2019 Kia Optima: sudden loss of power

Filed Sep 29, 2026 · Engine · AR

The vehicle experienced a sudden and severe loss of engine power while being driven on the interstate at highway speeds. The vehicle lost the ability to accelerate normally beyond approximately 60 mph, the Check Engine Light began flashing rapidly, and the vehicle entered “Limp Home Mode.” This sudden loss of power occurred in heavy traffic and created an immediate risk of a high-speed rear-end collision. The vehicle was subsequently inspected by an authorized Kia dealership service center. Diagnostic testing confirmed DTC P1326 (Knock Sensor Detection System). The dealership performed the manufacturer’s Bearing Clearance Test (BCT), and the dealership paperwork documents a “NO PASS BCT” result. The dealership paperwork also documents that Service Campaign SC340 (Theta II 2.4L GDI ECM Software Upgrade) was performed on the vehicle. Despite the documented P1326 condition and the manufacturer’s “NO PASS BCT” result, the dealership is refusing to provide the engine replacement as a covered repair and has instead quoted approximately $9,000 for the engine replacement. I am requesting that the federal safety agency review this matter because the vehicle experienced a sudden loss of power at highway speeds, followed by a documented “NO PASS BCT” result from the manufacturer’s diagnostic procedure. The vehicle remains an unresolved safety concern. I am also requesting review of whether Kia is properly applying the applicable P1326/BCT engine-replacement procedure and associated coverage to this vehicle. The vehicle and all diagnostic and service paperwork are available for inspection upon request.

Filed Sep 8, 2026 · Electrical, Engine · FL

While driving, my vehicle suddenly began shuddering and shaking. The vehicle lost power and would not accelerate properly. I had to press the brake pedal unusually hard. After parking, the vehicle would not move properly in reverse or drive. I turned the vehicle off and restarted it, and it moved only a short distance before shuddering again and losing power. The engine was making a loud buzzing or scooter-like sound. The vehicle became undrivable and had to be parked. I am concerned about a potential safety defect involving sudden loss of power while driving.

Filed Jul 21, 2026 · Engine · 146,000 miles · FL

The contact owns a 2019 Kia Optima. The contact stated that while driving at various speeds on two occasions, the vehicle lost power with the check engine warning light illuminated. The vehicle was driven over to the side of the road and then towed to the dealer twice; however, the failure was not duplicated on the first visit. During the second visit, the vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 146,000.

Filed Mar 30, 2026 · Electrical, Engine · CA

The engine of vehicle repeatedly failed, causing the vehicle to stall while driving, which posed a serious risk to my safety and others on the road. The vehicle had approximately 65,000 miles and was maintained routinely and on schedule. The failure first occurred before November 18, 2025, when I reported stalling issues to Kia authorized service & parts. The vehicle was returned as “fixed” on December 12, 2025, but the engine stalled again during normal operation. The vehicle was returned to Kia authorized service & parts multiple times (December 12, December 18, December 23, January 9, January 12, 2026, and March 4, 2026), with repeated assurances that it had been repaired. Each time, the car continued to stall, including during a test drive at Subaru, demonstrating that the failure persisted despite repeated dealer intervention. The stalling created a significant hazard, as the car could lose power while on public roads, including highways, potentially leading to accidents. There were no consistent warning lights or messages prior to the engine stalling; the first symptom was intermittent loss of power while driving. The failure has been reproduced and observed by multiple service personnel at Kia authorized service & parts and by Subaru during the trade-in test drive. The component(s) causing the failure were inspected by Kia authorized service & parts staff, but no effective repair was made. Documentation of repair orders and dealer inspections is available for review.

Filed Jan 13, 2026 · Engine, Fuel system · IN

I purchased this vehicle on [XXX], with approximately 170,150 miles. On [XXX], during a routine oil change at approximately 172,636 miles, it was discovered that the engine had no oil present. Shortly afterward, the oil warning light began flickering intermittently while driving. On November 4, 2025, at approximately 175,495 miles, a certified mechanic again confirmed that there was no oil present in the engine. At no point were there visible external oil leaks, indicating excessive internal oil consumption. This condition creates a serious safety risk, as sudden engine failure while driving could lead to loss of power, stalling, or accidents. Based on my experience and publicly known issues involving Kia engines, this appears to be a systemic defect rather than normal wear. I am requesting that the federal safety agency document and review this issue as a potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 15, 2025 · Engine · FL

