Fuel gauge don't work, don't know how much gas is in the tank
The worst 1992 Jeep Wrangler problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system25
- Brakes12
- Transmission11
- Seat belts9
- Engine7
- Electrical6
- Body5
- Steering3
- Locks2
- Seats2
- Tires2
- Visibility2
- Suspension1
Specific symptoms reported on the 1992 Jeep Wrangler
Recalls 4
Parking brake: conventional
- What is wrong
- On certain sport utility vehicles equipped with manual transmissions, the parking brake can self-release without warning.
- Risk
- This could allow the vehicle to roll away, increasing the risk of a crash.
- Remedy
- Dealers will install a parking brake assembly with a stronger pawl return spring. Owner notificaton began september 30, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1‑800‑853‑1403.
Recall number 02V041000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- Vehicle description: multipurpose passenger vehicles equipped with plastic fuel tanks. The fuel tank sending unit gasket can crack causing fuel and fuel vapor leaks.
- Risk
- Fuel and fuel vapor leaked from the fuel tank can result in fire when exposed to a source of ignition.
- Remedy
- Replace the fuel tank sending unit gasket.
Recall number 94V106000 · Recall details
Electrical system: ignition: switch
- What is wrong
- Salt corrosion products between the starter solenoid wire and the adjacent battery feed in the bulkhead connector may short these connections, causing the circuit to bypass the ignition key control of the starter motor solenoid. The car can start without the starter sequence being initiated by the ignition key in the ignition lock.
- Risk
- The unintended start of a vehicle with a manualtransmission left in a drive gear can result in a runaway vehicle.
- Remedy
- The starter solenoid wiring will be separated from the battery feed wire by relocating it within the bulkhead connector on affected vehicles.
Recall number 93V083000 · Recall details
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
- What is wrong
- On 1987 through early 1990 models, both front brake hoses can wear due to direct contact with the wheel opening splash shields. On the late 1990 through 1992 models, periodic rubbing contact of the left front brake hose can occur due to movement of the splash shield in certain vehicle operating conditions.
- Risk
- Either condition can cause loss of front brake systemfunctions, resulting in increased stopping distances and an increased risk ofvehicle accident.
- Remedy
- The 1987 to 1990 model vehicles will have both splash shields replaced and both front brake hoses replaced as necessary. All affected late 1990 through 1992 model year vehicles will have additional fasteners installed to further secure the left side splash shield. Also, the left front brake hose will be inspected and replaced as necessary.
Recall number 92V148000 · Recall details
See all 4 recalls for the 1992 Jeep Wrangler
Defect investigations
Brake roter disc/hud separation
There is no summary currently available
EA99014
Fuel leakage
Odi has received 6 reports on fuel leakage and 3 reports on alleged remedy failure reports
RQ97016
Rear axle shaft separation
This investigation was opened to examine the failure mode and the risk to motor vehicle safety posed by allegations of rear axle separations.the rear axle shaft and housing design is typical of those in which the weight of the vehicle is carried on the axle housing.the left and right axle shafts, supported by roller bearings, are situated inside the axle housing.the inboard splined end of the axle shaft receives power transmitted from the differential assembly, providing torque to the rear wheels.the allegations are that the axle shaft fails, resulting in the separation of a wheel and axle hub assembly or the entire axle shaft and wheel assembly, depending on the location of the axle shaft failure.as identified by chrysler, the subject rear axles are dana 35c and 35cm models, which have been used on the subject vehicles since the 1990 model year.a safety defect trend with respect to the subject axle shafts has not been identified.see hard copy resume for full text of summary.
PE95049
Sending unit gasket fails
There is no summary currently available
EA93031
Driveshaft/univ.joint fail
There is no summary currently available
EA93025
Fuel line leakage
There is no summary currently available
PE93051
Technical service bulletins for the 1992 Jeep Wrangler 11
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- DIPAP Requirements
- Part Description: Insulator on Lever Assy Manual Valve
- Subject regarding wire splice repairs
- This bulletin provides a revised wire splice procedure and related parts
- Outer exhaust manifold studs may fatigue/break
- The outer exhaust manifold studs may fatigue and break
- Information on installation of radio transmitting equipment
- Various car owner's have expressed interest in using engine coolants made with propylene glycol instead of...
- Concerns with engine coolant usage
- Difficult to clean light colored "chalky" residue from plastic body components that are molded in black
1992 Jeep Wrangler fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 2.5L 4‑cyl | 4WD | 16 | 19 | 17 |
| 4.0L 6‑cyl | 4WD | 14-15 | 15-20 | 14-17 |
What 1992 Jeep Wrangler owners say
Most recent owner complaints, unedited.
The contact owns a 1992 Jeep Wrangler. The contact stated upon completing a VIN search online, he became aware that the vehicle was included in the federal safety agency Campaign Number: 94V106000 (Fuel System, Gasoline). The vehicle was taken to the dealer who informed that they could not complete the recall repair since the part for the recall repair was no longer available. The manufacturer was notified of the issue and advised accordingly. The contact stated while driving 35 MPH, he smelled a fuel odor and as he looked at the rearview mirror, he saw a trail of fuel that had been leaking from the vehicle. The vehicle was not diagnosed nor repaired. The dealer and manufacturer were not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 156,200.
