2016 Jeep Grand Cherokee technical service bulletins
408 technical service bulletins and manufacturer communications cover the 2016 Jeep Grand Cherokee, including one warranty extension.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- FCA Caribbean Warranty Newsletter – Volume 11, Issue 6
- Qudra Lift Reman Compressor Excessive Repairs on Quadra Lift Reman Compressors Part Numbers: 68041137AF /...
- Outside Power Fold Rearview Mirror Noise Or Loose At Pivot
- Power Liftgate Inoperative.
- The vehicle will exhibit a service transmission/check engine warning indicator for the following...
- Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00,...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Isolator - engine mount
- Verify "Z" part number availability
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Verify Reman part number availability
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Engine Rattle Noise
- Decreased Remote Start And RKE Range
- When replacing a camshaft and parts kit (P/N 68661146xx and/or 68661147xx), it is NOT necessary to order...
- Adjuster
- Warranty Newsletter – Volume 11, Issue 6
- Tube - fuel injector supply & gasket - none
- 3.6L psu
- 3.6L psu
- Touchscreen For all infotainment system repairs (touchscreens, radios, etc.), refurbished parts may be...
- Rail - fuel
- 3.6L psu
- Fuel pump/level unit module
- Headrest
- Plate
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Suspected Engine Coolant Leak
- Pump water
- Spring Front Upr
- Verifying Camshaft Diagnosis
- Lifter
- Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair...
- PUMP Water For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak
- Suspected engine coolant leak.
- Warranty Bulletin D-16-03
- FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage
- Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review...
- Water Quality When Mixed With Engine Coolant
- WiTECH Small Leak Verification Test (SLVT)
- Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant Level...
- Adapter
- Adapter
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Perceived Low Power/Acceleration Lag, And/Or Malfunction Indicator Lamp (MIL) Illumination, Diagnostic...
- Approved Use of Weld Through Primers
- No Start, Start Stop Inoperative, Cluster Message Service Start Stop System
- Overhead Console If the sunglasses holder door in the overhead console will not stay closed, inspect the...
- Powertrain Diagnostic And System Enhancements
- If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is...
- Engine
- Complete Engine Assembly Replacements Arriving Without Engine Wiring Harness.
- Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire
- Engine Oil Filter Interchangeability
- Water Leak From Overhead Console, A Pillar And Or Headliner
- Rattle Coming From Sunroof
- Diesel Fuel Injector Cleaning Procedure
- 3.0L Ecodiesel Engine Oil Information
- Pentastar Upgrade Oil Fill Level after an Oil Change
- Warranty Bulletin D-21-11 (X95) 3.0L Diesel Crankshaft Tone Wheel
- 3.0L Diesel Crankshaft Tone Wheel Loss of Signal
- No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
- Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement...
- Air Suspension System Diagnosis
- Wiring
- Customer Complaint May Include Engine Oil Leak Or Consumption
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle,...
- Battery Tester Warranty Code Procedures, Midtronics Charger Update Process
- Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
- Battery Tester Warranty Code Procedures, Medtronic Update Process
- Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles
- Customer complaint may include engine oil leak/consumption.
- Air Suspension Inoperative And Or Compressor Freeze Up Or Sticking In Cold Weather.
- Vehicle Sway At Very Low Speed While Being Flat Towed Behind A RV
- Vehicle Sway While Being Flat Towed Behind A RV
- Overcharging/Undercharging DTC?s Interior And Exterior Lamps Flicker, Electronic Stop/Start (ESS) Operates...
- Safety recall W58 - loss of crank position
- Cruise Control Inoperative.
- Warranty Bulletin D-20-10 (X88) Active Head Restraint
- Active Head Restraint (AHR) Inadvertent Deployment
- Warranty Bulletin D-20-10 (X88) Active Head Restraint
- Warranty Bulletin D-20-10 (X88) Active Head Restraint
- (Rev. A) Malfunction Indicator Light (MIL) Illuminated
- Active Head Restraint (AHR) Inadvertent Deployment
- (Rev. A) Power Inverter Load Ratings
- (Rev. B) Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant...
- Aluminum Body Panel Corrosion Repair
- Improper Up Shift With Paddle Shift
- (Revision A): P2463-00-DIESEL PARTICULATE FILTER
- (Revision A) Heated And Vented Seats Inoperative Driver And Passenger
- (Revision A) Clunk Noise From Rear Suspension
- (Revision A) Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ?...
- D-20-10 (X88)
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle
- Customer Satisfaction Notification W41 Reprogram Powertrain Control Module
- Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions...
