2014 Kia Sportage problems

What is wrong

Kia Motors America (Kia) is recalling certain 2016-2018 K900 and 2014-2016 Sportage vehicles. The Hydraulic Electronic Control Unit (HECU) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Risk

An engine compartment fire while parked or driving can increase the risk of injury.

Remedy

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse for the HECU circuit board, free of charge. Owner notification letters were mailed September 22, 2022. Owners may contact Kia customer service at 1‑800‑333‑4542. Kia's number for this recall is SC227.

Recall number 22V051000 · Recall details

What is wrong

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V‑224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Risk

A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy

Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1‑800‑333‑4542. Kia's number for this recall is SC172.

Recall number 18V907000 · Recall details

What is wrong

Kia Motors Corporation (Kia) is recalling certain model year 2014 Kia Sportage vehicles manufactured September 30, 2013, through January 11, 2014. The certification label has incorrect tire pressure information printed on it, listing a specification that is 1 or 2 psi below the correct information. Thus, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) 110, "Tire Selection and Rims for Passenger Cars."

Risk

Maintaining tire pressure below the recommmend specification could result in premature tire wear, increasing the risk of a crash.

Remedy

Kia will notify owners, and dealers will correct the label information, and owners will also receive a sticker to put into the owners manual, free of charge. The recall is expected to begin in February 2014. Owners may contact Kia at 1‑800‑333‑4542. Kia's recall campaign number is SC103.

Recall number 14V023000 · Recall details

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V‑520, 20V‑543, 21V‑161, 21V‑160, 21V‑303, 22V‑056, 22V‑810, and 23V‑651. Kia recalls 16V‑815, 20V‑518, 20V‑519, 21V‑137, 21V‑331, 22V‑051, 22V‑800, and 23V‑652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

AQ23002

the federal safety agency received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to the federal safety agency which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in the federal safety agency's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, the federal safety agency does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing the federal safety agency’s reasons for denial of the petition will be published. The reference numbers for the complaints to the federal safety agency cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to

DP22003