I am on military orders and am planning on shipping my jeep wrangler to my next duty station located in lima peru. I am told that prior to customs shipping the vehicle it has to be clear of all recalls. The local dealership in san diego located at 777 camino del rio s san diego ca phone # 619‑224‑4151, is telling me that they will no longer perform recalls due to the age of the vehicle. I was wondering if you could help with this situation. Regards, [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Tl* the contact owns a 1992 jeep wrangler. After checking the VIN, it was discovered that the vehicle had two open recalls, including the federal safety agency campaign number: 94v106000 (fuel system) and 02v041000 (service brakes). After notifying the manufacturer of the recalls, the contact was informed that the parts needed to complete the recalls were no longer being produced due to the age of the vehicle. A remedy for the recall would not be provided the local dealer was not notified. The contact had not experienced a failure. Updated 08/04/17*lj
I have previously written to you under reference #10429043, for a leaking gas tank. Chrysler has since blown me off and not addressed this recall or safety issue. I now carry two fire extinguishers in the car awaiting the impending explosion and/or fire. In addition, chrysler took my car to their bayside jeep dealership and charged me $217.75 to install clamps on (I believe) the gas line. That lasted about 6 months before the leak started again. [xxx] (no last names are given) from chrysler advised me that they would refund my $217.75, which was never done. Today, I read an article in the ny daily news that chrysler is dodging the recall by the federal safety agency on gas tank problems with many years of jeeps, which proves my point more that they are distancing themselves from their responsibilities. I would like my forever leaking gas tank finally fixed and I would like my $217.75 refunded; or they can offer me a brand new jeep as a replacement, as long as the gas tank doesn't leak. Otherwise, I would like to be fully involved in any class action law suits against chrysler. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
I am on my second time replacing the slave cylinder. The owner before me replaced it 3 times.
Tl* the contact owns a 1992 jeep wrangler. The contact stated that upon starting the vehicle, he could smell a very strong odor of fuel. The vehicle was towed to an authorized dealer and the contact was informed that the fuel tank was leaking. The contact was also informed that the vehicle was not included in the recall associated with the federal safety agency campaign id number: 94v106000 (fuel system, gasoline:delivery:fuel pump). The manufacturer was made aware of the failure and the contact was awaiting a response. The failure mileage was 150,000.
Gas tank overflows every single time it is filled up, if it wasn't for me having to hold in the nozzle the entire time and noticing it is overflowing, it would just keep overflowing gas onto the ground.
Vin [xxx] I have a 1992 jeep wrangler saraha yj with about 150,000 miles. This is the third time that the tilt steering column broke. There seems to be a shear pin which keeps the tilt steering mechanism in position. When the shear pin breaks the tilt steering just flops up and down. Periodically the shear pin on the tilt steering breaks. It just broke again for the third time in about 5 years. It costs about $300 to fix. The mechanic said that this vehicle has a propensity for this problem. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Steering wheel up/down adjustment safety latch defective. For no apparent reason steering wheel latch broke and steering wheel will not lock into place. Steering wheel eust flops up and down. Contacted manufacturer re: recall and to fix defect.
Compare the 1992 Jeep Wrangler
Wrangler vs Toyota 4RUNNERWrangler vs Ford Bronco
Other model years
1990199119921993199419951996199719981999200020012002200320042005200620072008200920102011201220132014201520162017201820192020202120222023202420252026
Questions about the 1992 Jeep Wrangler
Is the 1992 Jeep Wrangler reliable?
Owners have filed 77 complaints about the 1992 Jeep Wrangler, fewer than a typical Wrangler model year.
What is the most common problem with the 1992 Jeep Wrangler?
Fuel and propulsion system, with 25 complaints. Next is brakes (12).
How many recalls does the 1992 Jeep Wrangler have?
4 recalls, covering parking brake, fuel system, gasoline and electrical system.
Was there a recall on the 1992 Jeep Wrangler fuel system?
Yes, 1 recall: 94V106000. Check your VIN to see if your car still needs the free repair.
What year does the Jeep Wrangler have the most fuel system problems?
The Jeep Wrangler model years with the most fuel system complaints are 2006 (479 complaints), 2005 (448 complaints) and 2010 (228 complaints).
What gas mileage does the 1992 Jeep Wrangler get?
Official estimates for the 1992 Jeep Wrangler range from 14 to 17 mpg combined. The most efficient version (2.5L 4-cyl, 4WD) gets 16 city and 19 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1992 Jeep Wrangler?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its historyJeep Wrangler in the news
- Jeep recalls 2026 Grand Cherokee, 2026 Wrangler and 2026 Cherokee and other models over back over prevention camera problem (844,028 vehicles)
- Jeep extends warranty coverage on 2018-2023 Wrangler, 2020-2023 Gladiator and 2021-2023 Wrangler 4xe (structure body)
- Jeep extends warranty coverage on 2018-2022 Wrangler, 2020-2022 Gladiator and 2021-2022 Wrangler 4xe (electrical system)