2017 Kia Optima: engine knocking or ticking

Filed Aug 24, 2026 · Engine · TX

While driving at highway speed, my engine began to produce a loud knocking noise without prior warning. Within few seconds, the engine seized completely causing sudden loss of motive power.This caused a dangerous situation— loss of power steering and barking at highway speed, leaving me stranded in traffic lanes. I was forced to coast to the shoulder. The vehicle was towed to the nearest independent repair shop because it was not drivable and I was stranded far from home. The shop diagnosis —- seized engine due to big end connecting rod bearing seizure, identical to the federal safety agency Recall 17V‑224 and KIA recall SC 17/ SC165 and TSB P1803 related to Theta engine bearing wear and engine seizure.My vehicle has the 2.4 L engine covered by this recall/defect.The failure occurred exactly as described in the recall: knocking , the seizure. KIA has denied warranty coverage because the vehicle was initially diagnosed and repaired at independent shop after the roadside emergency.The shop was used only because the vehicle was immobilized on the freeway away from home. I did attempt to contact a dealership in FortWorth, Texas, Morits KIA, but they could not provide roadside assistance or a tow solution at that time. I am reporting because: 1) This is a sudden loss of power at highway speed, which is a major safety risk 2) This appears to be the same defect KIA has recalled for, but the vehicle was not remedied or remedy failed 3) KIA is refusing to honor the extended warranty for this known defect I request the federal safety agency document this failure as part of the ongoing monitoring of Theta II engine failures. Vehicle is available for inspection and defective engine have been preserved.

Filed May 26, 2026 · Engine · 98,000 miles · KY

The contact owns a 2017 Kia Optima. The contact stated that on three of four occasions while driving at approximately 50 MPH, the vehicle began rattling and shaking, and he observed a knocking noise emanating from the engine compartment. The check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the knock sensor needed to be replaced, and he was advised that his vehicle may have been included in Manufacturer Recall Number: SC162. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 98,000.

Filed Jan 16, 2026 · Engine · GA

The vehicle is consuming excessive amounts of oil. The dipstick was completely dry before 5000 miles were up. I had to add some oil to the engine to avoid engine failure. I have reported this to Jim Ellis dealership in Kennesaw GA but I was told to drive the vehicle until it knocks or the knock sensor goes.

Filed Dec 30, 2025 · Electrical, Engine · 98,000 miles · UT

The contact called on behalf of her daughter who owns a 2017 Kia Optima. The contact stated while driving at approximately 60 MPH, the vehicle made an abnormal knocking sound, the cruise control was inoperative, the infotainment screen darkened, and the charging outlet was inoperative. The Check Engine warning light was intermittently illuminated. The vehicle was taken to the contact's residence, and the contact used a vehicle scanner to scan the vehicle. The contact stated that DTC: P1326 for the Knock Sensor Detection System (KSDS) was found, which detected excessive engine vibration. A dealer was contacted; however, the vehicle was not diagnosed or repaired by the dealer. No further information was available. The failure mileage was approximately 98,000.

Filed Dec 9, 2025 · Engine, Transmission · IL

Vehicle experiences sudden and dangerous loss of power while driving, including hesitation during acceleration, consistent with connecting-rod bearing failure risk known in this model’s GDI engine. Dealer estimate found timing and oil-flow component failures connected to internal engine damage. Vehicle is unsafe to drive and stalls/lacks power unexpectedly, creating a high risk of crash.”

Filed Nov 16, 2025 · Engine, Fuel system · CA

I own a 2017 Kia Optima with a major internal engine defect. Starting shortly after purchase, the car lost power and consumed fuel unusually quickly. Over time, the engine began burning excessive oil and now produces a loud knocking sound (bearing knock), indicating internal bearing failure. These symptoms are consistent with known Kia engine defects (bearing wear / piston ring failure). The defect is a serious safety concern: because of weak bearings and high oil consumption, the engine could stall, seize, or catch fire. The dealership has refused to repair or replace the engine. I am reporting this as a safety defect and request the federal safety agency investigation.

