2019 Kia Optima: engine knocking or ticking

Filed Nov 3, 2026 · Acceleration, Engine · MI

I have a 2019 Kia Optima S with the 2.4L engine and 117,000 miles. The vehicle has diagnostic codes P1326 and POOOB. The check-engine light is continuously flashing, the engine is knocking, and the vehicle has lost acceleration and will not go over approximately 65 mph. I believe this may be related to the KSDS connecting-rod bearing issue under Kia campaign PI1805.

Filed Oct 8, 2026 · Engine · FL

Vehicle shut off while driving at 40mph, engine seized ,will not crank .suspected conecting rod bearing failure under safety recall sc200, I call kia 18003334542 denied recall repair and bearing clearance test stating vehicle is rebuilt title. Federal safety recall cannot be denied due to rebuilt title per the federal safety agency .requesting recall remedy.

Filed Sep 29, 2026 · Engine · AR

The vehicle experienced a sudden and severe loss of engine power while being driven on the interstate at highway speeds. The vehicle lost the ability to accelerate normally beyond approximately 60 mph, the Check Engine Light began flashing rapidly, and the vehicle entered “Limp Home Mode.” This sudden loss of power occurred in heavy traffic and created an immediate risk of a high-speed rear-end collision. The vehicle was subsequently inspected by an authorized Kia dealership service center. Diagnostic testing confirmed DTC P1326 (Knock Sensor Detection System). The dealership performed the manufacturer’s Bearing Clearance Test (BCT), and the dealership paperwork documents a “NO PASS BCT” result. The dealership paperwork also documents that Service Campaign SC340 (Theta II 2.4L GDI ECM Software Upgrade) was performed on the vehicle. Despite the documented P1326 condition and the manufacturer’s “NO PASS BCT” result, the dealership is refusing to provide the engine replacement as a covered repair and has instead quoted approximately $9,000 for the engine replacement. I am requesting that the federal safety agency review this matter because the vehicle experienced a sudden loss of power at highway speeds, followed by a documented “NO PASS BCT” result from the manufacturer’s diagnostic procedure. The vehicle remains an unresolved safety concern. I am also requesting review of whether Kia is properly applying the applicable P1326/BCT engine-replacement procedure and associated coverage to this vehicle. The vehicle and all diagnostic and service paperwork are available for inspection upon request.

Filed Jan 29, 2026 · Engine, Transmission · CA

The vehicle experienced a sudden engine failure one day after undergoing a manufacturer emissions/service campaign at an authorized dealership. Prior to service, the vehicle operated normally with no warning lights, knocking, or drivability issues. After the failure, the dealership denied coverage and declined to inspect the engine oil. The vehicle was towed for an independent inspection, which found metal shavings in the engine oil, indicating internal mechanical engine failure. The sudden failure created a safety risk due to unexpected loss of engine function. The issue has been confirmed by an independent service center and the vehicle remains available for inspection. No warning lamps or symptoms were present prior to the failure.

Filed Dec 9, 2025 · Engine, Transmission · TN

Unknown needing help with new purchased car. Bought this car October/2025 with 93k on engine. Already been to dealership i Bought it from to have current issues im dealing with checked out and they only listen to it and said it was injector ticking clatter. Since then ive seen white smoke and the car burning excessive oil. I am adding oil to the car every 2-3 days. Still noticeable smoke and smell of burning oil. No recall on this vin. It seems as if this is a huge problem with this engine. Please help

Filed Aug 27, 2025 · Electrical, Engine · TX

I was just driving then noticed lack of acceleration and the engine light flashing. Loosing acceleration mid driving posed a great safety risk because no other drivers would know the issue I was experiencing and risked causing an accident. The vehicle was taken for a fault code reading which indicated a knock sensor code, later it was inspected at the dealership who confirmed an ECU issue. The police or insurance have not inspected the vehicle for this particular issue.

