During a rear tire check on our 2001 ford windstar it was discovered that there is a crack in the rear axle beam. Friends of ours have the same year vehicle and last year their windstar rear axle beam broke in two and locked up the rear wheels, luckily there was no accident. I have been monitoring our axle beam since then and now it is cracking. I don't dare have my wife drive it, especially on the highway. Why has ford not recalled this??? This could be catastrophic at highway speeds if it snapped. I need to get this fixed immediately and have heard it is at least $1,000 !!
2001 Ford Windstar body complaints
Page 9 of 11: complaints 221 to 250 of 293, newest first, as owners wrote them.
201 ford windstar. Engine/transmission subframe/cradle rusts through leaving vehicle uncontrollable. It is reported to be caused by AC drain dripping directly on subframe assembly.
Traveling along a major highway approx. 70 MPH, the engine cradle assembly became detached from the frame due to corrosion and subsequently the cv axel became detached from the wheel and the control arm also became detached. The vehicle became un controllable and luckily we didn't flip or hit someone else. This is a very serious condition and a sub frame assembly shouldn't come apart on a vehicle with only 70k miles on it. I have called ford motor co. With no help or even an apology as there is no recall for any issues like this. Again, this is very serious issue and we were luck we weren't killed.
Driven down the road the front passenger axle pops out lose of alignment vehicle wont run both front tires are looking the opposite way.... How can I find out how to fix this. Vehicle is not drivable.
Our not for profit owns a 2001 ford windstar which failed to pass nys inspection because the sub-frame is rusted through. This vehicle had less than 160k miles on it. We wash our vehicles every month or so in the winter to rid them of salt so that corrosion is kept to minimum. Too bad ford doesn't stand by their products like toyota, (which paid owners of defective pick-ups which had underbody corrosion 1 & 1/2 blue book value for vehicles). Another reason not to buy american: shoddy materials, shoddy workmanship & uncaring customer satisfaction.
On november 3rd, 2009, the rear axle failed in my 2001 ford windstar while I was on the highway. The car had begun performing erratically so I was not traveling at high speed, but even at low speed it was essentially uncontrollable when the failure happened. In the weeks leading up to the actual failure, I had experienced handling problems with the vehicle. After my mechanic replaced the front struts and rear shocks the car still didn't handle right. They thought this might be because the rear alignment was not a little out of spec - they were waiting for shims to come in to correct that when the axle failed. In addition to my unhappiness about the complaints - the vehicle kind of swerved when going around corners, especially highway on/off ramps - the only warning the car gave in the weeks up to the failure was seemingly-random indications from the tire-pressure warning light. In end end, the garage I took the car to ended up replacing the rear axle assembly and the two rear tires - when the axle failed the tires had rubbed against the tire wells. When searching online for other reports of this problem I came across several here, and posted my own. (my own description as well as four pictures of the failed part are on the site under november 3rd 2009: http://www.carcomplaints.com/ford/windstar/2001/drivetrain/rear_axle_snapped_in_two.shtml.
Tl*the contact owns a 2001 ford windstar. The contact heard a loud noise outside of the vehicle while he was backing out of a parking space and shifting into the "reverse" position. The vehicle suddendly failed to operate in reverse. Immediately, the gear shifter was placed into the "drive" position; followed by no power response. The driver turned the engine off and inspected the vehicle. The front passenger wheel was turned outwardly when the right shaft disengaged from the differential. The vehicle was towed to an authorized dealer for inspection. The technician stated that the failure was contributed to the engine cradle which exhibited severe rust and caused the lower control arm to break. The vehicle was repaired for malfunction. The contact had concern of the safety risk involved. The VIN was not available. The failure and current mileages were 71,000.
The mounting ears on the right front subframe (h-frame that all the suspension, steering , and drivetrain) that connects the lower control arm to the frame rotted off the frame allowing the passenger side tire assy. To swing out from under the vehicle causing a loss of control. Fortunately it happened when turning left at a intersection and not on the freeway. The whole front h frame has to be replaced. The vehicle is an 01 ford windstar with approx. 61,000 miles, always taken good care of and garage kept. Original owner never any accidents.
2001 ford windstar. Subframe rusted away where it attaches to the main frame. Consequences might be loss of steering, rollover or other serious accident. Fortunately, the problem was discovered and repaired at the cost of $1700 before a serious accident occurred.
Tl*the contact owns a 2001 ford windstar. The contact stated that during routine inspection for an oil service, a mechanic located excessive rust in the engines sub frame. Engine failure while driving increases the risk of vehicle crash.the vehicle has not been repaired. He notified the dealer and the manufacturer of the failure. The current and failure mileages were 87,000.
Front subframe rusted through at passenger side mounting point requiring replacement of the front subframe. The condition was noticed immediately after failure due to a change in the direction of the steering wheel and a popping noise during turns, confirmed and repaired at an independent repair shop before any further damage accumulated. I noticed a recall issued on kias of the same vintage for the same problem.
