2017 Hyundai Tucson: excessive oil consumption

Filed Nov 4, 2026 · Engine, Fuel system · FL

While driving down the highway, the check engine light started to flash. Once the car was turned off and back on again, it shook violently. It was hard to keep it in the lane and I was worried it would cause an accident. It was driven off the highway while constantly shaking. Once it sat off for roughly 30 minutes, it would turn on, but wouldn't turn over and drive. It was towed to a dealership where it was diagnosed, though I was never given anything past a verbal "it stopped compressing". It turns on and over, but makes a grinding noise. It will die and turn off the engine after roughly 45 minutes. This had never happened before. *I've been told a few different things by people who hear about the problem, but I've never received a real diagnosis by the Hyundai dealership it is located at. It has always had a oil consumption problem, adding roughly one quart of oil every 800-1000 miles. It has had oil changes every 5,000 miles. It also had a hard time when cold-started accelerating, but would work fine once heated up. It is available for inspection upon request.

Filed Aug 24, 2026 · Engine · MA

I have a 2017 Hyundai Tucson with a 1.6 turbo engine, and I have been experiencing massive oil consumption. Oil is coming out of the tail pipe with occasional big puff of smoke out of the tailpipe. Skipping and hesitation during acceleration, rough cold start, I have previously had the check engine light on with a multiple misfire code. I changed the plugs and the coils, and it did not resolve the problems. I then took it to the mechanic, and he told me that the car has to go to Hyundai because these are known problems with my particular motor. I took it to Balise Hyundai in Hyannis Mass. and was told that they know about these motor issues but could not help me because the engine light was not on.' If the light comes on, then bring it back and we will check it out'.I was then told that any work performed would be my responsibility to pay for it out of my pocket. If it a known problem by Hyundai, then I think that a recall or something should be posted so customers are not stuck with a very big service bill. Any help to get my vehicle running the way it was designed to would be greatly appreciated. Apparently, there are no recalls or campaigns about these issues on my vehicle even though they are well known to Hyundai

Filed Jun 10, 2026 · Engine · NC

2017 Hyundai Tucson | VIN: [XXX] | Mileage: 75,000 I have owned this vehicle for approximately five years and have experienced severe excessive oil consumption for the past two to three years. The issue was first discovered when the vehicle entered protective mode due to critically low oil levels despite a routine oil change having been performed only a few months prior. I am currently required to add approximately one quart of oil every month to maintain safe operating levels. I visited an authorized Hyundai dealership to have an oil consumption test performed. The dealership informed me that if the test confirmed excessive consumption, I would be required to pay out of pocket for an engine replacement. I declined, as Hyundai Motor America has publicly acknowledged this exact defect in the 2017 Tucson through the federal safety agency Recall 21V727000, multiple Technical Service Bulletins, and a class action settlement covering 2014-2021 Tucson vehicles with the Nu 2.0-liter GDI engine. My VIN was found ineligible on the class action settlement website despite the acknowledged defect. Hyundai has admitted this engine suffers from premature bearing wear, excessive oil consumption, and risk of engine failure and fire. I am requesting the federal safety agency investigate why my VIN falls outside current recall coverage despite presenting identical symptoms to affected vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 21, 2026 · Engine · NC

I am submitting a complaint regarding a 2017 Hyundai Tucson Ultimate AWD equipped with the 1.6L Turbo Gamma GDI engine. My vehicle currently has approximately 127,000 miles and has experienced sudden engine knocking consistent with rod bearing failure and/or catastrophic internal engine damage. The vehicle has been properly maintained, including regular oil changes. However, the engine began consuming excessive oil without warning. Upon inspection by an independent repair facility, the engine was found to have extremely low oil levels despite being within the normal oil change interval. After refilling the oil, the engine continued making severe knocking noises, and the repair facility advised that the engine is likely non-repairable and requires replacement. This failure appears materially similar to the rod bearing and engine failure issues already widely documented in Hyundai/Kia engine defect investigations and class action settlements involving related Gamma and GDI engine platforms. I have learned that Hyundai extended warranties for certain vehicles with similar engine defects up to 15 years/150,000 miles; however, my specific Tucson trim/engine configuration does not appear included despite experiencing the same type of failure. This vehicle has also previously required major drivetrain repairs under warranty, including two transmission replacements and turbocharger replacement. My concern is both financial and safety-related. A sudden engine failure or seizure while driving could create a serious roadway hazard and risk of loss of power in traffic. Additionally, Hyundai dealerships have advised that replacement engines for this vehicle are no longer readily available. I believe Hyundai should further investigate whether the 2017 Tucson 1.6T Gamma GDI engine should be included in existing engine defect warranty extensions and/or recalls.

