Ford Focus. The contact stated while driving approximately 65 MPH, the vehicle started shuddering and vibrating and decelerated unintendedly. The contact stated that the transmission failed to properly shift and failed to reverse. During the failure, the messages "Transmission Overheating" and "Transmission Fault" were displayed. The cause of the failure was not yet determined. The manufacturer and local dealer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 18V169000 (POWER TRAIN). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 143,000.

Filed Jun 17, 2025 · Transmission · 153,000 miles · FL

The contact owns a 2015 Ford Focus. The contact stated while driving at various speeds, the transmission was slipping, and the message "Pull Over to Prevent Transmission from Overheating" was displayed. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the transmission was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 153,000.

Filed Jun 10, 2025 · Transmission · 89,500 miles · WA

The contact owns a 2015 Ford Focus. The contact stated while driving at an undisclosed speed, the “Transmission Overheating” warning light illuminated. Additionally, the RPM had become elevated. The vehicle was towed to the dealer where it was diagnosed with transmission clutch failure. The contact was informed that the transmission clutch needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact referenced the federal safety agency Campaign Number: 18V169000 (Power Train); however, the VIN was not included in the recall. The contact had previously received the recall notification. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 89,500.

Filed Apr 23, 2025 · Transmission · 35,000 miles · FL

The contact owns a 2015 Ford Focus. The contact stated that while driving approximately 65 MPH the transmission suddenly switched to neutral and the vehicle would no long accelerate. During the failure the message "Transmission Fault" had displayed. The contact was able to continue driving but later discovered that the vehicle would not operate in reverse. Later while driving the message "Transmission Overheating" had displayed and the vehicle stalled. The vehicle was towed to the local dealer who diagnosed that the transmission clutch was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The contact indicated that the failure had occurred shortly after the TCM and PCM software was updated as part of a recall repair. No further information was available. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 35,000.

Filed Feb 18, 2025 · Transmission · 99,000 miles · CA

The contact owns a 2015 Ford Focus. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. The failure occurred on several occasions. The message that the "Transmission was Overheating" was displayed on the instrument panel; however, there were no warning lights illuminated. The contact pulled over and allowed the vehicle to cool down for several minutes and the vehicle returned to normal operation. The vehicle was taken to a dealer where it was diagnosed and determined that the clutch assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 99,000.