Tl* the contact owns a 2001 ford windstar. The contact took the vehicle in for repairs under the federal safety agency campaign id number: 11v030000 (structure: frame and members:underbody shields). The contact stated that the vehicle sat idle on the dealers lot for approximately three months before the contact was informed that the vehicle could not be repaired due to excessive corrosion of the front part of the sub frame. The contact was advised to have the sub frame repaired before recall repairs could be performed. The contact stated that the front and rear of the sub frame was one whole part and if the front was replaced, the entire frame would have to be replaced. The frame was not repaired. In addition, the contact stated that the vehicle was also repaired under the federal safety agency campaign id number: 09v399000 (vehicle speed control) and as a result, the entire cruise control system became inoperable after recall repairs. The contact was concerned with the potential of the vehicle catching fire. The vehicle was not repaired. The failure mileage was 74,000.
2001 Ford Windstar body complaints
Page 5 of 11: complaints 101 to 130 of 293, newest first, as owners wrote them.
There is a re-occurring door failure and extensive rust damage on 2001 ford windstar. The first incident occurred in oct 2006 when the front stabilizer bar failed causing the van to loose control. Ford will not release the record of repair. My van is a modified wheelchair van and we are experiencing a severe sag in the floor on the passenger side, have had to replace the transmission, had multiple repairs due to rust and yesterday the top guide rail for the sliding door cracked and the top of door fell down almost hitting the car next to me. The tracks are extremely rusted and as the floorboard, becoming a safety hazard. I believe the rust issue in this vehicle are far more extensive than the 2 recalls currently in place. This may also be acerbated by authorized modifications to allow wheelchair access. In essence, the van is rusting apart.
Tl* the contact owns a 2001 ford windstar. The vehicle was included in the recall associated with the federal safety agency campaign id number: 11v030000 (structure: frame and members:underbody shields and was taken to an authorized dealer for repairs. After the repairs were completed, the contact noticed that the front frame was unstable and he could easily shift it using his hands. The vehicle was taken to an independent repair shop where the contact was told that the vehicle was unsafe to drive and would not pass inspection. The vehicle was not further repaired. The failure and current mileage was 167,000.
2001 ford windstar. Consumer writes in regards to vehicle recall *tgw the consumer stated she took the vehicle to the dealer because she received a recall letter in the mail. The dealer inspected the vehicle and informed her she would receive another letter in the mail stating when to return with the vehicle. The consumer stated she has not received a letter. *jb the consumer stated the vehicle is emitting gas fumes.. Updated 04/26/11
Product recall made on personal vehicle in february 2011 ( notification sent ) however vehicle was turned in for repair because hood and engine was smoking and overheating ! I was informed then that the car could be potential danger and could relate in vehicle detachment. I turned car into ford dealership and check engine light still appears and car can not pass inspection. I feel very unsafe.
2001 ford windstar limited. Subframe and frame needs repair due to salt corrosion in ohio. There should be a recall to repair these items as ford co. Should have used salt resistant materials to take care of this problem. Updated ivoq 03/17/11
Tl* the contact owns a 2001 ford windstar. The contact was driving approximately 70 MPH when the rear axle fractured followed by a loud noise which caused difficulty in steering. The contact had received notification of the federal safety agency campaign id number: 10v385000 (suspension: rear: axle: non-powered axle assembly) and the vehicle was towed to the dealer for repairs. The dealer advised that the part needed for repairs was not yet available and the contact would be notified when the part had become available. The contact was still waiting for the parts to become available. Most recently, the contact received notification of the federal safety agency campaign id number: 11v030000 (structure: frame and members: underbody shields) but the vehicle was not yet repaired. The contact believed that a reasonable time to adhere to the recall had passed and the vehicle had not yet been repaired. The failure mileage was approximately 127,000. Updated 03/29/11*lj the consumer stated the vehicle has been in the dealer's possession for six months to remedy two recalls. Updated 09/19/11
Tl* the contact owns a 2001 ford windstar le. The contact was driving approximately 65 MPH when the right front sub-frame separated and fractured the engine cradle. The contact lost control of the vehicle and crashed off road. The contact was uninjured and the vehicle was towed to an independent mechanic where they advised him that the right sub-frame was completely rusted. The vehicle was not repaired. The manufacturer was contacted and offered no assistance. The failure and current mileage was approximately 127,000.
