2016 Ford Transit Connect electrical problems

Filed Dec 18, 2023 · Brakes, Electrical · 70,000 miles · FL

The contact owns a 2016 Ford Transit Connect. The contact stated that while initially starting the vehicle and while driving at various speeds, the main computer screen displayed the “Hill Stop Assist Not Available" and "Parking Assist Not Available" messages. The check engine and ABS warning lights were illuminated. The speedometer, power steering, and several other unknown messages were displayed intermittently. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to the dealer after the original failure and was diagnosed and determined that the front passenger’s side wheel position sensor had failed and needed to be replaced. The vehicle was taken to an independent mechanic after the second failure, and it was determined that the same front passenger’s and driver’s side wheel position sensors had failed and needed to be replaced. The contact was informed that the steering wheel position sensor had failed and needed to be replaced. The vehicle was not repaired. The manufacturer had not been made aware of the failure. The approximate failure mileage was 70,000.

Filed Dec 8, 2023 · Electrical, Lights · 55,000 miles · NY

The contact owns a 2016 Ford Transit Connect. The contact stated that cracks had formed in both taillights which lead to water accumulation inside the taillight housing. The vehicle was taken to a dealer and the contact was informed that moisture had leaked into the taillight wiring harness and both taillight sensors and sensor harnesses need to be replaced. In addition, the taillight wiring had begun to hang from the rear of the vehicle, causing the exhaust pipe to melt the wiring harness. The dealer informed the contact that the taillight sensor could not be repaired due to the part being on backorder. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 55,000.

Filed Sep 19, 2023 · Brakes, Electrical · HI

Calipers and brake pads were replaced and still front brakes locking up. Unable to drive. Also, I had to replace a brand new brain on the van over $3000 electrical. The contact stated the vehicle is not working and needs help.

Filed Jul 21, 2023 · Brakes, Electrical · 50,000 miles · MN

The contact owns a 2016 Ford Transit Connect. The contact stated while an employee was driving 55 MPH, the vehicle decelerated unintendedly. The contact stated no warning light was illuminated. The contact took the vehicle to an independent mechanic however, the mechanic was unable to duplicate the failure. The contact stated on July 14, 2023, while the same employee was driving the vehicle and was releasing the brake pedal, the vehicle started losing motive power and slowed unintendedly. The contact stated no warning light was illuminated. The employee continued driving to the independent mechanic and was informed that the brake rotors, brake pads, and the front driver’s side and the rear passenger’s side calipers needed to be replaced. The vehicle was repaired however, the mechanic then stated that the Hydraulic Control Unit (HCU) pump was faulty. Upon investigation, the mechanic associated the failure with the federal safety agency Campaign Number: 16V482000 (Service Brakes, Hydraulic, Electrical System) however, the VIN was not included. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the Hydraulic Control Unit (HCU) pump to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 50,000.

Filed Aug 22, 2022 · Airbags, Electrical · WI

My Passenger Seat Occupancy Sensor failed. Caused my airbag system to throw a code and become inoperative and SRS light on. Took to Middleton Ford in Middleton, WI and they confirmed the code indicated the OCS sensor has failed and required replacing to make the airbag system operable again. Meaning if I got into an accident, no airbags would deploy while the defective OCS sensor is in place. My insurance refused to inspect or cover the sensor as the failure wasn't related to an accident. Middleton Ford refused to cover the replacement cost regardless of cause of failure and said I must pay for the repair as my van was out of warranty. The sensor was replaced on 08/22/22 and see attached pics to prove the sensor had no visual issues and the cause of said failure is a manufacturer defect. Consumers should never have to pay for a defective part that failed due to no fault of their own.

Filed Jul 19, 2022 · Airbags, Electrical · WI

My SRS system has thrown the SRS light with code B00C0:11AB Passenger Occupancy sensor A short to ground. According to The weight pad is faulty and requires a $989 part replacement. The SRS system is disabled with the light on which is a safety issue in today's vehicles as none of the airbags will deploy in an accident with the SRS light currently on. No consumer related malfunction detected meaning there were no broken wires found nor evidence of a consumer triggered fault found such as wet or previously wet pad which could have caused the fault. It is an internal part failure.

Filed May 3, 2022 · Electrical, Steering · CA

After battery replacement, the power steering (the EPAS system) failed. The dashboard-gauges display said, "STEERING ASSIST FAULT SERVICE REQUIRED." After towing and diagnosis, my mechanic said the system had to be reprogramed at a dealership. The vehicle is available for inspection upon request.

Filed Jun 26, 2020 · Body, Electrical · 31,000 miles · CA

1. Stationary or in motion: the top of the front windshield seems to be losing its seal because when water is poured or when it rains, it enters the car and falls onto the dashboard. Also, the plastic box that stores the rear view window and which is attached to the windshield gets filled with rain and drips down the window. 2. In motion, on a gradual hill and up: from day one, the car would not shift up on a downhill, even a slight hill. It revs in the 2nd gear and rev until it would jump into third after revving in a lower gear for 2-4 minutes. I took it to 2 dealerships (one in tacoma, wa, and the other in marina ford) and they said they couldn't repeat the problem even though I had plenty of video of it. 3. Stationary or in motion: lcd screen sometimes stops responding for no particular reason. You have to turn car off and on again to get a response.

Filed Jan 31, 2020 · Electrical · 25,951 miles · NY · 1 injury

While driving the vehicle in reverse, the driver's air bag deployed for no reason. The diver was slightly injured. The vehicle's maintenance history was looked at. This vehicle was never implicated in an accident. The ford dealer found that the electrical wiring for this airbag was corroded. This would be the reason why the airbag deployed. This electrical wire should be better protected. The dealer refused to repair it under warranty because it is not valid anymore.

Filed Jun 19, 2019 · Electrical, Steering · 95,000 miles · MA

While pulling out of a fast food drive through steering jerked to center and I lost power steering to the point where I could barely keep control of the vehicle, mechanic informed me the powering steering motor seemed overheated because of its location and I could expect this to happen again, on the dash I got a "steering fault" code. Second issue unrelated is that the temp sensor keeps malfunctioning, once the senor reaches below the freezing point on the dash ( keep in mind its 74f outside) the vehicle shuts down the air conditioning unit blowing hot air until the whole system resets and the dash reads the actual exterior temp. New ford temp sensor installed worked fine for two weeks then same issue. Its frustrating when we reach 80+ degrees and the air conditioning is intermittent because of a senor issue which is totally unrelated to the unit itself. Two other friends of mine own the same year vehicle and are having the same issues. Love my ford but they should own up to they're problems.