2021 Kia Telluride: engine knocking or ticking

Filed Sep 21, 2026 · Engine, Transmission · OH

I purchased my 2021 Kia Telluride S new, with only 22 miles from the test drive. XXX (approx. 53,000 miles, vehicle age 18 months): The transmission failed while I was traveling approx. 75-80 mph on a major highway in [XXX]. Upon failure, the vehicle suddenly lurched as if the brakes had locked or the parking brake had been applied, nearly causing us to strike our heads on the dashboard and creating a hazardous situation for other traffic. After the failure, the vehicle would only operate in approx. first through third gears and reverse, and would not exceed 25 mph. We were forced to limp the vehicle off a busy six-lane highway. XXX: Due to parts delays, the vehicle was not returned until November 2022 after the transmission work. XXX (approx. four months later): The vehicle developed engine knock and excessive oil consumption. Advised this may have been related to oil degradation while the vehicle sat waiting for parts. Since then, I had to regularly check and add oil between oil changes. Despite low oil levels, no oil pressure warning light ever appeared. XXX (exact date unknown): While opening the sunroof at a stop, a loud crack occurred and pieces of the sunroof track, plastic and metal, fell onto me and my passenger. The glass is intact but became partially stuck open without the track to guide it. XXX: The engine knock worsened and became a squeal while driving approx. 60 mph. The vehicle lost power, requiring me to turn on hazards and coast off to avoid accident. Dealership mechanic advised that the engine had thrown a rod and blown the oil filter housing gasket. The vehicle is currently at the dealership and available for inspection. Kia has denied coverage despite the failure of a component linked to excessive oil loss and a recently extended 180,000-mile warranty, even after the engine threw a rod following a sudden loss of oil pressure. The failed transmission has likely already been disposed of. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 8, 2026 · Engine · IA

My 2021 Kia Telluride has developed progressively worsening engine problems without any warning lights ever appearing that may present a serious safety concern. Approximately two months ago, the vehicle began experiencing significant engine shaking and rocking. Maintenance and repairs were performed, and the symptoms temporarily improved. The engine symptoms later returned. The vehicle began making a noticeable ticking noise that progressively became much louder and occurred both while idling and during acceleration. The vehicle subsequently shut off after being driven to an independent mechanic. Multiple warning/diagnostic alerts appeared, and the vehicle would not remain running when restarted. The mechanic checked the engine oil and found it essentially empty. Approximately 4½ quarts of oil were added. The ticking noise continued despite the addition of oil. Later that same day, the engine developed a pronounced knocking noise that continued while driving. There was also a hot smell, and I had noticed discolored smoke coming from the exhaust. The vehicle is currently parked and is available for inspection. I have stopped driving it because I am concerned about an engine failure and the possibility of the vehicle shutting off or losing power while being operated. The vehicle has been maintained and I have documentation of its maintenance and repair history. The underlying cause of the severe oil loss and engine symptoms has not been determined.

Filed Apr 11, 2026 · Engine · OH

Kia has 110,000 miles on it. We’ve regularly changed the oil at 3-5k mile intervals. A week ago, I heard loud knocking from the front of the car, along with loss of power. We drove it to our local Kia dealer (Kia of Bedford, OH), where upon inspection, they found cylinder bank 2 to be inoperative due to loss of oil. They found approx 2 quarts of oil in the engine - way below normal. They observed NO oil leaks. We inspected our garage and driveway floors, and there is no indication of any oil leaks. The Kia dealer said the engine needs to be replaced, at a cost of $12,700. I contacted Kia Customer Care, and they said it’s out of warranty and they won’t help. I replied back with an appeal to escalate to a higher / regional level for help. The oil had been changed at 105,000 miles. No oil leak present. Routine oil changes performed. This engine should never have had this issue at 110,000 miles. I know this is a known issue with this era of Kia engines. I’ve asked Kia to provide assistance in a repair.

Filed Apr 6, 2026 · Engine · IN

Recently our 2021 Kia Telluride, had a fluttering/metal knocking/mechanical sound and I scheduled a shop visit at our trusted local mechanic. After their inspection, they found that the oil was extremely low and there was metal shavings in the oil filter housing. This was found when absolutely no warning lights were activated that would indicate low oil level or any other engine challenges. The vehicle is maintained with regular oil changes. The vehicle only has 65k miles. Looking further into this online, it seems very similar to the Theta engine recall from Kia. No warning lights/indicator lights, well maintained vehicle with regular oil changes, and to all of a sudden consume almost all the oil and have metal shavings in the oil filter housing is extremely concerning. As of 4/6/2026 the dealer is assessing the vehicle and coming up with a plan and or further actions to be done.

