2017 Kia Optima: check engine light

Filed May 26, 2026 · Engine · 98,000 miles · KY

The contact owns a 2017 Kia Optima. The contact stated that on three of four occasions while driving at approximately 50 MPH, the vehicle began rattling and shaking, and he observed a knocking noise emanating from the engine compartment. The check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the knock sensor needed to be replaced, and he was advised that his vehicle may have been included in Manufacturer Recall Number: SC162. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 98,000.

Filed Feb 12, 2026 · Engine · 130,000 miles · AZ

The contact owns a 2017 Kia Optima. The contact stated that while driving at 67 MPH, the vehicle experienced a loss of drive power, and the vehicle went into LIMP Mode. The check engine and HEV warning lights were intermittently illuminated. The contact entered the vehicle settings, and the ECU message was displayed. The contact stated that the failure had occurred three times. The vehicle was taken to the dealer, but the failure could not be duplicated. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

Filed Jan 4, 2026 · Engine · ND

Kia Engine Settlement-Kia America and Grand Forks KIA dealership is refusing a mandatory diagnostic test for excessive oil consumption under the Kia Theta II Engine Class Settlement, despite the vehicle having the required KSDS software update installed. The vehicle is consuming 1 quart of oil every 1000 miles, requiring constant topping off to prevent engine seizure. Vehicle was brought to Kia Grand Forks on 7/21/25 was told that the valve gasket needed to be changed. Engine light illuminated 10/2025 and car was unable to make it back to dealership from 58369. Vehicle was brought to local mechanic where I was told that the has failed and that the spark plugs had oil on them. Mechanic changed the spark plugs to make it to Grand Forks Kia on 10/14/25 I was told that the Turbo needed to be replaced for $3300 before they can do an oil consumption test. There were no issues with the turbo before it was driven to Grand Forks on 10/14/25. Kia America refuses to cover the engine warranty which will lead to "sudden engine stall, loss of power, or vehicle fire," which are primary safety concerns monitored by the federal safety agency.

Filed Dec 30, 2025 · Electrical, Engine · 98,000 miles · UT

The contact called on behalf of her daughter who owns a 2017 Kia Optima. The contact stated while driving at approximately 60 MPH, the vehicle made an abnormal knocking sound, the cruise control was inoperative, the infotainment screen darkened, and the charging outlet was inoperative. The Check Engine warning light was intermittently illuminated. The vehicle was taken to the contact's residence, and the contact used a vehicle scanner to scan the vehicle. The contact stated that DTC: P1326 for the Knock Sensor Detection System (KSDS) was found, which detected excessive engine vibration. A dealer was contacted; however, the vehicle was not diagnosed or repaired by the dealer. No further information was available. The failure mileage was approximately 98,000.

Filed Oct 28, 2025 · Engine · 100,400 miles · CA

The contact owns a 2017 Kia Optima. The contact stated that upon routine maintenance with a local independent mechanic, it was discovered that the vehicle had low engine oil. No warning light was illuminated. The vehicle was taken to a local dealer, where it was determined that an oil consumption test was needed to determine any failure. The vehicle was not repaired. The check engine warning light was illuminated. The contact stated that engine oil was added almost every 2 weeks. The message to "Contact the Dealer" was displayed. The vehicle was towed to Team Kia of El Cajon (541 N Johnson Ave, El Cajon, CA 92020), where it was determined that there was engine oil leaking onto the catalytic converter. The contact related the failure to a Kia recall related to a connecting rod bearing failure. The manufacturer was made aware of the failure. The failure mileage was approximately 100,400.

Filed Aug 21, 2025 · Engine · GA

Car began hesitating and stalling, particularly from a stop. Engine light came on. Took the car to the KIA dealership for diagnosis. Was told by svc coordinator that the diagnosis indicated a bad knock sensor. The technician replaced the knock sensor, then test drove the car. It failed immediately. I was told that it would likely need engine replacement. After a few days, svc coordinator called and said that KIA recommended replacing the knock sensor (again) and perform a tuneup. They declined to replace the engine. The car runs in "limp home mode" (Kia's terminology), hesitates and stalls so as to make it very unsafe to operate. The engine on this car was replaced about two years ago for excessive oil consumption. There cannot be more than 30k miles on the new engine. KIA stated that there is a lifetime warranty on the replaced engines, but are apparently not going to honor the warranty. Car is serviced regularly and is in otherwise excellent condition.