- Trailer Wiring Connector Adapter 4-Pin And 7-Pin Circuit Identification
- Blind Spot Or Park Assist Warnings, False Activation
- Service 4wd Light On, Message AWD System Service Required
- Customer complaint may include an overfilled engine crankcase after an oil change.
- Flash: Powertrain Control Module (PCM) Updates
- Liftgate Will Not Power Close Liftgate Ajar Light Will Be On. Liftgate Will Not Power Open.
- Malfunction Indicator Lamp (MIL) on. Diagnostic Trouble Codes (DTCs) P2463 ? Diesel Particulate Filter...
- Disinfectant Solution Recommended for COVID-19
- Charging System, Battery Diagnostic Tools and Warranty
- Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season
- Hands On Steering Wheel Message In EVIC
- No Start, No CAN C BUS Communications
- Customer Satisfaction Notification VA7 3.0L Diesel Performance
- Water Leak At Rear Lift Gate D Pillar.
- LED Front Fog Lamps Flicker Or Intermittently Light, Are Dim Or Inoperative
- 3.0L Oil Filter Cartridge Identification Differences And Oil Filter Element Servicing Procedure
- Revised Emissions Recall V11 3.0L Diesel Emissions
- Revised Emissions Recall V08 3.0L Diesel Emissions
- Creaking Noise From Front Of Vehicle With Body Flex
- Key Programming, Security Pin Request, Pin Invalid
- Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the...
- RA3 and RA4 GPS Calibration Update
- Cover
- Revised Customer Satisfaction Notification VB3 ? Navigation Flash
- Repair Parts Used For Structural Repairs
- Authentic Mopar® Glass Replacement
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- RRT 19-090 (Service Bulletin 08-111-19) 2013-2018 Multiple Vehicles RA3/RA4 Radio GPS Certification Error
- Latch
- RA3 and RA4 GPS Radio Update
- Radio, multi
- GEN-2 and GEN-3
- Flash Over The Air (FOTA) Software Update RA3 and RA4 Radio
- Dash and Door Appliques Delaminating
- Radio [res]
- V08/V11/V16 3.0L DIESEL EMISSIONS CAMPAIGNS FREQUENTLY ASKED QUESTIONS (replaced OD55489)
- V08/V11/V16 3.0L diesel emissions campaigns frequently asked questions
- Emissions recall V08 & V11 3.0L diesel emissions important step in dealer instructions
- ACTUATOR, A/C and Heater Before replacing HVAC actuator, please contact either Thomas Conway (248)...
- Emissions recall V08 - 3.0L diesel emissions veci label placement and photo requirements
- V08/V11 EPA AND CARB APPROVED EMISSIONS MODIFICATION AND EXTENDED WARRANTY NOTE: VINS LIVE MAY 3rd , 2019...
- (X78) Emission Control System ? 3.0L Diesel
- Trans Oil Pan, Heater Tube or O-ring, Heater Applies to vehicles equipped with 8 speed transmissions only;...
- Flash: Powertrain Diagnostic and System Enhancements
- Flash: BCM Diagnostic and System Improvements
- Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable...
- RA3 and RA4 Radio Over The Air Software Updates
- Customer Satisfaction Notification T23 ? EGR Valve Function The Powertrain Control Module (PCM) on about...
- Flash: Active Noise Cancellation Module Software Enhancement
- This bulletin involves updating the electronic shift module (ESM) software and if necessary replacing the...
- Transmission Oil Cooler Lines For WK/WD Bodies ONLY; Before replacing TOC line, please call/text Karen...
- This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a...
- This bulletin involves inspecting and if required, updating the radio software.
- Park Assist ECU (WK & RU) The
- Vehicle Unable to Reach Max Speed
- Flash: Electronic Shift Module (ESM) System Improvements
- Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter...
- Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures...
- RA3 and RA4 Radio Enhancements
- Brake Pedal Sensor For vehicles with DTC's P0572 or C0042, or complaints of brake lights staying on or...
- Rear View Camera In the case for inoperative camera, radio screen is blue or black in reverse mode
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Flash: Powertrain Diagnostic And System Enhancements
- Door Hinge Assembly Side door hinge noisy
- Electric Power Steering Gear If any of the following DTCs exist, it is okay to replace the steering gear:...
- Trans Pan or Gasket If your repair requires replacing one of the two part numbers for a leak, prior to the...
- RA3 And RA4 Radio Over The Air Software Updates
- Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for...
- Cleaner For A/C Evaporator Before using deodorizer to remove HVAC or evaporator odor, call Ken Deneau at...