Filed Mar 30, 2026 · Engine, Fuel system · 68,000 miles · NC

The contact owns a 2017 Hyundai Tucson. The contact stated that the vehicle was consuming an excessive amount of engine oil. There was an abnormal knocking sound coming from the vehicle. There was no warning light illuminated. Due to the failure, the vehicle was towed to a dealer, and the excessive oil consumption was confirmed. The contact was informed that the vehicle was included in the federal safety agency Campaign Number: 21V727000 (Engine), and the engine was replaced. The vehicle was repaired, and a family member retrieved the vehicle and drove it to the residence without failure. Several days later, the family member started the vehicle, and fuel started pouring out from underneath the vehicle. Due to the failure, the vehicle was towed back to the dealer and was diagnosed the vehicle with an O-ring failure inside the fuel injectors. The dealer repaired the O-ring, and the contact picked up the vehicle from the dealer. Soon after retrieving the vehicle, fuel started pouring out from under the vehicle at start-up. The vehicle was towed back to the dealer and remained with the dealer. The manufacturer was notified of the failure, and a claim was filed. The vehicle was not repaired. The failure mileage was approximately 68,000.

Filed Mar 18, 2026 · Engine, Fuel system · GA

This car has major oil consumption that affects the engine and catalytic converter. This can cause engine damage and stalls in driving that affect safety on the roads because the car doesn't accelerate properly. There were no warning signals to indicate this being a problem with the car, especially at purchase. This car will get an oil change and in less than a week, the oil is gone and bone dry.

Filed Mar 16, 2026 · Engine · 63,547 miles · PA

The contact's wife owns a 2017 Hyundai Tucson. The contact stated that the engine was consuming an excessive amount of engine oil. During frequent oil checks, the oil on the dipstick was low soon after an oil change. The vehicle was taken to the dealer approximately 15 times for oil consumption issues. Several oil consumption tests were performed on the vehicle for every 1,000 miles driven; however, the results varied from normal to low oil consumption. The engine had been partially disassembled twice, and pictures were taken and sent to the manufacturer. The manufacturer approved a combustion chamber cleaning to be performed on the vehicle; however, the failure persisted. The contact had spoken with the manufacturer several times and was provided a case number. The manufacturer ultimately denied the request for an engine replacement. The vehicle was not repaired. The failure mileage was 63,547.

Filed Feb 6, 2026 · Engine, Fuel system · IN

Car engine seized and lost ALL power going 60mph down the highway at night with my child in the back seat. I have poured quarts and quarts of oil in this vehicle because it burns oil at an alarming rate until it eventually runs dry and the engine seizes. This is extremely dangerous and luckily my child and I were able to drift to the side of the road without harm and injury. Very discouraging that there are thousands of these cars and engines on the road that can literally seize up at any minute. Maintenance was performed and kept up with. The Oil pressure light had been flashing when the vehicle turned but was flashing even when oil had just been changed. These engines are dangerous and have people in a financial hard spot. I still owe $16k on a car I can no longer drive and that Hyundai is saying due to owner maintenance will not get an engine replacement. The Facebook group Hyundai Oil Consumption test has thousands of people dealing with the same exact issue on these cars and engines.