In 2008, I experienced a failure of the subframe on my 2001 ford windstar cargo van. I do mostly small-town driving - I.e. Not over 45 MPH, with occasional trips on the nys thruway. I purchased the van used at 57,000 miles from johnson ford, kingston, ny. The failure occurred at 85,419 miles. I drove my van to a local business at about 45 MPH, a distance of 4-5 miles. That day or the day previous I had heard a funny noise as I turned the wheel, but it was not repeated. (I realized afterward that this was the sound of the subframe cracking, but it was not loud enough to really raise any concern when I heard it.) on the day of the failure, I arrived at my destination, parked my car, and a few minutes later, when I came out of the store, I discovered that my tires had apparently broken off and were leaning inward , the car was undrivable. I had it towed to my local mechanic and he was able to find me a used subframe to replace the one that broke. There was. Of course, no information from ford at that time regarding this defect. I have now (feb. 2011) received a recall and had my subframe checked by the dealer and am waiting for the call about a "reinforcement kit", while still being expected to drive this vehicle. I do not consider this a safe vehicle, with or without the "reinforcement" . I believe that ford should be compelled to buy back all windstars still on the road as they were improperly engineered and therefore violated the federal safety agency law as to merchantability. I want a vehicle whose parts are all safe, not a vehicle patched together with epoxy and baling wire. My life and everybody else's lives are at risk from any of these vehicles that are left on the roads. I am unwilling to drive this vehicle anymore, and I am now compelled to purchase a new vehicle, which I cannot afford. For the present I am borrowing a vehicle from a family member, which is ok in the short-term, but it doesn't address my long-term needs.
Today I was driving my 2001 ford windstar from yonkers ny to white plains ny when the rear axle cracked. It was a clear, dry day. This axle had cracked before - in august 2010, prior to the recall being issued. At that time, as there was no repair being offered by ford, I had the axle welded. Welding the axle was a 'fix' reported by other windstar owners so I was not too bothered. Until today I had no problems with the rear axle. The new crack is approximately an inch from where the first one had been. The van had to be towed to my usual mechanic. I am trying to find out if ford has the part to fix this. My mechanic called but said they did not have a replacement. I am not sure what I can do now - this really leaves me in a bad spot as I use my car daily. Others I know who have this same vehicle and trying to have the recalled part taken care of have been having problems because of lack of parts and/or problems getting appointments.
Front end steering,disturbing front end frame sound,ABS lights noticed ABS braking problem,brake light,od light,interior lights flash on and off intermittently when driving. Have to cut the van off and restart for to stop that only last awhile. .took into dealer for recalls still dealing with electrical problem so forth. I never been so scared of an vehicle in my life.
Disturbing sounds from right side front end of my 2001 form windstar. Steering wheel became off center. Problem diagnosed as subframe corrosion.
I just got off the expressway and made a left turn when the front wheels of my 2001 windstar both turned out in opposite directions. I had it towed and found out the frame broke. I had the frame replaced with a used one. Cost $1,187.15 plus tow $105.10. Now I hear this is a common problem and I am concerned it could happen again. At highway speeds I worry about loss of control.
Vehicle is no longer drivable & is sitting at a ford dealership service lot. Incident occurred on tuesday, january 25, 2011 at approximately 4:30pm. Vehicle front subframe cracked and passenger side tire separated from car while driving resulting in loss of control of vehicle. Car would not steer or move, could not be pushed out of traffic.
Front sub frame rusted through front end collapsed while driving 25 MPH.
Abs brake light comes on and disables the ABS brake feature.
My 2001 windstar had been making a scrunching noise each time I went off a curb. I took it to a tire place as that's when I found the crack in the axle in august 2010. The tire dealer didn't make that kind of repair so I call ford dealership who told me to bring the car in and that a recall had just been issued. My car sat for six months. On 1/26/2011 the dealer called and said my axle had been repaired and that I could pick the car up. I couldn't pick it up that day. On 1/27/11 I heard the news state a new recall and I looked it up. Turns out my car is involved in that recall too. I went to the dealer and I communicated to them that I do not want that vehicle back under any circumstances. The ABS light has been malfunctioning for three years or more. Since I got the vehicle I had many problems with sensors and I have had to replace the transmission after having only around 78,000 miles on the vehicle. I completed all maintenance on my vehicle as suggested by ford, yet I have had so many problems. I called ford on 1/27 and told them I do not want the vehicle back. They said a buy back isn't being offered for this recall at this time. It may be offered when the letter is distributed. I still do not want this vehicle back. I have three children and I cannot trust that this vehicle is safe.
My 2001 windstar has severe corrosion on the subframe. The corrosion is located on the right side of the vehicle near the front wheel. The vehicle is currently being held by a dealership for the axle recall, I have made them aware of the corrosion but it seems they have no intention of repairing it since it is not a recall.