My wife lost control of vehicle, 2001 windstar, 71,000 miles, right front lower control rod broke loose from engine cradle and she lost control of steering. I had vehicle towed to ford dealership. Subframe rusted out at right lower control rod mounting, vehicle is not driven in winter,do not understand how this could have rusted out and caused a possible catastrophic failure. Subframe has been ordered, estimate for repairs from ford dealer is $2,000.00. I have not contacted ford motor company, it appears that they do not care about this failure judging from other customer complaints for the same failure. If this is caused by water dripping from the AC compressor or a defect in the subframe metal, ford should be assisting in these repairs. I have been a loyal ford customer for 30 years and can not believe they would not help with this type of safety issue.
While driving 2001 ford windstar on a 1-hour trip toward home, I noticed the back wheels fish tailing that occurred in every rough spot in the road. I immediately thought the tire was going flat and pulled over to check it. Since the tires visually looked fine, I drove to the next exit to a gas station and checked the tire air pressure and found it was at proper levels. I was still unsure what could cause the "fish tailing" or "hydroplaning" feeling, yet I was able to make it the rest of the way home without a major accident; although my car kept "fishtailing".. The next morning, my husband took the windstar to a service mechanic to inspect the tires. What he found was a rear axle that was "rusted from the inside out" about 3/4 of the way. The mechanic's initial estimate is $1000 (for replacement of new axle and labor). We are relieved that the rear axle didn't break while we were driving as the car could have flipped and killed all of us. What could cause corrosion on the inside? The rear axle should be made to never corrode or break under normal road driving conditions. After researching on the internet, I have found other 8 year old, same make/model windstar owners reporting the same conditions. This is an unsafe part especially noting that people are keeping their cars longer due to economy. Ford should own up to this part failure and recall and replace this part at no charge to the owners immediately!
Tl*the contact owns a 2001 ford windstar. While attempting to make a left turn at an unknown speed, the vehicle made a very loud banging noise. The dealer stated that the engine cradle was rotted out. The repair cost was estimated at more than $500. The failure and current mileages were less than 110,000. Updated 04-23-09 updated 04/24/09.
I started hearing a knocking -- popping noise whenever I turned the wheel. I took it to the mechanic and he said it could be the buckles in the steering rack. When I brought the van to be fixed, the mechanic stated that my problems are worse than that. The rear axle carrier is cracked and needs to be replaced and the front subframe to body is almost completely rusted through and needs to be replaced. He stated that he has seen this problem alot in 2001 ford wnidstars with mileage over 100,000 miles. My van has 108,000 miles. I have had many problems with this van including replacing struts, steering rack, ABS lights constantly on the dash. Check engine light on. All these issues have been addressed and still no resolution. I am very frustrated. This latest "mechanical" issue going to cost me way above $2000. I have always driven ford cars/vans. I am not sure if given the opportunity, if I would buy another ford vehicle. I am very disappointed with ford.
The cradle on my 2001 ford winstar broke off on the passenger side due to rust. Other side is fine. But in the passenger is totally broken off, making popping and cracking noises. Vehicle is unsafe to drive.
I own a 2001 ford windstar and while driving the rear axle beam snapped in half this should not happen this is not a isolated event ford should be held accountable for this.
While pulling out of my driveway, the rear axle on my ford windstar snapped in half. Clean break with both rear tires holding up the rear of the car.
I own a 2001 ford windstar. I noticed strange sound when cornering and brought car to dealer. The rear axle is severely cracked. Being a front wheel drive car, the rear axle is more of a stabilizer, an inverted, u shaped length of steel. Crack is half way up one side of u and over the top. $500 part plus labor would be $1000+ repair. Still deciding to repair or scrap car. It is too unsafe to drive. Dealer states they've never seen anything like it. On web boards, I have seen several cracked / broken axle complaints. This is a real safety issue. Axles should be inspected for cracks. The vehicle was not involved in any collision or incident and dealer can vouch for maintenance record. Dealer thinks crack started small and grew with each turn - especially when turning over a hill or into a low point in the road when flex pressure is largest. They've worked on car several times over past year ' replacing brakes . . . The crack is glaring now and hard to miss. I agree that it probably started small. Axles on windstars should be examined carefully for hairline cracks which will grow.
The lower control a-arm on the passenger side broke loose from the frame causing the van to dropto the ground. This luckly happened when I just pulled into a parking spot in front of a wendy's.
Tl*the contact owns a 2001 ford windstar. The contact took the vehicle to a repair shop for inspection and the mechanic explained that the subframe and engine cradle were rusted and needed to be replaced. The mechanic further stated that the failure was very uncommon. The contact believes that this is a manufacturer defect. The failure seems to originate from the air conditioning unit. Through online research, the contact found numerous others experiencing the same failure. The manufacturer stated that they were not responsible for the failure; therefore, they expected the contact to pay for the repairs. The current and failure mileages were 108,000.
Rear subframe axle assembly part #2f2z 4b435 aa broke in half causing loss of control of vehicle & loss of brakes.
