2019 Kia Optima: check engine light

Filed Nov 3, 2026 · Acceleration, Engine · MI

I have a 2019 Kia Optima S with the 2.4L engine and 117,000 miles. The vehicle has diagnostic codes P1326 and POOOB. The check-engine light is continuously flashing, the engine is knocking, and the vehicle has lost acceleration and will not go over approximately 65 mph. I believe this may be related to the KSDS connecting-rod bearing issue under Kia campaign PI1805.

Filed Sep 29, 2026 · Engine · AR

The vehicle experienced a sudden and severe loss of engine power while being driven on the interstate at highway speeds. The vehicle lost the ability to accelerate normally beyond approximately 60 mph, the Check Engine Light began flashing rapidly, and the vehicle entered “Limp Home Mode.” This sudden loss of power occurred in heavy traffic and created an immediate risk of a high-speed rear-end collision. The vehicle was subsequently inspected by an authorized Kia dealership service center. Diagnostic testing confirmed DTC P1326 (Knock Sensor Detection System). The dealership performed the manufacturer’s Bearing Clearance Test (BCT), and the dealership paperwork documents a “NO PASS BCT” result. The dealership paperwork also documents that Service Campaign SC340 (Theta II 2.4L GDI ECM Software Upgrade) was performed on the vehicle. Despite the documented P1326 condition and the manufacturer’s “NO PASS BCT” result, the dealership is refusing to provide the engine replacement as a covered repair and has instead quoted approximately $9,000 for the engine replacement. I am requesting that the federal safety agency review this matter because the vehicle experienced a sudden loss of power at highway speeds, followed by a documented “NO PASS BCT” result from the manufacturer’s diagnostic procedure. The vehicle remains an unresolved safety concern. I am also requesting review of whether Kia is properly applying the applicable P1326/BCT engine-replacement procedure and associated coverage to this vehicle. The vehicle and all diagnostic and service paperwork are available for inspection upon request.

Filed Jul 21, 2026 · Engine · 146,000 miles · FL

The contact owns a 2019 Kia Optima. The contact stated that while driving at various speeds on two occasions, the vehicle lost power with the check engine warning light illuminated. The vehicle was driven over to the side of the road and then towed to the dealer twice; however, the failure was not duplicated on the first visit. During the second visit, the vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 146,000.

Filed Jan 20, 2026 · Engine · 112,000 miles · CA

The contact owns a 2019 Kia Optima. The contact stated that while the vehicle was parked, there was sputtering sound coming from the engine compartment, with the check engine warning light illuminated. The contact stated that while driving at an undisclosed speed, the vehicle was running rough. The vehicle was taken to the independent mechanic where it was diagnosed with a cylinder misfire and burned spark plug, and that there was oil inside the cylinder and on the spark plug. The contact was informed that the parts needed to be replaced. The vehicle was repaired but the failure reoccurred months later. The vehicle was taken back to the same independent mechanic where it was diagnosed with oil consumption, oil intrusion into the firing chamber, and that another spark plug needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 112,000.

Filed Dec 11, 2025 · Engine · 179,000 miles · TX

The contact owns a 2019 Kia Optima. The contact stated that the catalytic converter was previously replaced. The contact stated that while driving at 60 MPH, two weeks later, the check engine warning light illuminated, and the vehicle started misfiring. The contact drove to the residence. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the engine needed to be replaced. The mechanic related the failure to an unknown engine recall, and the contact was referred to the dealer for assistance. The vehicle was taken to the nearby dealer, where it was diagnosed with engine damage. The dealer acknowledged the unknown engine recall, but the engine was not replaced. The manufacturer was notified of the failure and informed the contact that the part of the engine that was damaged was not covered. The vehicle was not repaired. The failure mileage was approximately 179,000.

