Vehicle shut off while driving at 40mph, engine seized ,will not crank .suspected conecting rod bearing failure under safety recall sc200, I call kia 18003334542 denied recall repair and bearing clearance test stating vehicle is rebuilt title. Federal safety recall cannot be denied due to rebuilt title per the federal safety agency .requesting recall remedy.
2019 Kia Optima: engine stalls while driving
17 of the 214 complaints about the 2019 Kia Optima describe engine stalls while driving.
- owner complaints
- 17
- of this car's complaints
- 8%
- recalls
- 0
Is there a fix? 47 service bulletins cover this area of the car. See below
Engine stalls while driving by model year
What owners say
The contact owns a 2019 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The vehicle was towed to a dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 200,000.
The engine of vehicle repeatedly failed, causing the vehicle to stall while driving, which posed a serious risk to my safety and others on the road. The vehicle had approximately 65,000 miles and was maintained routinely and on schedule. The failure first occurred before November 18, 2025, when I reported stalling issues to Kia authorized service & parts. The vehicle was returned as “fixed” on December 12, 2025, but the engine stalled again during normal operation. The vehicle was returned to Kia authorized service & parts multiple times (December 12, December 18, December 23, January 9, January 12, 2026, and March 4, 2026), with repeated assurances that it had been repaired. Each time, the car continued to stall, including during a test drive at Subaru, demonstrating that the failure persisted despite repeated dealer intervention. The stalling created a significant hazard, as the car could lose power while on public roads, including highways, potentially leading to accidents. There were no consistent warning lights or messages prior to the engine stalling; the first symptom was intermittent loss of power while driving. The failure has been reproduced and observed by multiple service personnel at Kia authorized service & parts and by Subaru during the trade-in test drive. The component(s) causing the failure were inspected by Kia authorized service & parts staff, but no effective repair was made. Documentation of repair orders and dealer inspections is available for review.
I purchased this vehicle on [XXX], with approximately 170,150 miles. On [XXX], during a routine oil change at approximately 172,636 miles, it was discovered that the engine had no oil present. Shortly afterward, the oil warning light began flickering intermittently while driving. On November 4, 2025, at approximately 175,495 miles, a certified mechanic again confirmed that there was no oil present in the engine. At no point were there visible external oil leaks, indicating excessive internal oil consumption. This condition creates a serious safety risk, as sudden engine failure while driving could lead to loss of power, stalling, or accidents. Based on my experience and publicly known issues involving Kia engines, this appears to be a systemic defect rather than normal wear. I am requesting that the federal safety agency document and review this issue as a potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My vehicle is consuming oil excessively. I have to put a whole quart of oil in my vehicle every 2 weeks. I am adamant about getting regular maintenance oil changes as well. My car had to be towed to a local auto shop due to the engine stalling and accelerator not working. They had to replace all 4 coil packs and 4 spark plugs due to dark, tarry oil covering the parts. The repairman told me my engine was at risk of failing, and that the repairs he did would not last without a new engine. I am worried about the car stalling or failing while driving, which puts an accident occurring at greater risk. My complaints resemble symptoms tied to previous Hyundai/Kia engine recalls. I am requesting investigation and manufacturer action related to this issue.
2019 Kia Optima EX - 59,000 miles - car miss fires and shakes on start. After a few seconds the car calms down and I can drive. Very dangerous since the fuel can stop flowing and the car can stall at any speed. Very dangerous!! Looks like several Kia's from 2019-2023 have been recalled for the same issue - High Pressure Fuel Pump - if my car is having the same issue at 59,000 miles why is this car not recalled, Very Dangerous! The Kia K5 which took over for the Optima is on the list why not the Optima EX.