- Restraints Remove I-Sheet from packaging
- Restraints Information Sheet (I-Sheet) has been added to Star Parts
- Variable Valve Timing (VVT) Solenoid, Variable Valve Timing (VVT) Phaser For a 2016/2017 MY 6.4L SRT with...
- Water Pump Dealers are replacing water pumps because of a coolant leak
- License Lamp If vehicle comes in for license plate bulb replacement, you will need to determine the...
- Click, Creak, Or Groaning Sound Near C-Pillar, Dual Pane Sunroof
- TANK, Diesel Exhaust Fluid, Part Includes Temp Sensor and Level Sensor For DS and WK vehicles ONLY; If the...
- RA3 And RA4 Radio Enhancements
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Engine Oil Viscosity Upgrade And Flash Enhancements
- PSU Exhaust Phaser 05048043AB If replacing the Exhaust Phaser for the following codes: P0340 Cam...
- Engine Oil Pan Replacement
- Panel, Front Seat Back For WK and WD Bodies ONLY: If the customers are complaining the seat back panel is...
- Seat back panel loose or, has poor fit at top edge, side and bottom.
- Flash: powertrain diagnostic and system enhancements
- TPM Sensor 2016 WK/WD vehicles only
- Flash: Powertrain Diagnostic And System Enhancements
- Flash: Transmission Diagnostic And Shift Enhancements
- Camshaft Replacement
- TANK, Diesel Exhaust Fluid, Part Includes Temp Sensor and Level Sensor For DS and WK vehicles ONLY; If the...
- MY16 RA3 & RA4
- Brake Pedal Sensor For DS, WD & WK bodies ONLY; Prior to replacing the brake sensor; Please call Salma Al...
- Shifter & PRNDL For 2016 WK ONLY; If vehicle DTC Code U114C-00 (Loss of Communication with PRNDL Display)...
- Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature
- Shifter & prndl for 2016 wk only; if vehicle DTC code U114C-00 (loss of communication with prndl display)...
- Shifter & PRNDL For 2016 WK ONLY; If vehicle DTC Code U114C-00 (Loss of Communication with PRNDL Display)...
- Replace Both Intake Variable Valve Timing Solenoids
- Re+G21:H21place Both Intake Variable Valve Timing Solenoids
- 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH...
- Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the...
- 3.0L V6
- Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold...
- Electronic parking brake module connector water intrusion.
- 3.0L V6
- RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free...
- Subject: RA3 RA4
- RA3 RA4
- Subject
- Subject
- Overview
- SYMPTOM/CONDITION: A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination
- Flash: Intrusion Transceiver Module Enhancements
- Intrusion Transceiver Module Enhancements
- Radio Frequency Module RF_HUB Before Replacing RFHM (RF-hub) for any reason for 2015 or 2016 WD or WK...
- Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar...
- Radio Frequency Module.
- Chirping Or Squeaking Coming From The Second Row Headrest
- Customers may describe a chirping or squeaking coming from the rear second row seat headrest(s) while driving.
- This bulletin involves updating the Wireless Control Module (WCM) with new software.
- Incorrect Jeep Emblem On Liftgate
- The vehicle may have the incorrect Jeep emblem installed on the vehicle
- 2016 WK/WD vehicles only
- TPM Sensor
- Speed Transmission Quick Learn Procedure.
- Powertrain Diagnostic And System Enhancements.
- EGR Temperature Sensor This Tech Tip applies to 2016MY Jeep Grand Cherokee (WK) and Dodge Durango (WD)...
- EGR Temperature Sensor
- Summary to be provided on a future date.
- Flash: 3.0L Powertrain Diagnostic And System Enhancements
- Fast feedback program - 3.6L V6 24V VVT ENGINE-2016 dodge durango/jeep grand cherokee (rev
- Flash: Transmission Enhancements
- Warranty bulletin
- Fast Feedback Program
- Transmission Enhancements.
- Load Floor Handle If you are in need of a load floor handle, please just order the handle, it is no longer...
- Load Floor Handle.
- This bulletin involves reprogramming the Instrument Panel Cluster (IPC) with the latest
- NAG1 (5A580)
- Replace Left Front Axle Half Shaft
- Replace Left Front Axle Half Shaft.
- Electronic Vehicle Information Center (EVIC) Switch Replace
- Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code
- Fast feedback program - 3.6L V6 24V VVT ENGINE-2016 dodge durango/jeep grand cherokee to announce a fast...
- Fast Feedback Program
- RL4 RK4 RM4
- 82212076, 82203694
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Jeep Grand Cherokee?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history