Ford Fusion hesitation problems

Filed Sep 30, 2026 · Engine · NC

Capital Ford of Wilmington diagnosed my vehicle with coolant intrusion into cylinder 2, accompanied by diagnostic trouble codes P0302 and P0316, after check engine light came on. I have been advised that the vehicle requires a complete engine replacement, with an estimated cost of $13,180.89. The vehicle has experienced sputtering and hesitation, creating concern that it could lose power or stall. These symptoms are concerning. After researching this issue, I have learned that coolant intrusion is a documented problem associated with certain Ford vehicles equipped with the 1.5L EcoBoost engine produced during the 2017–2019 period. Ford has addressed this issue through Technical Service Bulletins and Customer Satisfaction Program 21N12. I contacted Ford and was told that my VIN is not covered under the Customer Satisfaction Program. When asked why mine was not covered but other were , Ford stated that even if it is the same issue that is being recalled if my VIN is not flagged it will not be covered for any recall or assistance.I called Ford when I first purchase vehicle and asked about this recall and was told if I didn't have anything wrong with my car and no engine lights that my car was fine and to bring it in if I have any issues.

Filed Sep 28, 2026 · Acceleration, Engine · CA

We purchased this 2017 Ford Fusion 1.5L EcoBoost in August 2022 at 48,968 miles. At 55,940 miles, the vehicle developed a documented coolant leak requiring water-pump replacement. At approximately 75,520 miles, the coolant level was again documented as requiring attention. At approximately 84,189 miles, the vehicle experienced low coolant, low oil, white/gray smoke and rough running. Manteca Ford identified Ford TSB 22-2322 and ultimately performed a major short-block replacement. Despite this major engine repair, mechanical and drivability problems continued. At approximately 101,375 miles, we returned the vehicle to Manteca Ford specifically for loss of power and hesitation. The Ford technician verified a “noticeable loss of power” and lack of full boost. Manteca Ford diagnosed and replaced the turbocharger. The problem was not resolved. Only approximately 205 miles later, at 101,580 miles, the vehicle returned to Manteca Ford because it was still hesitating during acceleration. Manteca Ford then identified DTCs P0729, P07AA, P2703 and P2704 and documented “TRANSMISSION INTERNAL MECHANICAL FAULTS,” including an incorrect sixth-gear ratio and friction-element faults. The dealer recommended replacement or teardown of the transmission. We are extremely concerned about the safety implications of this history. Loss of power and hesitation during acceleration can create a serious hazard when merging onto a highway, entering or crossing traffic, or attempting to accelerate to avoid a collision. This vehicle has experienced repeated engine/powertrain problems despite major repairs, and we are concerned the transmission condition may have been developing during the earlier loss-of-power/hesitation complaints. We request that the federal safety agency evaluate this history for a potential safety-related defect or broader pattern.

Filed Aug 30, 2026 · Electrical, Engine · CA

2017 Ford Fusion. Transmission replaced February 2026 at 98,175 miles by independent repair facility. Check engine light illuminated immediately following replacement and has remained on continuously since. Autozone scan showed emissions-related code only. On August 28, 2026 at approximately 120,064 miles, orange wrench light and "See Manual" message appeared moments after hot restart. Acceleration became heavy and hesitant. Drove approximately 70 miles home via I-15; heavy traffic required engine shutdown at multiple stops. Following morning, wrench light was no longer illuminated but hesitation persisted. Using manual paddle shift to select 5th gear improved drivability. Replacement transmission accumulated approximately 22,000 miles over 6 months. Ford Motor Company has issued multiple recalls for 2013-2016 model year Fusions involving identical transmission, shifter cable bushing, and torque converter defects, but 2017 model year vehicles with identical 6F35 transmissions and failure symptoms have been excluded from all campaigns. No crash, fire, or injury occurred.

Filed Aug 13, 2026 · Engine, Transmission · CA

I am reporting a serious recurring safety concern involving a 2017 Ford Fusion SE with a 1.5L EcoBoost engine. The vehicle was purchased used in August 2022 with approximately 50,000 miles. Within months, significant coolant and engine problems began. In February 2023, at approximately 55,940 miles, the vehicle developed a coolant leak. A pressure test confirmed the water pump was leaking and it was replaced. At approximately 84,189 miles, the vehicle experienced white/gray exhaust smoke, coolant loss, very low oil, and rough-running symptoms. The servicing Ford dealership referenced Ford Technical Service Bulletin (TSB) 22-2322 in connection with the diagnosis and ultimately replaced the engine short block. Despite this major engine repair, the problems continued. The vehicle subsequently experienced additional smoking, hesitation and loss of power and required replacement of the turbocharger. The vehicle was returned again because it continued to smoke and required additional repairs. I am concerned this is a recurring engine defect rather than normal wear and tear. The repeated engine/coolant failures, smoking, hesitation and loss of power create a serious safety concern because the vehicle may unexpectedly lose power or experience engine failure while being driven. Ford has been notified of the repeated failures but declined further relief based primarily on the vehicle's current age, mileage and expired warranty. This ignores that the problems began years earlier at substantially lower mileage and that major repairs failed to permanently correct the condition. I request that the federal safety agency investigate whether the 1.5L EcoBoost engine in this and similarly equipped Ford vehicles has a safety-related defect involving coolant intrusion, engine failure and loss of power. The vehicle is currently at approximately 101,000 miles, but the documented problems began at 55,940 miles and continued despite major repairs.