The engine appears to be consuming an abnormal amount of oil. There are no visible leaks or external damage, and the vehicle has not yet stalled or failed, but oil levels drop rapidly between oil changes. The engine is available for inspection upon request Driving with low or empty oil levels risks sudden engine failure while in motion, which could lead to loss of power, stalling in traffic, or even a crash. The oil warning light came on and went off at regular intervals unexpectedly during driving this week, which prompted me to get it to my mechanic asap to avoid potential engine damage or failure. They performed an oil change (even though I had done it there for this same car only 2133 miles ago NOT YET. I have contacted the dealership and have been advised to monitor the oil level or potentially conduct an oil consumption test. I have not yet received a formal diagnostic or confirmation from Kia or a third party. Yes the vehicle was formally inspected by Gettel Kia of Bradenton on 14th Street for an engine stalling issue... Have experienced a stall only once since then Yes. The oil warning light turned on (and off several times in 1 minute intervals) for the first time around 132011 miles. Upon the mechanic checking the dipstick, the oil level was significantly below minimum. No check engine light appeared. An oil change was performed only 2133 miles since the last one. Additional Notes: I have discovered multiple similar reports from other 2016–2020 Kia Optima owners via online forums such as Reddit and Kia owner groups, suggesting this may be a widespread issue related to the GDI engine design. These cases often go unresolved until engine damage occurs. I am requesting: A formal oil consumption test A full engine inspection Repair or replacement if the issue is confirmed Consideration for goodwill or warranty extension due to potential manufacturing defect I am maintaining oil top-off records and would be happy to provide them
I purchased this car off the show room floor in 2019 with only 10 miles on it. At some point in 2022 my car was slow to accelerate. I received the recall letter September 16,2022. no appointments until 08/09/2023. It didn't help .It was still stalling two weeks after. I have talked to the manager numerous occasions. He said it sounds like the transmission. The parts manager told me he will keep it overnight so his mechanics can drive it the following morning. That didn't happen. This car is a safety hazard. I can't pull out in front of anyone due to the car stalling. My family like to have lost our lives this weekend 05/31/2025 due to the car failing to accelerate(stalling). I have filed complaints with KIA head quarters twice. They keep telling me that if there's no warning lights on they can't identify the problem. On 01/06/2025, the manager and parts manager agreed to keep my car for a couple of days. I paid for my oil change/tire rotation and they sent me on my way. the bottom line is this car will be the death of me. God forbid!!
The contact owns a 2019 Kia Optima. The contact stated while driving approximately 65 MPH, the vehicle made an abnormal knocking sound and started vibrating and shuddering. The contact stated that the vehicle started to lose motive power and failed to respond upon depressing the accelerator pedal. The vehicle stalled and failed to restart. The contact stated that the check engine warning light illuminated while attempting to restart the vehicle. Additionally, the contact stated that the vehicle had previously experienced engine failures and electrical fuse failures. The contact stated that the 12-volt battery was previously replaced three times. The contact had taken the vehicle to two local dealers. The second dealer referred the contact to the manufacturer for assistance. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.
The contact owns a 2019 Kia Optima. The contact stated that while driving at various speeds, the vehicle lost motive power and stalled. During the failure, a flashing check engine warning light was illuminated. The vehicle was towed to the local dealer who determined that the engine had experienced excessive oil consumption. The cause of the failure was not yet determined, and the vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 30,449.
The car is using oil like crazy and is not leaking anywhere out of the vehicle. Stalling out while driving and then accelerating. Has completely lost power and rolled down an onramp. Completely unsafe. Took for diagnostic and they wanted to say I needed a new gas cap. Replaced, still doing same thing. Hesitant to start even and the alternator is less than a year old.
2019 Optima EX excessive oil consumption. Oil changed every 3000 miles, but is always empty within 1000miles. Car has 101,000 miles. Took to Kia dealership due to loss of power on acceleration and stalling and excessive oil consumption, they said I have multiple misfires on cylinder 1, excessive sludge buildup under cap and again no oil present. I was advised the engine needed replaced and that somehow this is a me problem and not a Kia problem. Spoke with Kia support and because it’s 1,000 miles over warranty they will not do anything even though they are aware of excessive oil consumption issue in these motors
Service bulletins that may apply
- Voluntary emissions service campaign: owner notification (SC367)
- SC367_POC: proof of correction card
- Voluntary emissions service campaign
- Voluntary emissions service campaign: question and answer (SC367) –
- Voluntary emissions service campaign: theta II 2.4L GDI emissions: ECM logic improvement (SC340 revision 5)
- Voluntary emissions service campaign: theta II 2.4L GDI emission secm logic improvement (SC340 rev 4)
- Voluntary emissions service campaign: owner notification (SC340 flight 103 / jf)
- Voluntary emissions service campaign: theta II 2.4L GDI emissions ECM logic improvement (SC340)
Related recalls
No recalls on record for this model year.
Questions about the 2019 Kia Optima stalling
Is engine stalls while driving a common problem on the 2019 Kia Optima?
17 of 214 owner complaints about the 2019 Kia Optima (8%) mention engine stalls while driving. The model year with the most reports is 2013.
Is there a recall or service bulletin for this on the 2019 Kia Optima?
There are 0 recalls and 47 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2019 Kia Optima
Oil consumption 34Check engine light 31Engine failure 22Knocking 18Collision warning 15Loss of power 10ABS 7Fire or smoke 7Fuel pump 7No deployment 6Misfire 6Hesitation 5Won't shift 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Kia Optima?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history