I have a 2019 Kia Optima S with the 2.4L engine and 117,000 miles. The vehicle has diagnostic codes P1326 and POOOB. The check-engine light is continuously flashing, the engine is knocking, and the vehicle has lost acceleration and will not go over approximately 65 mph. I believe this may be related to the KSDS connecting-rod bearing issue under Kia campaign PI1805.
2019 Kia Optima engine problems
95 complaints (44% of all complaints for this car). Typical mileage when it fails: 70,000.
- owner complaints
- 95
- of this car's complaints
- 44%
- typical mileage
- 70,000
- crashes
- 0
- recalls
- 0
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Kia Optima engine problems in other years
Specific symptoms reported on the 2019 Kia Optima engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Oil consumption 34Check engine light 31Engine failure 22Knocking 18Stalling 17Loss of power 10Misfire 6
Related recalls
No recalls on record for this model year.
Related investigations
Loss of Motive Power
the federal safety agency received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitionersâ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODIâs evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to the federal safety agency which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. Â There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in the federal safety agency's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, the federal safety agency does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing the federal safety agencyâs reasons for denial of the petition will be published. The reference numbers for the complaints to the federal safety agency cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to
DP22003
What 2019 Kia Optima owners say
Most recent owner complaints, unedited.
Car smelled of what seemed like motor oil while driving. Parked, saw white smoke, and confirmed an engine fire. I was clearly in life threatening danger, especially with a full tank of gas. Fire developed rapidly into a roaring blaze. Entire front of car melted. Car is currently being investigated by manufacturer and cause is unknown. No warning lamps illuminated.
Vehicle shut off while driving at 40mph, engine seized ,will not crank .suspected conecting rod bearing failure under safety recall sc200, I call kia 18003334542 denied recall repair and bearing clearance test stating vehicle is rebuilt title. Federal safety recall cannot be denied due to rebuilt title per the federal safety agency .requesting recall remedy.
The vehicle experienced a sudden and severe loss of engine power while being driven on the interstate at highway speeds. The vehicle lost the ability to accelerate normally beyond approximately 60 mph, the Check Engine Light began flashing rapidly, and the vehicle entered “Limp Home Mode.” This sudden loss of power occurred in heavy traffic and created an immediate risk of a high-speed rear-end collision. The vehicle was subsequently inspected by an authorized Kia dealership service center. Diagnostic testing confirmed DTC P1326 (Knock Sensor Detection System). The dealership performed the manufacturer’s Bearing Clearance Test (BCT), and the dealership paperwork documents a “NO PASS BCT” result. The dealership paperwork also documents that Service Campaign SC340 (Theta II 2.4L GDI ECM Software Upgrade) was performed on the vehicle. Despite the documented P1326 condition and the manufacturer’s “NO PASS BCT” result, the dealership is refusing to provide the engine replacement as a covered repair and has instead quoted approximately $9,000 for the engine replacement. I am requesting that the federal safety agency review this matter because the vehicle experienced a sudden loss of power at highway speeds, followed by a documented “NO PASS BCT” result from the manufacturer’s diagnostic procedure. The vehicle remains an unresolved safety concern. I am also requesting review of whether Kia is properly applying the applicable P1326/BCT engine-replacement procedure and associated coverage to this vehicle. The vehicle and all diagnostic and service paperwork are available for inspection upon request.
On December 26, 2023, this vehicle received a complete engine assembly replacement at an authorized dealership under a manufacturer warranty repair order. Following the engine overhaul, the vehicle developed a severe, raw gasoline smell entering the passenger cabin through the climate control AC vents while sitting at an idle.The vehicle was brought back to Kia Store East on September 10, 2026, specifically to report this volatile safety issue. On September 17, 2026, the dealership technician explicitly duplicated and confirmed the raw fuel odor coming from the engine area in writing. Despite confirming the gasoline smell, the dealership is refusing to perform a manual high-pressure fuel system pressure-drop test to isolate the physical vapor leak. Instead, they have listed a high-pressure Fuel Pipe Assembly (Part # 35305 2GGA0) on a customer-pay estimate paired with an unrelated $1,819.12 timing cover oil seal repair.The dealership is claiming the failure is out of warranty and is holding the vehicle while forcing daily rental car fees onto me, refusing to isolate the active fuel leak unless I authorize the out-of-pocket repair. The vehicle currently sits un-repaired at the dealership as an active cabin fire and occupant chemical exposure hazard that the manufacturer and dealer refuse to properly diagnose or cover under repair workmanship guidelines.
While driving, my vehicle suddenly began shuddering and shaking. The vehicle lost power and would not accelerate properly. I had to press the brake pedal unusually hard. After parking, the vehicle would not move properly in reverse or drive. I turned the vehicle off and restarted it, and it moved only a short distance before shuddering again and losing power. The engine was making a loud buzzing or scooter-like sound. The vehicle became undrivable and had to be parked. I am concerned about a potential safety defect involving sudden loss of power while driving.
The contact owns a 2019 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The vehicle was towed to a dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 200,000.
The contact owns a 2019 Kia Optima. The contact stated that while driving at various speeds on two occasions, the vehicle lost power with the check engine warning light illuminated. The vehicle was driven over to the side of the road and then towed to the dealer twice; however, the failure was not duplicated on the first visit. During the second visit, the vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 146,000.
Oil is needing added on a weekly basis to keep up with how much the engine is burning, Spark Plugs and Coils have been changed excessively, the dealership says we may end up being covered by a recall but the engine needs to completely fail first.
Engine failure, metal leaking into oil which caused engine to fail
Questions about the 2019 Kia Optima engine
Does the 2019 Kia Optima have engine problems?
Owners have filed 95 complaints about the engine of the 2019 Kia Optima, 44% of all its complaints, more than any other problem.
At what mileage do 2019 Kia Optima engine problems start?
The typical (median) mileage in owner complaints is 70,000 miles.
Is there a recall for the 2019 Kia Optima engine?
There is no recall for this problem on this model year.
Other 2019 Kia Optima problems
Driver assistance 40Electrical 23Brakes 19Fuel system 18Transmission 18Body 14Airbags 12Acceleration 11Steering 6Visibility 3Wheels 3Lights 2Locks 2Seat belts 2Tires 2Suspension 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Kia Optima?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history