Filed Jul 26, 2026 · Brakes, Engine · IL

The engine experienced a sudden failure that caused the vehicle to become completely inoperable. Prior to the failure, the vehicle exhibited intermittent hesitation, rough idling, and loss of power during acceleration. These symptoms began several weeks before the complete failure. No warning lamps were illuminated at first, but shortly before the breakdown, the vehicle displayed a check engine light and a “Service Engine Soon” message. While driving, the vehicle abruptly lost power and became unsafe to operate. I was forced to pull over immediately, which created a safety risk to myself and other drivers due to the sudden deceleration and inability to maintain speed in traffic. The vehicle would not restart afterward. A repair facility has confirmed that the engine has suffered a major internal failure and requires replacement. The estimated cost of repair starts upwards of $5,000. The vehicle is currently non‑drivable and remains available for inspection. The issue has been reproduced and confirmed by an independent service center. The vehicle has not yet been inspected by the manufacturer, police, or insurance representatives. However, I have found multiple similar complaints from other owners reporting the same type of powertrain failure, suggesting a potential pattern or defect affecting safety.

Filed Jul 7, 2026 · Transmission · FL

A failed transmission cooling line caused the transmission fluid to leak. At no point did the vehicle display a check engine light, transmission warning, or any other indication that there was a problem. According to the Ford dealership, the transmission fluid had been leaking for some time. Because the transmission pan is wrapped in a fabric-like insulating material, the leaking fluid was absorbed rather than dripping onto the ground, making the leak virtually impossible for an owner to detect during normal use. The dealership also advised that this condition could have created a potential fire hazard within the engine compartment. The vehicle has only approximately 40,000 miles, making this type of catastrophic transmission failure especially concerning for a relatively low-mileage vehicle. The first and only symptom occurred when I started the vehicle one day. It hesitated, struggled to shift out of first gear, and drove abnormally. I immediately drove it to the Ford dealership, where it was diagnosed with a complete transmission failure. The vehicle is currently at the dealership, and I have been presented with an estimated repair cost of approximately $12,000. My primary concern is that there was absolutely no warning before this major failure. No warning lights, no diagnostic alerts, and no indication that a significant transmission fluid leak or internal transmission damage was occurring. A safety-critical failure of this magnitude should provide drivers with some form of warning before resulting in complete transmission failure.

Filed Feb 5, 2026 · Engine · TX

While operating my 2018 Ford Fusion, the vehicle began experiencing internal coolant loss resulting in engine misfires, rough running, and white exhaust smoke. The coolant intrusion caused engine failure and loss of reliability. This condition creates a safety risk, as it can lead to loss of power while driving, hesitation, and the possibility of engine shutdown. The defect occurred without warning and is consistent with widespread reports involving Ford EcoBoost engines. This issue is not related to maintenance or normal wear and tear but is a known design defect acknowledged through service bulletins and consumer litigation. Repair requires full engine replacement.

Filed Jan 18, 2026 · CA

Vehicle: 2013 Ford Fusion Mileage: ~165,000 miles Issue Type: Engine stalls / loss of power My 2013 Ford Fusion has experienced intermittent engine stalling and hesitation since early ownership. The vehicle will stall or “putter” when slowing down or coming to a stop, often without warning. When this occurs, the engine shuts off and the vehicle must be put into park and restarted. Restarting is sometimes delayed or hesitant. This issue occurs without any warning lights or diagnostic trouble codes appearing on the dashboard, making it difficult for dealerships and mechanics to diagnose. The problem has persisted for years and has occurred multiple times under normal driving conditions. This defect presents a serious safety risk, as the vehicle can lose power unexpectedly while in traffic, at intersections, or during braking. Loss of engine power in these situations creates a high risk of collision. The vehicle has been inspected multiple times, including by dealerships, but the issue could not be identified due to the absence of fault codes. This appears to be a design or component defect that does not reliably trigger diagnostic warnings. I am reporting this as a safety-related defect involving unexpected engine stalling and loss of power. The date I marked you asked below is the most current but as I stated it’s been happening since a month after purchasing the car brand new.

Filed Nov 25, 2025 · Engine · 100,000 miles · GA

The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle started shuddering violently, hesitated, and failed to accelerate to approximately 35 MPH. The check engine warning light was flashing. The contact related the failure to the Customer Satisfaction Program: 21N12. The vehicle was towed to the local dealer, where it was diagnosed with coolant intrusion into the cylinders. The dealer informed the contact that the engine small block needed to be replaced, but a full engine replacement was recommended. The vehicle was not repaired. The manufacturer was contacted and filed a complaint. The manufacturer advised the contact that a future report would be issued. The failure mileage was approximately 100,000.

Filed Oct 6, 2025 · Engine, Fuel system · NY

According to Auto Zone, after being placed on scanner, the power train system (P0456) has a evaporative emissions system leak (very small leak) diagnosed at 76,919miles. Ford dealership says they cannot find a problem. When I put gas in the car I have to sit and wait at least 10 minutes before my car will start again. It takes a couple of tries and much hesitation, but it will start. Once you get started it has difficulty accelerating or may slow down on its own. Again, Ford dealership reports they can't seem to find a problem. When I told them the problem, they came up with a price to charge me to fix something they could not find. Ridiculous!! My ford app clearly states check engine problem detected, but nooooo they cannot find anything wrong. Two different dealerships. Thank God I keep my paperwork because others are complaining of the same thing. They have to put the pen to the paper or we will never get a recall.