The engine appears to be consuming an abnormal amount of oil. There are no visible leaks or external damage, and the vehicle has not yet stalled or failed, but oil levels drop rapidly between oil changes. The engine is available for inspection upon request Driving with low or empty oil levels risks sudden engine failure while in motion, which could lead to loss of power, stalling in traffic, or even a crash. The oil warning light came on and went off at regular intervals unexpectedly during driving this week, which prompted me to get it to my mechanic asap to avoid potential engine damage or failure. They performed an oil change (even though I had done it there for this same car only 2133 miles ago NOT YET. I have contacted the dealership and have been advised to monitor the oil level or potentially conduct an oil consumption test. I have not yet received a formal diagnostic or confirmation from Kia or a third party. Yes the vehicle was formally inspected by Gettel Kia of Bradenton on 14th Street for an engine stalling issue... Have experienced a stall only once since then Yes. The oil warning light turned on (and off several times in 1 minute intervals) for the first time around 132011 miles. Upon the mechanic checking the dipstick, the oil level was significantly below minimum. No check engine light appeared. An oil change was performed only 2133 miles since the last one. Additional Notes: I have discovered multiple similar reports from other 2016–2020 Kia Optima owners via online forums such as Reddit and Kia owner groups, suggesting this may be a widespread issue related to the GDI engine design. These cases often go unresolved until engine damage occurs. I am requesting: A formal oil consumption test A full engine inspection Repair or replacement if the issue is confirmed Consideration for goodwill or warranty extension due to potential manufacturing defect I am maintaining oil top-off records and would be happy to provide them

Filed Mar 26, 2025 · Driver assistance, Electrical · LA

UNKNOWN. Vehicle is burning through oil every 1,000 miles or so. Excessive oil consumption which i am aware there is a recall. However Kia states my VIN # is not included. While at the dealer service department for failed A/C system, we questioned the excessive oil consumption and engine replacement. We were told they found nothing wrong. Having to top off oil every 1,000 miles or so. It does not make it to the next oil change before the light comes on. No oil leaks. Mechanic said known problem with this engine. Most recently the starter went bad, alternator, and battery. Replaced with a second brand new battery and car won't start again. Dash is lighting up erratically, new battery dead. As if something is drawing all power and draining brand new batteries. This car has a little over 86,000 miles and one thing after another is failing. The car lost power and power steering in a curve leaving us in a dangerous situation after replacing the starter. Dash lighting up erratically with front end collision warning message on the display. We had it towed to our residence which our auto insurance reimbursed us for. Replaced alternator and battery yesterday, and the car lost all power again turning back onto our street, again with the Dash lighting up erratically.

Filed Aug 19, 2024 · Engine · OK

The car is using oil like crazy and is not leaking anywhere out of the vehicle. Stalling out while driving and then accelerating. Has completely lost power and rolled down an onramp. Completely unsafe. Took for diagnostic and they wanted to say I needed a new gas cap. Replaced, still doing same thing. Hesitant to start even and the alternator is less than a year old.

Filed May 15, 2024 · Engine, Fuel system · MD

I am writing to bring to your attention a critical safety issue with my 2019 Kia Optima SX 2.0 GDI Turbo, which has accumulated approximately 103,000 miles. This vehicle has recently developed several serious problems that I believe pose significant risks to both my safety and the safety of other road users. Firstly, my Kia Optima has been burning an excessive amount of oil. Specifically, it consumes over 5 quarts of oil within just 2,000 miles of driving. Despite thorough inspections, even from Kia Dealers there are no visible oil leaks, making this issue even more perplexing and concerning. Moreover, the vehicle has begun to shake violently while driving on the highway, which has led to a substantial loss of power in the middle of traffic. This unpredictable loss of power is extremely dangerous, especially at high speeds, as it compromises my ability to maintain control of the vehicle and poses a significant hazard to other motorists. Additionally, the car now emits a loud knocking noise, which appears to be related to the engine's internal components. This issue further exacerbates the vehicle's performance problems and raises serious questions about its reliability and safety. I urge the federal safety agency to investigate these issues promptly. The problems I am experiencing are not isolated and may affect other Kia Optima owners, potentially leading to widespread safety risks. I believe it is crucial to determine if there is a manufacturing defect or other underlying cause that needs to be addressed to prevent accidents and ensure the safety of all Kia Optima drivers. Thank you for your attention to this matter. I am hopeful that the federal safety agency will take immediate action to investigate these serious safety concerns and provide a resolution to protect both myself and others.

Filed Apr 4, 2024 · Engine · GA

2019 Optima EX excessive oil consumption. Oil changed every 3000 miles, but is always empty within 1000miles. Car has 101,000 miles. Took to Kia dealership due to loss of power on acceleration and stalling and excessive oil consumption, they said I have multiple misfires on cylinder 1, excessive sludge buildup under cap and again no oil present. I was advised the engine needed replaced and that somehow this is a me problem and not a Kia problem. Spoke with Kia support and because it’s 1,000 miles over warranty they will not do anything even though they are aware of excessive oil consumption issue in these motors