2017 Ram 2500 engine problems

Filed Sep 25, 2026 · Engine · 120,000 miles · WA

The contact owns a 2017 Ram 2500. The contact stated that while driving 25 MPH, there was an abnormal sound coming from the vehicle. The contact stated that upon inspecting the vehicle, there was a squeaking sound coming from the coolant pump. The dealer was contacted by phone and made aware of the failure. The contact referenced an unknown recall; however, the VIN was not associated with a recall associated with the failure. The manufacturer was contacted by phone and made aware of the failure. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 120,000.

Filed Aug 25, 2026 · Engine, Transmission · MS

Motor completely over heated causing the hose to rupture underneath the intake manifold. Engine is unrepairable. Had to order new engine and a new intake manifold because it melted the current one. Also approximately 2 years ago, I also had to replace the transmission. This truck only has 155,000 miles in it and has had 2 major break downs. WHY? This truck is unsafe.

Filed Aug 24, 2026 · Engine · CO

My turbo actuator failed and was replaced in February of 2026. This is the same part, manufactured the same year as the recall: LOP#09440301 Both the manufacturer and the federal safety agency knew of this problem for years, but only fixed a small portion of the impacted vehicles. Please make me whole and refund my expenses for this known faulty actuator and repair work. Let me know if there is anything more you need from me.

Filed Apr 16, 2026 · Brakes, Engine · 82,792 miles · MA

The contact owns a 2017 Ram 2500. The contact received notification of the federal safety agency Campaign Number: 24V896000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not available. The contact stated that while driving at various speeds, the ABS and check engine warning lights illuminated. The vehicle was initially taken to the dealer to be diagnosed. The diagnostic test determined that there was a failure with the ECM. The ECM was replaced; however, soon after the repair, the warning lights returned with the vehicle going into LIMP Mode. The vehicle was taken back to dealer, where the vehicle remained for months while attempting to determine the cause of the failure. The contact was then informed that the transmission needed to be replaced. The contact was provided an estimate for the repair, and the vehicle was towed to an independent mechanic, where a diagnostic test indicated a failure with the hydraulic control unit (HCU). Several repairs were performed, but failed to correct the failure. The mechanic replaced the transmission twice; however, the failure returned after each repair. The manufacturer was notified about the failure, and the contact was provided with two case numbers. The vehicle was not repaired and remained with the independent mechanic. The failure mileage was 82,792.

Filed Mar 21, 2026 · Brakes, Engine · RI

My 2017 Ram 2500, 6.4L Hemi experiences warning lights which I'm told is caused by intermittent PCM failure. I'm told this can cause the truck to stall while in motion, refuse to start, or enter "limp mode". This amounts to a possible unsafe condition that can put myself and passengers at risk of property damage, bodily injury or worse. I brought the truck to Priority Automotive of Westerly, LLC on March 9, 2026 for diagnosis. Their diagnosis (attached) recommended replacing the PCM to correct (possibly), "...intermittent internal short(s)". Cost of the repair is $2,012.42. Subsequently, I contacted customer care at Stellantis (866‑726‑4636) and was given Case #[XXX]. I was told to make an appointment at the aforementioned dealership and call them the day before the appointment, so they could send a representative to the dealership for examination. I did exactly that to no avail. No one from Stellantis even contacted the dealership on the appointment date. I called them to find out what happened, only to find out (from a supervisor) that they are not offering assistance in the matter. Additionally, the truck is currently under recall #C4B/the federal safety agency 24V‑896 (PCM related) and, to-date, I'm told the part is still not available after more than a year since the recall. I've owned Dodge Rams for over 27 years and find the situation unsafe and totally unacceptable. I'm also aware that many other owners of the 2017 Ram 2500 6.4L experience PCM/ECM issues, causing no-start conditions or stalling, and have reported them alongside braking system complaints. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 11, 2025 · Engine · NV

It is a known issue that 2017 ram 2500 diesels experience turbo or actuator failures at low mileage costing upwards of 8-10000 dollars in repairs. My ram only has 61000 miles and due to exhaust fluid requirements etc, premature failure is common. Owners should be able to extend the warranty to 15 years as Chrysler has known this issue and has failed to address it. The code is in the attached screenshot.

Filed Aug 1, 2025 · Engine · 93,000 miles · PA

The contact owns a 2017 Ram 2500. The contact stated that while driving at various speeds, the vehicle hesitated to accelerate as intended while the accelerator pedal was depressed. The “Low Coolant” warning light was illuminated. The contact was able to pull over to the shoulder of the roadway. While inspecting the vehicle, the contact became aware that the vehicle was experiencing excessive coolant consumption. The vehicle was taken to a local dealer, where it was diagnosed that the EGR system had failed and needed to be replaced. The vehicle was not repaired due to the cost. The vehicle remained at the local dealer for further tests. The manufacturer was made aware of the failure. The failure mileage was approximately 93,000.

Filed Jun 21, 2025 · Brakes, Engine · OK

When I have gone to slow down and try to stop, the vehicle has slide forward a fee times. I thought it was a little weird, but didn't think to much of it. After a while, my transmission started acting up as well. I will be driving down the road about 50-60mph and it will shift to 4th gear and not come out of 4th gear until stopped and shut off and restarted. I recently heard about the recall when I took my truck to the dealership that is close to where I am located at the moment. I decided to research about the recall and what could happen if that part fails. It showed me that if the recalled part fails, it will cause all the problems that is going on with my truck. I am a full-time rv'er and trailer the country pulling an rv everywhere I go. I am stuck where I am until my truck can be fixed of these problems. This is a major setback and a major financial burden to have to stay where I am until it is fixed. I am near Thomson, GA where I am waiting to have my vehicle fixed.

Filed Apr 28, 2025 · Engine · CA

I got a p2609 code when the check engine light came on. After researching the code it has been determined it is the bolt holding the grid heater in place has deteriorated and now my engine needs to be dismantled to repair the problem. These repairs are roughly $3000.00. Ram has been aware of this problem in their vehicles since 2007 models and it is still a problem they are not being held responsible for.

Filed Mar 28, 2025 · Brakes, Electrical · 153,777 miles · MS

The contact owns a 2017 Ram 2500. The contact stated that while driving at highway speeds, the check engine, traction, and ABS warning lights illuminated. Once the warning lights had appeared, the speedometer, odometer, and cruise control functions failed to operate as needed. The contact also stated that the transmission failed to shift out park(P). The vehicle was taken to an independent mechanic, where a code reader determined that the failure was linked to the ABS control module. The contact then received notification of the federal safety agency Campaign Number: 24V896000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, and the contact was provided the same information as the dealer. The failure mileage was 153,777. VIN tool confirms parts not available.