2020 Kia Telluride: excessive oil consumption

Filed Oct 14, 2026 · Engine · CA

I have this 2020 telluride and it’s consuming a lot of oil I have to add a quart of oil every 600 miles. I was wondering if there is any open recalls for this.

Filed Oct 7, 2026 · Engine · CA

I am reporting a potential safety defect involving excessive engine oil loss and persistent oil leakage on my 2020 Kia Telluride, VIN [XXX]. The vehicle currently has approximately 100,367 miles. It has been experiencing significant oil loss, approximately one quart of engine oil per week. I am concerned that this amount of oil loss is abnormal and creates a potential safety hazard if the engine loses sufficient oil while the vehicle is being driven. The vehicle has also had repeated oil leaks, including an oil pan leak and timing cover leak. I have taken the vehicle to Kia for repairs multiple times, but the oil-related problems have continued. This has required me to continually monitor and add engine oil to prevent the oil level from becoming dangerously low. I specifically brought the vehicle to Kia because of the excessive oil consumption and ongoing leaks. However, the dealership has told me that they will not perform an oil-consumption test until the existing oil leaks are repaired. Kia Customer Care also opened case #[XXX], but I was subsequently told that Kia could not provide assistance because the vehicle is outside the standard warranty period. I am concerned that the underlying cause of the excessive oil loss has not been properly diagnosed. I am also concerned about the possibility of engine damage or engine failure if the vehicle continues losing oil at this rate. Kia has also issued a 2026 warranty extension concerning an engine oil-filter-housing gasket leak on certain 2020–2025 Telluride vehicles. I have asked Kia to determine whether my vehicle is affected by this condition and whether the current oil leaks are related, but I have not received a satisfactory resolution. I am asking the federal safety agency to review this complaint along with other complaints involving 2020 Kia Tellurides experiencing excessive oil consumption and/or recurring engine oil leaks to determine whether there is a potential safety defect or broader pattern that warrant INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

Filed Oct 6, 2026 · Engine, Suspension · IL

I am filing this safety report regarding my 2020 Kia Telluride, which currently has approximately 133,000 miles. The vehicle is experiencing severe internal oil consumption, burning through multiple quarts of engine oil rapidly between normal service intervals without triggering any dashboard warning lights, creating a high risk of sudden engine failure or stalling at highway speeds. Additionally, the vehicle is losing coolant at an accelerated rate, risking severe engine overheating. Furthermore, the suspension system has been a recurring safety nightmare; the shocks have failed and been replaced twice, and a critical structural defect caused the tires to rub directly against suspension components while driving, prematurely destroying the tires and severely compromising vehicle stability and steering control. I do not feel safe driving this car or transporting my kids everyday. When I spoke to Kia customer service, I was told they could not do anything despite being just under 100,000 miles at the time.

Filed Oct 1, 2026 · Engine, Suspension · NC

Purchased vehicle 8/31/2021 - 32k miles 10/18/21 - first mention of oil consumption (opened case with Kia) 2023,2025,2026. 3 more cases filed and DENIED with Kia customer care. Filed BBB claim, filed BBB anutoline claim, also hired lemon lawyer. Kia offered $6k to go away (I declined). *July 18,2026 Kia finally diagnosis and recommends engine replacement. Bore scope was used to discover scoring on cylinders from significant oil consumption. Vehicle is now smoking at take off (112k miles), current open case with Kia customer care again. Requesting buyback or settlement for the 3rd time in 5 years. Still paying $600 a month Safety concern: on a trip out of state vehicle dash lit up every icon and went dead in the middle of a packed 4 lane highway , started with power steering, no lights, no horn , couldn't roll window down.(video avail) Vehicle towed to dealership. Had replaced battery 2 times already. This has happened twice and my family was in the vehicle once on the large highway, very scary no one knew we were broke down bc we had no way to show it. People blowing and zooming by mad. Low oil light doesn't exist on this vehicle, I've been bone dry with no indication EVER. I now ride around with a 5 quart jug of oil and funnel in the back of my car since 72,000 miles. This should be illegal. Rear suspension: 4 times the rear suspension has been replaced (7 times in the shop to be fixed one time over 30 days) and has never been fixed , now making the same knocking noise it's always made. The car is a lemon and Kia knows it and will not stand behind their product. I DO NOT FEEL SAFE IN THIS VEHICLE, kia has been notified numerous times in every avenue and every way I could communicate, they say "we will call you with an update when we have one" that call NEVER happens.

