2023 GMC Sierra 1500: won't start

Filed Nov 2, 2026 · Engine · CO

Information related to GMC 25V274 recall for 2023 GMC Sierra 1500 6.2L. Recall oil change inspection and change of oil to higher viscosity performed summer of 2025 (prior to my ownership). On May 17, 2026 the Truck lost engine power without warning and would not start again. Fortunately I was on a road and location where I could coast into a parking lot, but again the vehicle provided no advanced warning of any issue. Towed truck to dealership and determined that exact engine problem noted in recall had indeed occurred to engine. So GMC recall efforts to inspect and change oil had NO effect on the engine defect. Engine was replaced.

Filed Oct 29, 2026 · Fuel system · WA

On [XXX], at around [XXX] my 2023 GMC Sierra 1500 Elevation suddenly lost power while I was driving eastbound on [XXX]. The battery was still running, but the engine lost power and the accelerator did not respond and the truck would not move. I was stranded in the roadway. OnStar emailed me about a critical vehicle issue and reported DTC P129F. Because the truck was stopped in a live lane of traffic, I called 911. Responders blocked part of the road to protect me and to give the tow truck room to recover the vehicle. No one was injured, but this could easily have caused a serious collision. A few days later, I had the truck towed to Seaview GMC in Lynnwood, WA. The dealer diagnosed an internal failure of the fuel pump power control module, the K111 Fuel Pump Driver Control Module mentioned in the GM Bulletin earlier this year. This matches a known issue described in GM Service Bulletin 24-NA-139, which covers DTCs P129F and P023F and lists 2023 Sierra 1500 models. The bulletin describes symptoms including no-start and stalling. The dealership has attempted to charge me $200 for diagnosis and $261 for the fuel pump module. I had asked them if this was covered under warranty, they responded that they would check with their warranty specialist. This conversation happened at the Seaview GMC Dealer approximately 5pm on [XXX]. The informed me they would call the next day to confirm if this is covered or not covered by warranty. I am reporting this because a sudden loss of power while driving on a highway is a serious safety risk. I am concerned that other owners may experience the same failure at highway speed, and I would like the federal safety agency to review this issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 9, 2026 · Body, Electrical · GA

A GM warranty engine replacement was performed at Heyward Allen GMC in [XXX] on XXX at 70,415 miles. We purchase the vehicle on XXX with 73,904 miles and after driving for a month started having multiple malfunction indicator lights displaying, and experienced a no start condition. We took the vehicle to the Don Ledford GMC dealer in [XXX], and they performed a high level inspection. They found missing mounting brackets, loose wiring harness wires, broken and missing bolts. Issues all related to an engine replacement procedure. Deeming the vehicle unsafe to operate. The origin dealer that was paid through GMC to replace the engine is now refusing any responsibility for resolving these issues. Technicians have video evidence of the workmanship issues, documenting the sub- par repair work performed during the engine change. The vehicle now sits at the Don Ledford GMC dealer awaiting an estimated $4400 repair, before the vehicle is safe to operate on the road. The vehicle has been at the Don ledford dealer since XXX, and is still there today, XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 30, 2026 · Engine, Transmission · OH

My wife and I were driving on the highway going slightly uphill. I pushed the pedal a bit because the power wasn't keeping speed. It continues to not maintain so pushed throttle further and the truck stalled. We traversed 3 lanes to get to the shoulder. When I stoped I tried to restart but the car wouldn't turn over but all electrical were working. We were on the shoulder for over and hour on a main highway. We had aaa tow it to the dealership where they confirmed the engine was seized and will be ordering parts. The car is still available upon request. Our safety was at risk from loosing power on the interstate and sitting on the shoulder is very dangerous. I didn't receive any warning lights prior to this occuring. The truck did undergo the peko test and passed and added new oil viscosity. It had roughly 55k miles on it. Always changed the oil before it hit 0% oil life as told by dealerships.

Filed Jun 29, 2026 · Electrical, Engine · MI

Traveling had an engine light come on. stopped at a dealer they inspected found multiple errors reset engine light and said continue home. when home bring into my dealer. Got home that night went to start truck, all kinds of errors started popping up on the dash, vehicle would not turn over at all. Had to call wrecker to have brought into shop. First issue could not put the truck into neutral at all, so they had to pull in park to put unto the bed of wrecker (that seems to be a very poor design of the truck). Brought truck into shop received a call two days later that it is fixed and working fine. Went to the shop asked what the problem was, told there is a ground strap under the truck that is like the main part to make sure everything works regarding electronics. The dealer has had to repair many of these ground straps, they are exposed to the elements and come loose I was told. They had two other GMC trucks in the shop with the same issue that day. the ground strap is exposed to the elements do not understand why this would not be covered just like a battery lead to stop from corroding and have to clean it or replace it. Not to mention there is no where in the service manual I can find about any maintenance that needs to be done with it. Appears to be a very bad design from the car manufacture.