My wife's 2001 ford windstar has had a persistant clunk in the front passenger side. While doing some work on the vehicle this evening I discovered severe rust on the rear body mount of the front subframe. The area to the rear of the bushing is corroded through and cracked. I have good digital pictures and will provide them to you if you desire. This problem has been described repeatedly by many windstar owners. Frankly, I find ford's claim that this doesn't present "an unreasonable risk" infuriating. I am calling on you to recall this vehicle before someone gets killed.
1/23/11 while driving to baptism van all of a sudden started to clunk in the right front suspension. While driving home clunking kept happening on right hand turns. Got home, jacked up van, pulled passenger front tire, found excessive rust and sway bar completely broken from subframe. Also noticed front a arm excessive rust not safe to drive. Vehicle will be parked and only 10 years old. Don't know what to do next???? Wife and kids are not safe to drive in. Van is super clean and well maintained and no rust elsewhere. Now what do we do??? ? Please help!!!!
This complaint is related to your the federal safety agency action # ea10007 january 12, 2011, my wife was driving our ford windstar on hwy 155 north of saint germain, wi. Without warning the front end right wheel dislodged and the car swerved violently all over the highway. Luckily, no other cars were near. The roadside ditches where the failure occurred are more than 12' deep, so there could also have been injuries and or damage if she had not reacted as quickly and forcibly as she did. She was able to wrestle the car onto the shoulder and call for help. Upon towing to the nearest ford dealership, it has been determined that the undercarriage failed, the front right axle dislodged from the transmission, and various other damage can also have occurred. Updated ivoq 02/16/11
Vehicle began to pull dramatically when operated and could not be aligned properly. Makes a loud thumping sound when driven. The front right sub frame has corroded such that it has nearly broken off. I have spoken to several mechanics and there is no repair that can be done short of a replacement of the front sub frame. It is to the point where the engine will drop out of the vehicle and the right front wheel will no longer be attached to the vehicle. While I have had the vehicle in for alignment, it can not be aligned again and I have been advised that the condition is extremely dangerous. I brought the vehicle in to a ford dealer for other recall work and was advised that there is no recall for this dangerous condition.
My 2001 windstar failed the yearly state saftey inspection because of frame rotting at the passenger side rear frame mount. I trust my mechanic and he strongly suggested that I do not drive this car ! He would not put a sticker on the car. His estimate for repair was over $2000 .
2001 windstar [xxx] sel sub frame snapped while driving almost causing a serious accident. Tow company said this was very rare that the subframe had rusted through. Repaired at a cost of $1058.03 total parts (used subframe) and labor. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)
2001 ford windstar 280,000 miles ne oh 10-11-10. Right side lower control arm separated from frame. 65 MPH from left lane crossed 3 lanes rush hour traffic. No warning signs somehow no collision. Axle pulled from transmission. Replaced: tire, axle, boots. Frame shop reinforced and straight frame, aligned front end. Repair damaged transmission cooling lines and required replacement.
While driving on a local road at approximately 35 MPH, my 2001 ford windstar broke down and was immobile. After being towed and inspected by a repair service, the cause was determined to be the front subframe. The front passenger side tire was facing right while all others were forward facing. This easily could have resulted in serious injury or a crash if other vehicles had been near or had the vehicle been traveling at higher speed.
2001 ford windstar confiscated by dealer during recall inspection on 11/10/2010 due to crack in rear axle. As of 01/04/2011, no parts are available or expected to be available in the next few weeks. I am concerned about the mounting costs of this confiscation including loss of use of vehicle, reduced vehicle value even after possible repair, cost of interim rental vehicle, lack of communication by ford and the dealership.
I had to replace the subframe on my 2001 ford windstar.
I would like to report a recurring problem that I have had with my ford windstar 2 years ago while pulling out of a parking space the front right control arm pulled free from the sub-frame on my windstar. Fortunately no one was hurt. I had the sub-frame replaced with another used frame by a local mechanic. Last friday I took the van to the local ford dealer to take care of the most recent recall on the rear axles. The dealership called me at home and told me the front sub-frame was severely rotted and the right control arm was barley holding on to the frame. They deemed the vehicle unsafe to drive. I have pulled the vehicle from the road until I can get it fixed. I feel fortunate that it did not break at highway speed with my wife and three kids in the van.
On december 27th, my wife had her ford windstar lx recall on the rear axle fixed at jim kiem ford in hilliard, ohio. She also wanted ford to look into a really bad noise that she was hearing in front when she was turning. It was a loud banging noise. Jim kiem ford told us that the sound that we heard was the sub-frame. They said the sub-frame was rusted and that the vehicle was unsafe to drive. They said that the engine might fall out of the car! My wife and children have been using this van everyday. I have read many windstar owners comments online about the same problem. What does it take to get a recall? Do children have to die!
VIN decoder
See the problems and recalls for an exact car
Buying a used 2001 Ford Windstar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history