Had just gotten onto highway going about 45 MPH ,changed lanes to accelerate and felt like a tire blew out ,heard something dragging, luckily exited off quickly pulled over to find that rear axel had broke and both tires were on their way to caving in. No accident or injury-thank god. Called ford dealership and was told no recalls on axles and this was a "common occurrence."
Failure of the right lower control arm mounts at the subframe occurred with no warning or prior symptoms. My vehicle is a 2001 ford windstar with approximately 71k miles. My children and I were on a highway on-ramp approaching highway speed when the failure occurred, causing the wheel to swing out from the vehicle and the axle shaft to pull out of the transaxle. The van swayed and bucked with the rear end bouncing up and down off the ground nearly flipping the vehicle. I can't imagine what could have happened four or five seconds later at highway speed. The van was towed to a local service station where it remains about 100 miles from my home. My local dealer was contacted but the service writer said I would need to contact the ford customer relations center who in turn informed me that it was not within ford motor company's guidelines to offer any assistance. Linda, the department supervisor, said that there is nothing she can do, unless the federal safety agency issues a recall, because the van is out of warranty and out of the 5 year range they use for making "good relations allowances". I know there has been at least 12 or 13 similar complaints on the federal safety agency web sight and others on blogs (ie allworldauto.com ) so I agree with one of your complainants that "this is a severe failure that is premature, not easily detectable, potentially fatal, and will likely occur more frequently as these vehicles age". I too, strongly urge the federal safety agency to conduct an engineering investigation regarding this failure.
Paint blistering and coming off, 2001 ford windstar se, color is emerald. Has come off on the hood down to bare metal and also the panels under the doors.
Without any warning the rear axel on my 2001 ford windstar minivan snapped completely in two. We had just gotten off a busy highway and luckily were going very slowly on a side street. We all would surely have been killed if this had happened 5 minutes earlier.
2001 ford windstar 70,000 miles, had a minor fender bender took to the dealer for repair, once I received the van back an hour after the check engine light came on, called dealer they stated that they needed to reset the codes bring it back when I could. The very next day and every day after that until the final day I called stating the steering wheel seemed odd and I had to slightly turn it to the left to go straight. I again was told that they just needed to realign the steering wheel but not to worry. On the fifth day I called and said I wasn't sure the vehicle was safe to drive because the wheel now had to be turned half way to the left to go straight. Again I was told not to worry just bring it in the next day. 3 minutes later the vehicle stopped and wouldn't move. A tow truck was called and it turns out the control arm that was just replaced fell off!! The dealer informed me it was not their fault due to the fact that the frame was rotted out, something they claim to have never seen. Needless to say after hours on the phone with ford and the dealer so far I have gotten no where. So I decided to do some research online and found this site which informed me that there are almost 15 cases of the same thing reported! Why does ford think this is not their problem and are they waiting for a fatal accident to do something about this?
Tl*the contact owns a 2001 ford windstar. The contact noticed that the paint on the roof and rear of the vehicle had abnormal discoloration and was becoming progressively worse. Two months later, he noticed water leaking through the windshield. A professional technician stated that the hooks holding the windshield together were defective. The vehicle has not been repaired. The dealer stated that there were no recalls regarding this failure. The failure mileage was 55,000 and current mileage was 63,000.
There was no crash or injury, I was just wanting to know if there was a recall on the paint on a 2001 windstar. I just bought one and did not realize the roof paint is peeling. I called the dealer and I guess I am screwed.
On october 19, 2007 I backed out of my driveway, shifted into drive and began to go forward when I felt an alarming sensation in my car. I pulled over to the side of the road to inspect my tires. All looked fine so I returned to my car, shifted into drive again and began to go forward when I felt the rear of the car sway. I pulled over again and looked under the back of the car when I saw that my rear axel has snapped in two. On the day of the event my car had 65,700 miles on the odometer. I had my car towed to a local mechanic in wakefield, mass. Both the tow truck driver and the mechanic seperately told me this was shocking and not something that should happen to a car. After analyzing my car the mechanic determined that the broken axel was a manufacturer defect. There is a clean break in the axel where the two broken parts fit together snug like a puzzle. There is no evidence of an accident or tampering to the axel. The mechanic showed me where there is a part of the axel where water can get in, but there is no way for the water to escape. As a result the axel rusted from the inside until it weakened and broke. My mechanic has photographed this part and is holding it at his garage for inspection. As an aside, I have also contacted the owner of stoneham ford, mark melkonian, to report the problem. He looked up my service account and verified I have "been faithful in the maintanence schedule." I, like my mechanic, believe this is a serious issue in which other consumers will soon, if not already, experience an axel break. Had the axel given when I was on the highway with my children in the vehicle, the outcome might have been much more severe. I am afraid if this is not reviewed another family may have a critical outcome in the course of the axel giving way. Could you please advise what I need to do to have someone look at this part of the car and how it simply cracked in two.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2001 Ford Windstar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history