Filed Dec 4, 2025 · Fuel system · OH · fire

After routine maintenance replacing the valve cover gasket, the low pressure GDI fuel line developed a leak in an area away from where the maintenance had occurred. After a 10 minute drive, the car developed a fire in the engine compartment. Upon investigation by an independent auto mechanic, it was determined that the fuel line had become brittle and developed a crack that had sprayed fuel into the hot surfaces of the engine compartment. This appears similar to the scenario affecting earlier Kia Optima models with the 2.0L Turbo engines. The heat from the fire caused the brakes to start to fail and the amber check engine light to come on within about 5 seconds before smoke was observed coming from the engine compartment. Fortunately, the fire occurred as the vehicle was pulling into the owner's driveway and a fire extinguisher was nearby and used to put out the fire. The vehicle's occupants were able to exit the vehicle with no injuries.

Filed Nov 19, 2025 · Engine · MD

Red oil light came on along with check engine light took to shop got oil change and they test pressure all is good but oil light and engine light still on replaced oil pressure sensor switch and variable valve solenoid lights still on took to kia dealership they said say thing as first shop replaced oil pressure sensor switch again because they said the aftermarket one doesn't work on my car so bought part from dealer changed it light still on.

Filed Sep 5, 2025 · Engine · KY

Over the past couple years, the check engine light has came on and I immediately had a mechanic look at it. The first time they said it was my spark plugs and changed them. Then this year, a year later, the check engine light came on and it became hard to accelerate on my way to a mechanic. Once again, they said spark plugs, so they changed them and claimed that they didn't look to had been changed before. Now here I am a couple of months after that, my check engine light came back on and my car started making a funny noise on my way to work. I turned back around and went home since I was closer to home than work. It sounds like rocks popping when you start it or hit the gas. I had someone check the codes and it said engine 1 and 4 coils. All 4 coils and spark plugs were changed again. That did not fix it. The sound is still there and the engine light is now blinking. I have kept up with the oil changes and everything. There is no recall. I still owe on the car and it is not able to be driven.

Filed Aug 27, 2025 · Electrical, Engine · TX

I was just driving then noticed lack of acceleration and the engine light flashing. Loosing acceleration mid driving posed a great safety risk because no other drivers would know the issue I was experiencing and risked causing an accident. The vehicle was taken for a fault code reading which indicated a knock sensor code, later it was inspected at the dealership who confirmed an ECU issue. The police or insurance have not inspected the vehicle for this particular issue.

Filed Jun 27, 2025 · Engine, Transmission · IN

•Rapid oil loss — topped off every 1–2 weeks •Engine misfires, check engine light •Spark plug fouling and performance loss •Repeated advice to “just refill oil” and “wait for failure” •Unsafe to drive, especially as a working single mom

Filed Jun 15, 2025 · Engine · FL

The engine appears to be consuming an abnormal amount of oil. There are no visible leaks or external damage, and the vehicle has not yet stalled or failed, but oil levels drop rapidly between oil changes. The engine is available for inspection upon request Driving with low or empty oil levels risks sudden engine failure while in motion, which could lead to loss of power, stalling in traffic, or even a crash. The oil warning light came on and went off at regular intervals unexpectedly during driving this week, which prompted me to get it to my mechanic asap to avoid potential engine damage or failure. They performed an oil change (even though I had done it there for this same car only 2133 miles ago NOT YET. I have contacted the dealership and have been advised to monitor the oil level or potentially conduct an oil consumption test. I have not yet received a formal diagnostic or confirmation from Kia or a third party. Yes the vehicle was formally inspected by Gettel Kia of Bradenton on 14th Street for an engine stalling issue... Have experienced a stall only once since then Yes. The oil warning light turned on (and off several times in 1 minute intervals) for the first time around 132011 miles. Upon the mechanic checking the dipstick, the oil level was significantly below minimum. No check engine light appeared. An oil change was performed only 2133 miles since the last one. Additional Notes: I have discovered multiple similar reports from other 2016–2020 Kia Optima owners via online forums such as Reddit and Kia owner groups, suggesting this may be a widespread issue related to the GDI engine design. These cases often go unresolved until engine damage occurs. I am requesting: A formal oil consumption test A full engine inspection Repair or replacement if the issue is confirmed Consideration for goodwill or warranty extension due to potential manufacturing defect I am maintaining oil top-off records and would be happy to provide them

Filed May 10, 2025 · Engine · IN

I was driving in the rain on the highway and engine light started flashing!