Filed Mar 22, 2026 · Engine · FL

I am a 2nd owner of a kia telluride and the engine failed without warning at less than 90,000 miles. No check engine light, no temp gauge, no low oil level light. No warning at all. Just failure of the "push rod bearing" ny Kia was regularly maintained and when I took it to the dealership, they told me it was down about 3.5qts of oil! Again no low oil light? It holds 7qts...9,000$ later out of my pocket after being denied a goodwill engine replacement from kia to put a new motor in. I have found many others on on-line forums who have experienced this. Please help

Filed Dec 27, 2025 · Engine · IA · fire

First there are holes in the block from a rod bearing coming off. It was leaking oil and started on fire. There are many recalls and law suits regarding this matter and we shouldn’t be on the hook for putting a new engine in.

Filed Sep 3, 2025 · Engine · TX

On or about December 2024, we noticed a hesitation or sputtering in the performance of our Kia. I contacted Ancira Kia who reviewed the vehicle, which displayed no warning lights. Since they couldn’t duplicate the issue, nothing could be done. On or about [XXX], the vehicle’s cooling fan engaged on its own while parked in the garage and revved up extremely high. This was the second time this had happened. Ancira Kia couldn’t duplicate the problem although they mentioned another customer was experiencing the same problem. A few days later, I was advised to bring the vehicle in for a sensor replacement. So far, the problem hasn’t recurred but I won’t know if it’s fixed until it never happens again. On [XXX], while traveling from Del Rio to San Antonio, TX, we stopped at a rest area. There were no warning lights visible and no performance issues noted until this time. When we started the vehicle to leave, we noticed a slight knocking that went away when we put the vehicle in drive. After our next stop, we noticed the knocking noise again when we started the vehicle and the noise dissipate when we drove. After the next stop the noise appeared to be louder so we decided to stop for lunch and let the vehicle cool down so we could check the oil. When we checked the oil, we saw there was no oil marking the dip stick. I took the vehicle to Ancira Kia who also found no oil marking the dip stick. The engine was ruined and needed to be replaced. None of the Telluride’s warning systems illuminated. No check engine or oil pressure lights lit up. This is a catastrophic failure of the Telluride which placed my husband and I in severe danger. We could have been injured and possibly killed had the engine seized while we traveled on the highway between Del Rio and San Antonio, Texas (150 miles). My vehicle is meticulously maintained at Ancira Kia. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 9, 2024 · Suspension · IL

There is an ongoing problem with the NIVOMAT self-leveling shocks on every model year of this vehicle. The problem occurs at nearly every speed but is more noticeable at lower speeds (35mph or less) while going over uneven terrain or hitting small bumps. The vehicle produces a clunking noise from the rear of the vehicle and there is no cushioning or rebounding from going over the bump or uneven terrain. Instead, there is more of a jolting knock when hitting small bumps and a constant bouncing around/floating feeling while driving over uneven terrain. This is dangerous because passengers and cargo in the vehicle gets bounced around and the vehicle gets harder to control especially at higher speeds. Many of these shocks are failing early in the life of the vehicle. Mine is at 27K miles, however I believe the problem started before and probably closer to 18-20K miles. Kia knows about this issue but has failed to come up with a reliable solution. This is four model years now with the same issue. Kia has released TSB after TSB on this, only replacing certain parts of the shock (isolators, etc.). However, there are still reports of replacement parts and even new full shock assemblies failing around the same amount of milage. It would be great if a wider recall can be issued to address this ongoing problem that seems to affect every model year so hopefully Kia can find a more reliable, quality part to replace the consistently failing part.

Filed Aug 27, 2021 · TX · 1 injury

Closed rear hatch door with button on dash (because button on hatch door only works if key is in hand)/walked back to rear of car to walk around/door was still closing and landed forcefully on my head, hitting it 3 times, with no ‘obstacle in path’ safety response, and knocking my feet out from under me, landing me on my butt/door hit head so hard I saw stars, became light-headed, shot pain through my neck/left three bumps on my head, and a headache that has lasted for 3 days/If this had hit a child, we’d be having a much different conversation/The hatch never did release and return to an open position/It continued to close.