2016 Ford Transit Connect visibility problems

Filed Jun 17, 2026 · Visibility · WA

2 years ago (approx.) I brought my van to Sound Ford in Renton, WA. for the windshield recall. Two employees inspected my windshield and said they could not do the recall because they found a micro-pit in the glass. They told me to get my insurance to replace the windshield. I called my insurance but they said they won't replace the windshield unless it is cracked and I would have to pay a $100 deductible and Sound Ford is off the hook to do the recall. Since then I have been waiting for a crack to form but the windshield started to leak and on gravel and dirt roads the windshield started to vibrate. The vibration got so bad I had to duct tape the windshield on and tried to stop the leak with plumbers putty. I would like Sound Ford to complete the recall with no cost to me as stated in the recall. "FORD MOTOR COMPANY HAS AUTHORIZED YOUR DEALER TO RESEAL THE WINDSHIELD FREE OF CHARGE PARTS AND LABOR."

Filed Nov 14, 2025 · Visibility · 165,000 miles · TX

The contact owns a 2016 Ford Transit Connect. The contact stated that while driving at an undisclosed speed, the glass panel from the sunroof unexpectedly detached from the vehicle. The vehicle was taken to the dealer, where it was determined that the adhesive securing the sunroof glass had failed, causing the panel to detach. The contact was informed that the adhesive needs to be replaced to reattach the glass panel. The vehicle was not repaired. The contact expressed concerns that the failure had made the vehicle unsafe and that the children no longer wanted to ride in the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 165,000.

Filed Jul 14, 2025 · Visibility · 91,387 miles · GA

The contact owns a 2016 Ford Transit Connect. The contact received notification of the federal safety agency Campaign Number: 20V260000 (VISIBILITY). The contact stated that while one of the employees was driving at various speeds, the sunroof collapsed. The local dealer was contacted. The vehicle was repaired. The contact noticed that the sun visor was not installed. The contact returned the vehicle to the dealer however, the dealer refused to complete the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 91,387. Parts distribution disconnect.

Filed Dec 18, 2024 · Visibility · FL

dealership AL Packer Ford on 1530 N Military Trl, West palm Beach FL 33409 refuse to fix the Manufacturer Recall Number 22S20 (the federal safety agency Recall Number 22V192), they have to remove the windshield and resealed but they hire an company to do it, so the "company' went and check my windshield and they said they can not do it bc they find and crack(which I've never see) and the windshield can the windshield can collapse in the process, the dealer says they won't take care of the windshield if this happens, I called Ford but they say they won't take care of it either, that I can only resolve it with the dealer but they refuse to cover it, and it's not my fault that they used the wrong adhesive for the windshield and now they have to remove it, they recommended that I talk to my insurance but insurance won't cover it and it's crazy that they won't cover it when it's their fault, how do they know that the windshield doesn't have the crack because of the defect in the adhesive

Filed Apr 24, 2024 · Visibility · MA

Ford Transit Connect passenger van with a panoramic view roof window. Driving on the highway, when air starting rushing into the cabin via the glass roof. I was able to pull over before the whole panel blew off. The Front (leading) edge of the glass roof panel is now loose. I can push up on the glass panel and the front edge comes up at least a 1/2 inch now. Ford has a recall listed on the roof panel aleady, but they say my car is not covered by the recall. Campaign/the federal safety agency# 20S22/20V260 Issue Date 2020-05-08 Description On your vehicle, the panoramic roof glass panel may not be properly bonded to the vehicle, which may result in wind noise, water leaks, and in some cases, separation from the vehicle. Safety Risk This may result in separation of the entire panoramic roof panel from the vehicle while driving increasing the risk of a crash or injury. Remedy Parts are now available to repair your vehicles. Ford Motor Company has authorized your dealer to remove, clean, and reinstall the panoramic roof glass free of charge (parts and labor).

Filed Mar 5, 2024 · Acceleration, Engine · 73,000 miles · CA

The contact owns a 2016 Ford Transit Connect. The contact stated that while driving 65 MPH, the vehicle lost motive power. The accelerator pedal was depressed but the vehicle was slow to move. The engine HOT message was displayed. There was an unknown running sound detected. The vehicle was towed to an independent mechanic, and an unknown repair was performed. The vehicle was towed to the local dealer, where it was diagnosed that water had leaked into the engine from the front windshield. The vehicle was repaired. Additionally, the contact stated that the window was replaced but was installed incorrectly. The weather strip was detached. The manufacturer was contacted, and informed the contact that there was no warranty coverage on the vehicle. The failure mileage was approximately 73,000.

Filed Sep 6, 2022 · Visibility · AR

The contact owns a 2016 Ford Transit Connect. The contact received notification of the federal safety agency Campaign Number: 20V260000 (Visibility) and 22V192000 (Visibility). However, the parts to do the recall repairs were not yet available. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact called another local dealer, McLarty Daniel Ford (2609 S Walton Blvd, Bentonville, AR 72712) who informed the contact that the repairs may be completed at the body shop. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Filed Sep 6, 2022 · Visibility · 23,296 miles · KS

The contact called in regard to a 2016 Ford Transit Connect vehicle owned by the U.S. Army. The vehicle was taken to the dealer to be repaired under the federal safety agency Campaign Number: 22V192000 (Visibility) however, upon contacting the dealer four weeks later, the dealer informed the contact that the vehicle had been taken to a third-party technician where the windshield was cracked in the process of completing the recall repair. The dealer informed the contact that they were awaiting the part to replace the windshield. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The manufacturer was made aware of the issue and informed the contact that the part would be available in October 2022. The contact stated that the vehicle had been at the dealer since June 15, 2022. The vehicle was not repaired. The failure mileage was approximately 23,296. Parts distribution disconnect.

Filed May 16, 2022 · Visibility · 60,000 miles · CT

The contact owns a 2016 Ford Transit. The contact stated while sitting in the vehicle, he noticed the windshield was damaged and caused water to leak into the vehicle. The vehicle was diagnosed with windshield failure; however not repaired. The contact related the failure to the federal safety agency Campaign Number: 22V192000 (Visibility). The manufacturer was notified of the failure. The approximate failure mileage was 60,000.

Filed Apr 11, 2022 · Visibility · PA

I kept hearing a banging sound which sounded like it was my ladder rack. So I took my ladder off until I could get it looked at. Which made no difference. And one day while driving I hit a bump in the road and the whole windshield lifted and slammed back down cracking all over. I didn’t know what to do so I was able to get some windshield adhesive and glue it back in however it’s still cracked in several places all over the windshield. And now I’m assuming it has to do with the recent recall. Are they responsible for the windshield? Thank you, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).