Filed Oct 28, 2025 · Engine · 100,400 miles · CA

The contact owns a 2017 Kia Optima. The contact stated that upon routine maintenance with a local independent mechanic, it was discovered that the vehicle had low engine oil. No warning light was illuminated. The vehicle was taken to a local dealer, where it was determined that an oil consumption test was needed to determine any failure. The vehicle was not repaired. The check engine warning light was illuminated. The contact stated that engine oil was added almost every 2 weeks. The message to "Contact the Dealer" was displayed. The vehicle was towed to Team Kia of El Cajon (541 N Johnson Ave, El Cajon, CA 92020), where it was determined that there was engine oil leaking onto the catalytic converter. The contact related the failure to a Kia recall related to a connecting rod bearing failure. The manufacturer was made aware of the failure. The failure mileage was approximately 100,400.

Filed Oct 15, 2025 · Engine, Fuel system · CA

I purchased the 2017 Optima Hybrid from Huntington Beach Hyundai on [XXX]. I made sure to double check with the dealer if the engine and hybrid battery were in good condition, in which the salesman reassured me everything is good. The car was driving okay for a while, and I had oil change and tires/alignment changed recently. Just barely 4 months in after I owned the car, the incident happened on the night of [XXX]. I was driving on the highway near the Getty going roughly 70 mph up the mountain roads while all of a sudden the "check hybrid system" warning came on in the car. The car immediately went into limp mode, and I did everything I could to slow the car to a complete stop, and stop on the freeway shoulder safely. It was a traumatizing experience to me, as this is a major safety issue with the vehicle, and other cars were travelling really fast in LA mountain areas. I had the car towed to a auto repair shop the next day, the mechanics did a deep inspection and informed me the hybrid inverter has failed. I paid $2,177 to replace the hybrid inverter with the mechanic. The mechanic also informed me while they were test driving they heard a knocking sound from the engine. I did a look up and found out there is a class settlement and safety campaigns on the engine for 2017 Optima Hybrid due to the faulty factory rod bearings, and the 150K miles extended warranty from Kia should apply to replace my faulty engine free of charge. I will be getting my car towed to Car Pros Kia in Huntington Beach on October 15th, 2025, and request the dealer to replace my engine per Kia's extended warranty. I am filing the complaint because the car is having problems after problems in barely 4 months of ownership, in which I believe I have purchased a lemon, or Huntington Beach Hyundai knowingly hid the facts the components were faulty. I have also filed a case with Kia corporate. Attached is the repair invoice for the hybrid inverter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

Filed Sep 3, 2025 · Engine · DC

for the past year, I have been constantly replacing the spark plugs and ignition coil in my 2017 Kia optima. Recently I have had the valve cover gasket replaced. It is a constant oil consumption issue. I have received the P1326 diagnostic code. My dealership told me that the engine cannot be replaced unless it’s knocking. This is my only mode of transportation, and I would hate for me to be stranded because I’m waiting for the engine to knock for my engine to be replaced.

Filed Aug 21, 2025 · Engine · GA

Car began hesitating and stalling, particularly from a stop. Engine light came on. Took the car to the KIA dealership for diagnosis. Was told by svc coordinator that the diagnosis indicated a bad knock sensor. The technician replaced the knock sensor, then test drove the car. It failed immediately. I was told that it would likely need engine replacement. After a few days, svc coordinator called and said that KIA recommended replacing the knock sensor (again) and perform a tuneup. They declined to replace the engine. The car runs in "limp home mode" (Kia's terminology), hesitates and stalls so as to make it very unsafe to operate. The engine on this car was replaced about two years ago for excessive oil consumption. There cannot be more than 30k miles on the new engine. KIA stated that there is a lifetime warranty on the replaced engines, but are apparently not going to honor the warranty. Car is serviced regularly and is in otherwise excellent condition.

Filed Aug 4, 2025 · Engine · AR

--- **Summary of Complaint – 2017 Kia Optima** My 2017 Kia Optima (VIN: [XXX] ) experienced sudden engine failure due to a damaged piston. There were no warning signs—no knock codes or dashboard alerts—prior to the malfunction. Despite regular maintenance and timely oil changes, Kia denied warranty coverage, leaving me with significant repair costs. This issue appears consistent with reported engine problems in similar Kia models and could represent a broader manufacturing defect. I'm submitting this report in hopes of prompting an investigation into a potential safety hazard. A recall may be necessary to prevent similar failures and protect INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 27, 2025 · Engine · OH

Code P1326, Faulty Knock sensor on 2.4GDI