Filed Feb 28, 2026 · Engine, Transmission · NJ

While traveling on a major Route, the truck just turned off while driving. The truck was stuck in the middle of a two lane major route. Truck would not start or turn on. I was unable to put hazards on or put the truck in neutral. The engine siezed due to the GM recall. After having the engine replaced by a certified GM dealership, a few days later the Throttle body stopped working. Again, keeping me stuck. Certified GM dealership had to replace the throttle body.

Filed Jan 20, 2026 · Engine, Transmission · NJ

I had the truck inspected for recall N25249400 on August 11, 2025 with 24,610 miles. It passed the recall inspection and the dealer changed the oil to GM recall recommended oil. On January 18, 2026 with 28,275 miles, the engine seized while on a major highway. The truck lost all power and just turned off amd would not start or turn over. The vehicle was towed by the Police due to the vehicle being in a dangerous spot in the middle of a lane on the highway whi h I had to pay out of pocket. January 19, 2026, the GM dealer confirmed that the truck needs a new engine due to the recall defect. They said that they had just ordered a new engine, but does olnot know hpw long ot will take to get and then install. The dealer is unable to provide a rental vehicle which means, I can't WORK!

Filed May 6, 2025 · Engine · OK

Truck lost all power while towing a trailer driving on the highway. Got it over to the side of highway and lost all power and wouldn't start after parking. Dealership jad truck for over 6 weeks and replaced the motor and would not reset the milage due to manufacturer not allowing it. Since then my rods have a knocking noise occuring while vehicle is running and doesn't sound normal. Rubs rough since the engine replacement.

Filed Mar 17, 2025 · Engine, Transmission · AZ

With out any warning the truck stop running at stoplight an would not start back up. We could not move the truck out of the road and blocked traffic for almost 1 hour waiting for the tow truck and getting it loaded on the tow truck (truck would not go in to neutral). The truck is now at the Dealer and they are saying that the engine seized up and will need replaced.

Filed Mar 6, 2025 · Electrical, Engine · FL

On the highway, the engine suddenly stopped working. Everything turned black. While driving, the screen turned back on but the motor did not start again. I pressed the breaks and the start button to turn the engine back on, while still driving on the highway. It turned back on but then stopped again before I had time to pull to the side of the road. I did the same again and got to bring the car to the side of the highway. It started and stopped several times. I got it to run again so I exited the highway. It turned off again once I was off the highway. I got to drive it slowly to the dealer. He said it had never happened (which is untrue, I found out it is a recurring problem on the GM 6.2 liter). I had brought the car for service to the same dealership about a week prior to the incident. At that time, I told the dealer that the motor was making subtle weird noises. They serviced the car and gave it back to me stating that everything was ok and that nothing showed on their computer. When I picked up the car after the shutting off incident, I was told that their system showed prior issues but that nothing needed to be done since it was not detecting any problem at the time of pick up. About a week after I picked up my truck (after the shutting off issue was supposed to have been taken care of), I returned because I was still noticing the noise. While on a test drive with a GM mechanic, the motor suddenly started making very loud clicking and squeaking noises. He told me to stop right away. The manager at the dealership told me I would get a new motor because there was a recuring issue with the GM 6.2l. After a week, he said only some parts would be changed and that GM would not replace the whole motor. I told him I did not feel safe driving the truck and he said GM decides what to replace not me. I read online that the motor and all oil filters, ducts etc need to be replaced to avoid debris and future problems. No warning light ever went on. Terrifying experience.

Filed Feb 15, 2025 · Engine · AL

1) [XXX] - Was driving on the interstate at 65 - 70 mph when the truck suddenly shut off and shifted to neutral. I was in the far left lane and had to coast thru 2 lanes of high speed traffic to the right shoulder before the truck stopped coasting. Once I coasted to a stop on the right shoulder of the interstate, I tried to crank the truck up a couple of times and it finally cranked and I proceeded on to my destination. When I reached my destination and was attempting to park, the truck shut off again and would not crank after that. I then called roadside assistance to send a wrecker and take it to my local GMC dealer in Montgomery, Alabama. 2) My safety and others was put at risk when the truck, without warning, shut off and lost power while driving at 65-70 mph in heavy interstate traffic causing the truck to suddenly decrease speed and having to maneuver through traffic , without power, while coasting to the side of the road. 3) [XXX] - The service department at Mullinax GMC in Montgomery, Alabama called me about a week later to say the engine had "LOCKED UP" and that they had contacted GMC to begin the process of getting it fixed. They indicated that this was not uncommon with this model truck, and that it happens sometimes. 4) There were absolutely no warning lamps, messages, sounds or any other symptoms of the problem prior to the engine failure. I was caught completely off guard when the engine shut off. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 21, 2025 · Engine · TX

Truck acted like it would not start several times in a day. Had battery replaced and it still did not fix the issue. Was told by dealership I would need to bring in and let them look at it. Was going to delearship and noticed a llight knocking in my engine then all of a sudden lost power. Was able to coast out of traffic and onto a curb. Truck would not start or even try, yet every light and such still worked. Had taken to dealership and this morning was told it was the engine.