2023 Hyundai Santa Fe: brake failure

Filed Sep 2, 2025 · Brakes, Driver assistance · TN

I was travelling at 50mph a car pulled in front of me and stopped unexpetedly. I braked hard. My car began to slow, but the brake pedal went to the floor and did not slow, AFter a few seconds, the brake pedal came up from the floor and braking was resumed. I held the pedal to the floor the whole time trying to stop. It was as though the braking system failed and recovered. There was no pulsing felt on the brake pedal typical of ABS working. After my car resumed braking thte collision avoidance system took over and the car stopped just inches from the stopped car in front of me. I had just taken the car in for dealer service at 24,200 and everything was supposedly checked out as required by maintenance. I have contacted Hyundai but have not gotten a response yet.

Filed May 19, 2025 · Brakes, Transmission · AZ

Front brake failure at 3k miles. Rotors warped so badly they failed to properly stop the vehicle. Vehicle shaking immensely Transmission failure at 11k miles. While vehicle is in Drive mode the transmission is stuck in first gear and will not shift. The tachometer was redlining at 6k I had to use the paddle shifters to get the transmission to shift. I was driving the vehicle as a manual transmission when I own an automatic.

Filed Dec 16, 2023 · Brakes · PA · crash · 4 injuries

While parking, the brakes failed. Although the brake pedal was correctly and completely depressed the car failed to stop until it hit the building causing damage to structure and injuries occurred to passengers. The brake pedal pulsated but the car did not stop. Prior to this, the brakes would sporadically pulsate while braking. There were vehicle health issues that were reported.

Filed Nov 21, 2023 · Brakes, Driver assistance · TN

Upon braking hard and suddenly due to being cutoff on the interstate, it felt as if the antilock brakes did not properly engage but rather grabbed/grinded/scraped. Only when I let off the brake did they disengage. This happened the first time within 2 months of owning the car and with less than 2k miles on it, at highway speeds (65-70 MPH) and this sensation has happened probably 4 times in the 7 months I have owned the car under various scenarios of stopping quickly. In addition, it recently happened when driving 25-30 MPH and coming to a normal stop approaching a stop sign - where it felt as if the brake on the front passenger tire grabbed/grinded/scraped (but not on the 3 other tires). I have taken the car back for inspection at the dealer twice, neither time have they found any issues. In addition, one evening the stability control light flickered, sounded as if the dash was frying/sizzling with no reason - roads were not wet, no leaves, grass or other debris, etc. and speed was 25-30 - this happened twice within 3 miles. Dealer found no issue with car after performing visual inspection of wiring, check of system for code errors, nor driving test to reproduce issue. Had the brakes failed, I could have been in an accident causing serious harm to me/my passengers or whomever I could have hit. I believe the ABS system needs to be replaced or reprogrammed but the dealer refuses to acknowledge a problem exists. Online forums indicate similar (and worse) issues, also with people stating they cannot get a dealer to resolve their problems. This is a serious malfunction of either the electric or braking system in some capacity and should be fixed before people are severely injured or killed.

Filed May 9, 2023 · Brakes, Transmission · OH

Car was purchased January 21st had 3000 mile on it when service was needed for these issues. On march 23rd as I started driving my car wouldn't go above 30 mph, when pressing on the gas pedal the car wouldn't accelerate, the rpm gage would go to 4 but engine wouldn't make noise car wouldn't speed up. I put the car in park and back in drive with no improvement. I pulled off at a gas station restarted the car and it was fine. During this time the auto on off button was orange on the cluster which I had never seen it that color before. Was looked at by the dealer but wasn't reproducible. Not sure the cause, but safety was in jeopardy due to not being able to go with speed of traffic. Also a couple weeks after purchase brakes began to squeal, took car to dealer on march 28th was told brake pads were sanded and cleaned, upon leaving dealer brakes continued to squeal, car is now back at dealer, supposedly needing front rotors and pads replaced. Dealer won't drive car until rotors replaced. Safety was in jeopardy cause of possible brake failure and resulting accident.