Filed Feb 5, 2026 · Engine · VA

Purchased used via Carvana in Sept 2025, check engine light came on while driving it home indicating a pre-existing mechanical defect. We submitted the claim through Silver Rock (Carvana's warranty company) and brought to their approved mechanic. The recommended the following repairs, several that were denied by Carvana/SilverRock: spark plugs, alternator, serpentine belt, fuel injection service, electrical ignition coil. A month later check engine light illuminated again and through further diagnostics the mechanic found that 2 of the faulty spark plugs were an incorrect model/fit for our vehicle and reported that information which resulted in replacement being approved (a month after initial request). Fast forward to January 2026 we experienced the widely reported knocking noise while driving coming from the engine and had it towed. The damage is a thrown rod and damaged bearing, which is consistent with the current oil consumption litigation, requiring engine replacement. Our 2017 Tucson 1.6 L turbocharge is not included in the recall. Furthermore, Carfax report shows last oil change reported was 2023. Carvana confirms an oil change is part of their 150 point inspection before a sale, however unable to provide me with documentation and failed to report a record of the work to Carfax. There are many instances of negligence on Carvana's part from failure to provide record of maintenance, which is also failure to adhere to their standard policy, and declining recommended service directly from their approved mechanic, knowing that this vehicle could be impacted by the well known defects through Hyundai. We are requesting assistance with engine replacement meeting safety standards and ensuring consumer protection.

Filed Jan 13, 2026 · Engine · SC

am submitting a safety complaint regarding my Hyundai vehicle due to repeated engine power loss (limp mode), excessive oil loss, and a denied engine recall replacement. I initially brought my vehicle to the dealership after experiencing engine power loss/limp mode, engine oil loss, and illuminated check engine warning lights. The dealership confirmed that my vehicle was covered under an engine recall and stated that the recall procedure was completed. As part of this process, the dealership performed an engine combustion-related service and charged me approximately $1,600. After this repair, I drove the vehicle for approximately 1,000 miles. When I returned the vehicle to the dealership, the vehicle entered limp mode on the same day it was brought in, and the check engine light was illuminated again. The dealership advised me that the vehicle had lost an excessive amount of engine oil during the 1,000-mile period. Due to the continued engine issues and oil loss, the dealership requested a full engine replacement under the recall. However, Hyundai denied the engine recall replacement request. The vehicle’s repeated loss of power, excessive oil consumption, and limp mode create a serious safety concern, especially while driving at normal road speeds. I am concerned that the recall remedy was ineffective and that the denial of an engine replacement places drivers at risk. I am requesting that the federal safety agency review this matter for potential safety defects and improper handling of a known engine recall issue.

Filed Jan 11, 2026 · Engine · NC

Engine is burning oil causing the catalytic converter to clog and fail. Hyundai dealership told me after I had the car towed to them for repair on 12/30/2025 that the catalytic converter had already been replaced before in March 2024. I had purchased the car from another dealership March 2025 and the catalytic converter replacement was not on the car fax. I was also I formed by the Hyandai dealership that my car has an extended warranty of 10 year/150,000 miles on the engine due to the known oil consumption issue. My car has 131,000 miles. I was told Hyandai will make it very difficult for engine replacement since I’m a second owner. There needs to be a recall immediately.

Filed Jan 5, 2026 · Engine · 63,000 miles · NY

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at various speeds or accelerating from idle, there was a knocking sound coming from the engine. While accelerating from idle, the vehicle failed to exceed 30 MPH, requiring that the driver slowly accelerate and gradually increase the speed. No warning lights were illuminated. The vehicle was taken to a certified mechanic who diagnosed the vehicle with transmission failure. The mechanic replaced the brakes and tires. The vehicle was then taken to the dealer, who diagnosed failures with the muffler assembly and catalytic converter related to the failure to accelerate. The failure persisted, and the vehicle was returned to the dealer, who confirmed the noises coming from the engine while the accelerator pedal was depressed, with a burning odor, and oil issues. After five visits to the dealer, an oil leak from the drain plug was determined. The drain plug and oil pan were replaced a year and six months later. The vehicle continued to fail to accelerate properly, making it difficult to drive uphill. The vehicle was taken to another dealer, Niagara Hyundai of Grand Island (1910 Alvin Rd, Grand Island, NY 14072), who confirmed that the vehicle was not safe to drive. The catalytic converter was replaced again but the failure persisted, and there was no engine oil in the vehicle. While driving 65 MPH, the vehicle started shaking. The contact pulled over to the side of the road and waited approximately 10–15 minutes before continuing to drive at 50 MPH. The contact inspected the vehicle and noticed that the engine was hot. The vehicle was towed back to the second dealer, who performed an oil consumption test requiring the contact to drive 1,000 miles. The test determined the engine oil level was extremely low. The dealer suggested a chamber cleaning, but the request was still pending. The manufacturer was made aware of the failure and opened a case. The failure mileage was approximately 63,000.