Filed Jul 7, 2025 · Engine, Transmission · TX

Engine is failing and using over 3 quarts of oil every 700-100 miles. Spark Plugs have become oil fouled and replaced all 4 spark plugs June 11th, 2024 and replaced all 4 spark plugs again January 12th, 2025. Today July 7th, 2025 Check Engine light came back on with Engine Misfire code P0303 Cylinder 3 Misfire, changing spark plugs again today. My safety is put at risk because oil consumption is a know issue with Kia GDI Engines. At any moment my car can run out of oil if it is not check every other week causing my engine to completely fail or a spark plug become Oil fouled and a spark plug needing to be replaced. In July of 2024 when this happened I was on the highway going 70 mph and my car just completed shut down. I could have been seriously injured had I not been able to pull over and only been 5 miles away from my home. I called Kia today to start an Oil Consumption test, stated I am the 2nd owner and while this is a known issue I will pay for and Upper Engine Clean which is only a band aid. This problem has been confirmed with Kia that the GDI Engines are consuming oil. I have also replaced all Engine Coolant, Coolant Temperature Senor, Thermostat as well as the PCV Valve.

Filed Apr 5, 2025 · Engine · OH

I was driving on the highway, the check engine light started flashing and the car lost power. This created a very dangerous situation because I could not go the speed limit and could not get off the highway since I was in the middle lane. We went and had the check engine light checked and were told the code was P1326.

Filed Mar 26, 2025 · Engine · DE

I was driving on the highway and randomly my car started to shake very badly and i couldn’t go faster than about 30 mph. My engine light didn’t turn on until i turned the car off and back on after finally making it home after almost getting hit by cars trying to make it back home. I sent it to get looked at and they said that it’s misfiring pretty severely and that kia had a recall on an engine/motor awhile back for my car and to take it to a dealership. I contacted KIA customer care but the only recall I see when I look up my VIN # is for the trunk recall.

Filed Mar 17, 2025 · Engine · OH

1.) What component or system failed or malfunctioned? Engine failure due to excessive oil consumption and/or a malfunctioning Knock Sensor Detection System (KSDS). •The engine failed at only 50,000 miles due to internal issues. •The KSDS system triggered a flashing check engine light, but Kia refuses to cover the repair despite known past issues. •Kia engineers and the dealership confirmed the engine failure but are denying warranty coverage. ➡ The vehicle is currently at the dealership and available for inspection. 2.) How was your safety or the safety of others put at risk? •A flashing check engine light appeared, indicating possible catastrophic engine failure while driving. •Loss of engine function on the road could have led to an accident. •The KSDS system was designed to prevent this type of failure, but it failed to stop the damage in time. •If the engine had completely failed at highway speeds, it could have created a dangerous situation. 3.) Has the problem been reproduced or confirmed by a dealer or independent service center? ✅ Yes, the issue was confirmed by the Kia dealership. •The dealership confirmed that the engine has failed and needs to be replaced. •A tech line case was opened with Kia engineers, who confirmed the failure. •Kia refuses to cover the repair, claiming it is a "top-end failure" instead of a "rod bearing failure." 4️.) Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? ✅ Yes, it was inspected by the Kia dealership and Kia engineers. •A tech line case was created, and Kia engineers reviewed the issue. •Kia admitted that the engine failed but refused to cover the repair under warranty. 5.) Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? ✅ Yes, a flashing check engine light appeared due to the Knock Sensor Detection System (KSDS). •The same warning code had previously appeared while

Filed Feb 25, 2025 · Engine · IL

My Engine is burning a quart or more of oil a week. Since my last oil change I have put in 15 quarts of oil. I called KIA service department and they said there is nothing they can do unless my check engine light is on.

Filed Dec 5, 2024 · Engine · FL

The contact’s daughter owns a 2017 Kia Optima. While the contact’s daughter was driving at an undisclosed speed, there was a loud rattling sound coming from the front end of the vehicle. The check engine warning light illuminated. The contact stated that while attempting to start the vehicle, the vehicle failed to start on the first attempt. The vehicle started on the second attempt was able to be driven. The vehicle was taken to the dealer who determined that the engine rod had failed, causing complete engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact became aware that the vehicle was included in an undisclosed Product Improvement Program for a software update; however, the contact was unaware of the software update which voided the Extended Warranty for the engine repair. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was unknown.