Filed Sep 24, 2026 · Engine · OH

My 2020 Kia Telluride experienced progressive and severe engine oil consumption that ultimately required a full engine replacement. Beginning well before the failure, the vehicle required frequent manual oil top-offs between scheduled changes, including on longer trips. No low-oil warning light, check-engine light, or oil-pressure warning ever illuminated to alert of critically low oil levels. In late March 2026 an independent service center replaced the engine oil filter housing and related gasket after an oil leak was observed; an axle damaged by oil spray was also replaced at that time. Shortly afterward the manufacturer issued a warranty extension covering oil-filter-housing gasket leaks on 2020–2025 Tellurides, extending coverage to 15 years/180,000 miles for that specific condition. Despite the housing/gasket repair, the excessive oil consumption continued. Several weeks later the vehicle lost power and broke down while being driven. It was towed to an authorized Kia dealership. Technicians inspected the vehicle, confirmed heavy oil consumption (noting the engine had been requiring large amounts of oil nearly weekly with no external ground leaks observed), and diagnosed catastrophic internal engine damage. They recommended complete engine replacement at a quoted cost exceeding $13,000. The dealership also inspected the oil-filter housing area under the recent warranty extension but determined the engine damage itself fell outside that limited coverage. The oil-consumption problem and resulting engine failure create a clear safety risk: sudden loss of power or stalling can occur without any dashboard warning, potentially while the vehicle is in motion on public roads. The failed engine and related components remain available for inspection. The condition has been confirmed by both an independent service center and an authorized Kia dealership. Similar oil-consumption and engine-damage reports have been widely noted among other owners of the same model.

Filed Sep 18, 2026 · Engine · 69,000 miles · NJ

The contact owns a 2020 Kia Telluride. The contact stated that while driving 5 MPH, the vehicle unexpectedly stalled in the middle of an intersection. The vehicle was restarted; however, the low oil warning light illuminated. The vehicle was taken to a dealer, where an oil consumption test was performed. The dealer informed the contact that no failure was found. The contact stated that the failure reoccurred and, after inspecting the vehicle, the oil level was low despite a recent oil change. The contact stated that the vehicle was scheduled for another oil consumption test with the dealer. The manufacturer was made aware of the failure by telephone. The approximate failure mileage was 69,000.

Filed Sep 12, 2026 · Engine · PA

I have a Kia Telluride 2020 EX AWD automatic. I bought it used about 2.5 years ago. It’s been having some ongoing issues with oil consumption, which from what I have learned is pretty common in this car. Since I learned that I’ve been increasing the frequency of oil changes and topping off oil in between. It burns oil at an absurd rate, and gives no warning when oil is low. On the most recent change, ~a month ago, the mechanic recommended changing it after 3,000 miles. Yesterday the car completely shut down while driving on the highway, no warning or anything, just a noise, smoke and then the car died in a matter of seconds. I nearly got in an accident trying to drift to the side of the road with no power or anything. No control of the car. Ended up stuck in traffic going 70+ mph with a toddler. After it was towed, our mechanic found there was no oil left and we had two holes in the engine casing. He explained it looks like when the oil ran out completely, some part broke off in the engine and shot through the housing. So it’s looking like we need a new engine. We had NOT driven it 3000 miles since the last oil change just a month ago, and we have even topped off the oil since that change, most recently a week ago. This means the car burned through about 9 quarts of oil in <3000 miles. Multiple mechanics have told us this is a known issue with the car, and there is nothing to do to prevent it. When we called the dealership to inquire about getting a new engine, they told us we would need to do an oil consumption test. Obviously this is impossible on a car that does not drive and has two holes in the engine. So we are stuck paying out of pocket. Kia is well aware of this issue and is doing nothing.