Filed Mar 26, 2025 · Engine · GA

My 2019 Kia Optima purchased brand new. Kia released a service bulletin on 3/1/22 citing “excessive oil consumption for 2011-2021 Optima's”. I took it in for the "updates" for said service bulletin for the engine and was told that my engine is good and covered now for the life of the engine even past the 100k miles (mind you no one mentioned doing an excessive oil consumption test at this time). On 3/22/24 car had 104k miles on it and the oil light came on. I had an oil change just 2500 miles or so prior. Pulled into an autozone and it was almost bone dry. I put oil in it and the light went off. I took it to Evans Kia and was told that they couldn't do anything because it was past 100k warranty and that they couldn't run the DX test to determine if it was excessively consuming oil as per the recall. Apparently during the recall they did the DX tests if the consumer stated it was burning oil fast or something to that extent. Mine did not get said test, only the upgrade. They should have done the test, but they just did an "upgrade" which clearly did not work. They said since I had the "upgrade", if the engine fails, then Kia would fix it under warranty. Since then, this happened at least 4 more times with the oil light coming on and engine oil practically gone. Each time took less and less miles. I showed up to Kia 2 of those times in 2024 to show them the the oil change date, mileage, and check oil light on. Also physically showed them the oil being almost empty, yet they did nothing but say when the engine dies or "knocks" they can fix it under warranty. One of those times I had it towed but they determined it was the fuel pump, never mentioned anything else. Fast forward 3/15/25 the engine starts knocking and engine light comes on. I managed to drive it to Evans Kia without any accidents. After my car sat for 9 days, they call me on 3/25/25 and tell me there is a "burnt valve on cylinder 4 and the engine will need to be replaced and it is not covered. How? Help!

Filed Nov 9, 2024 · Engine · SC

Engine is consuming too much oil engine is shaking and knocking engine light is on reducing speed will cut off in mid drive

Filed Nov 8, 2024 · Engine · 92,000 miles · MI

The contact owns a 2019 Kia Optima. The contact stated while driving at undisclosed speeds, the check engine warning light was flashing, and the vehicle went into LIMP Mode. The vehicle was towed to the local dealer, where it was diagnosed and determined that an unknown sensor needed to be replaced. The vehicle was repaired, but the failure recurred. While driving 65 MPH, the driver came to a stop, and upon accelerating, the check engine warning light started flashing. The vehicle was consuming an excessive amount of engine oil. The contact used a code reader and determined the failure was with the knock sensor. The vehicle was taken back to the local dealer, who determined that the knock sensor needed to be replaced. The dealer informed the contact that there was no warranty coverage on the vehicle for the failure. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 92,000.

Filed Oct 29, 2024 · Electrical, Engine · 18,000 miles · FL

The contact owns a 2019 Kia Optima. The contact stated while driving approximately 65 MPH, the vehicle made an abnormal knocking sound and started vibrating and shuddering. The contact stated that the vehicle started to lose motive power and failed to respond upon depressing the accelerator pedal. The vehicle stalled and failed to restart. The contact stated that the check engine warning light illuminated while attempting to restart the vehicle. Additionally, the contact stated that the vehicle had previously experienced engine failures and electrical fuse failures. The contact stated that the 12-volt battery was previously replaced three times. The contact had taken the vehicle to two local dealers. The second dealer referred the contact to the manufacturer for assistance. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.

Filed Aug 14, 2024 · Acceleration, Engine · TX

This vehicle is a lemon. It is a 2019 with 81,000 miles. How in the world does the engine start knocking when i have consistently, kept up with the maintenance on this vehicle. If i do not hear something soon im weakening legal action. Since May 18TH i have been without a car.i am a single mom and this is so difficult. Mind you it was towed July 5th from where it broke down on me.

Filed May 15, 2024 · Engine, Fuel system · MD

I am writing to bring to your attention a critical safety issue with my 2019 Kia Optima SX 2.0 GDI Turbo, which has accumulated approximately 103,000 miles. This vehicle has recently developed several serious problems that I believe pose significant risks to both my safety and the safety of other road users. Firstly, my Kia Optima has been burning an excessive amount of oil. Specifically, it consumes over 5 quarts of oil within just 2,000 miles of driving. Despite thorough inspections, even from Kia Dealers there are no visible oil leaks, making this issue even more perplexing and concerning. Moreover, the vehicle has begun to shake violently while driving on the highway, which has led to a substantial loss of power in the middle of traffic. This unpredictable loss of power is extremely dangerous, especially at high speeds, as it compromises my ability to maintain control of the vehicle and poses a significant hazard to other motorists. Additionally, the car now emits a loud knocking noise, which appears to be related to the engine's internal components. This issue further exacerbates the vehicle's performance problems and raises serious questions about its reliability and safety. I urge the federal safety agency to investigate these issues promptly. The problems I am experiencing are not isolated and may affect other Kia Optima owners, potentially leading to widespread safety risks. I believe it is crucial to determine if there is a manufacturing defect or other underlying cause that needs to be addressed to prevent accidents and ensure the safety of all Kia Optima drivers. Thank you for your attention to this matter. I am hopeful that the federal safety agency will take immediate action to investigate these serious safety concerns and provide a resolution to protect both myself and others.