Filed Sep 6, 2026 · Engine, Fuel system · UT

My engine failed from burning oil, even though the car has been maintained its whole life, 14 documented oil changes, roughly every 5,000 miles. • Jiffy-lube shop found the crankcase completely bone dry, only 4,344 miles after the last oil change. No reading on the dipstick. They added 6 quarts. Engine was knocking before and after. • No oil warning light ever came on, and no low-oil warning, just a check engine light and the knocking. • Towed same day to an independent shop. They found code P0524 (engine oil pressure too low) and say the internal noise is probably a rod bearing. Engine needs to be replaced. • The car goes into limp mode while driving. On the highway it dropped from 60 mph to 20 mph in live traffic with no warning. I couldn't safely get to an exit. • That's about 1.4 quarts per 1,000 miles, Kia's own bulletin ENG222 calls 1 quart per 1,000 excessive. • The car is not drivable, hasn't been repaired. This happened around 3 months after purchasing it second hand. Lots of other 2020 Telluride owners are reporting the same oil consumption problem.

Filed Aug 28, 2026 · Engine · AL

The car has stalled numerous times on the roadway while driving. The issue has been identified as an oil consumption issue. There was no low pressure warning light or other warning indicating that there is an oil pressure issue or any other early warning of an engine stall. The dealer has indicated that a complete engine replacement is required to correct the problem. Based upon research, there has been a significant amount of complaints pertaining to this issue. This same oil consumption and engine stall issue was part of a Class Action settlement by KIA, however this particular KIA model was not covered in the litigation.

Filed Aug 27, 2026 · Engine · WA

Vehicle experienced significant drivability issues including shaking/clinking at speeds over 50 mph, check engine light, and reported two-cylinder misfires. Engine oil level was critically low, not registering on the dipstick, requiring approximately 2 quarts added to continue driving. An independent mechanic inspection found excessive oil in Cylinder 2 and assessed that oil was likely leaking past the piston rings and burning, recommending a bottom-end rebuild or engine replacement. Kia dealership (Sunset Kia) inspection subsequently found a score mark in Cylinder 6 and two external oil leaks (oil pan gasket and oil filter housing). Kia approved goodwill repair of the external leaks only, after which I was instructed to drive approximately 1,000 miles for a follow-up oil consumption test. After that period, the dealership confirmed the engine was still consuming oil beyond the external leaks. Kia Corporate took approximately three weeks to review a goodwill request for engine replacement, ultimately denying it. During this three-week period the vehicle remained at the dealership, and I incurred over a week of out-of-pocket rental car expenses due to no loaner vehicle being available and no transportation assistance offered. The vehicle has fewer than 100,000 miles. I am concerned this reflects an internal engine defect (oil consumption/piston ring or cylinder wall issue) affecting the vehicle’s safe operation, given the drivability symptoms (shaking, misfire, near-zero oil level) that initially prompted this investigation.

Filed Jul 27, 2026 · Engine, Seats · 60,000 miles · CA

The contact owns a 2020 Kia Telluride. The contact received notification of the federal safety agency Campaign Number: 26V430000 (Seats); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact needed to add a quart of oil per week. The vehicle was taken to a certified mechanic who diagnosed that the piston in the engine was damaged from oil consumption, ultimately causing the engine failure. The engine was replaced. The dealer was not contacted. The manufacturer was made aware of the issue and denied covering the cost of the repair. The manufacturer was not contacted about the recall. The failure mileage was 60,000.

Filed Jul 27, 2026 · Engine · KS

Purchased this car used in July of 2025 with 77,000 miles. When we went in for the first complimentary oil change at ~5,000 miles, there was no noticeable oil on the dipstick. The dealership continued with the oil change and advised us to come back every 500miles for an oil consumption test. We did this three separate times and each time we were at least a full quart low each time. It was determined that the engine needed to be replaced. Luckily for us, it was covered under warranty. Our engine was replaced with a remanufactured engine from Kia. When we asked if this problem was going to happen again, we were told yes, but with no timeline. We now have no idea what to expect with this “new, but used” engine and why we were never alerted to the car being low on oil before the first complimentary oil change. Concerns for the purpose of this report are the reliability of these engines and the oil level/pressure sensing system.