2016 Ram 3500 technical service bulletins
490 technical service bulletins and manufacturer communications cover the 2016 Ram 3500, including one warranty extension.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Warranty Bulletin D-24-10 (XQ1) Emission Control System Components – Select 2013
- Air cleaner - none
- Trac-Rite Operation Diagnosis, Chatter, Shudder, Moving From A Stop And Turning
- Bearing
- Outside Power Fold Rearview Mirror Noise Or Loose At Pivot
- Squeak Or Squawk Noise Coming From Either Side Door Of The Vehicle, It Could Be Just One Door Or More
- Speaker - none
- Verify "Z" part number availability
- Front Axle Disconnect (FAD) Electrical Connector Design Change On Replacement Axle Assemblies.
- Lamp - dome
- Malfunction Indicator Lamp (MIL) Illumination, Diagnostic Trouble Codes (DTCs) P21C4 – (Diesel Exhaust...
- Antilock brake system Attention: Please return removed ABS modules ASAP to the supplier
- Malfunction Indicator Lamp (MIL) Illuminated
- Seal - output shaft
- Gear - reaction sun
- Plate
- Emission Recall 67A D Truck Engine Calibration
- Emission recall 67A d
- On Board Diagnosis (OBD) Monitor Readiness Information
- 6.7L Diesel Emissions Warranty Extension XQ1 Special Warranty Extension"
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Emission Recall 67A
- Steering Drag Link If drag link had been welded due to V06 recall repair and there is an alignment...
- Lifter
- Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair...
- Warranty Bulletin D-16-03
- FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage
- Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review...
- 6.7L New Oil Usage Information Incorrect oil used
- Water Quality When Mixed With Engine Coolant
- Ambient Air Temperature Missing, Malfunction Indicator Lamp (MIL) Lamp On, Diagnostic Trouble Code (DTC)...
- Ambient Temperature Sensor Servicing.
- WiTECH Small Leak Verification Test (SLVT)
- Malfunction Indicator Lamp (MIL) Illumination
- Guidelines For The Use Of Alternative Diesel Fuels.
- Connector
- Approved Use of Weld Through Primers
- Cooler - EGR
- Flash: Powertrain Control Module (PCM) Updates
- Connector/wiring
- Flash: Powertrain Control Module (PCM) Updates
- Flash: Powertrain Control Module (PCM) Updates
- Roof Damage Repair
- If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is...
- Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire
- Flash: Powertrain Control Module (PCM) Updates
- Transfer Case Shift Lever Design Change
- Left Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger
- Updates - safety recall Y26 wheel studs
- Diesel Injector Freezing
- No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
- Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement...
- Customer Complaint May Include Engine Oil Leak Or Consumption
- No Start, No Crank
- Wiring
- NUT, Wheel Flange Wheel Nut Service Torque should be 175 N-M.
- NUT, Wheel Flange Wheel Nut Service Torque should be 190 N-M.
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle,...
- Battery Tester Warranty Code Procedures, Midtronics Charger Update Process
- Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
- Battery Tester Warranty Code Procedures, Medtronic Update Process
- Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles
- Customer complaint may include engine oil leak/consumption.
- Plate - clutch pressure
- Malfunction Indicator Lamp (MIL) Illumination
- Customer may complain of a MIL lamp on. Upon further investigation there could be a fault code in the PCM...
- (Rev. A) Power Inverter Load Ratings
- Flash: Drivetrain Control Module (DTCM) Update
- External Fuel Pump Relay Kit Now Available
- Intelligent Power Distribution Center If the PDC requires replacement due to a failed internal fuel pump...
- Power Distribution Center If the PDC is being replaced due to a failed internal fuel pump relay, the relay...
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle
- 6.7L New Oil Usage Information
- Click Or Pop From Drag Link
- Blind Spot Or Park Assist Warnings, False Activation
- Turbocharger vs Turbocharger Actuator Replacement
- 5th Wheel/Gooseneck Trailer Hitch Does Not Fit
- Flash: Anti-lock Brake System (ABS) Enhancements
- Rear Axle Vibration, Shudder Or Chatter
- Disinfectant Solution Recommended for COVID-19
- Charging System, Battery Diagnostic Tools and Warranty
- Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season
- Valve Body Pressure Testing Plug Inspection
- Hands On Steering Wheel Message In EVIC
- RFE Valvebody Plug Installation OEM RFE valve bodies require seven (7) 06030035 plugs installed and...
- Speed Control Operates Intermittently
- Chatter, Shudder, or Vibration From Rear Axle During Turns
- Key Programming, Security Pin Request, Pin Invalid
- Case assembly
- Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the...
- RA3 and RA4 GPS Calibration Update
- Flash: Transmission Control Module (TCM) Updates
- Revised Customer Satisfaction Notification VB3 ? Navigation Flash
- Repair Parts Used For Structural Repairs
- Authentic Mopar® Glass Replacement
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- RRT 19-090 (Service Bulletin 08-111-19) 2013-2018 Multiple Vehicles RA3/RA4 Radio GPS Certification Error
- RA3 and RA4 GPS Radio Update
- Radio, multi
- Flash Over The Air (FOTA) Software Update RA3 and RA4 Radio
- Radio [res]
- PadKit- Front Disc Brake
- Brake Transmission Shift Interlock (BTSI) Please contact Stacey Davis at (248) 260-6078 or...
- Mat Kit- Floor Front
- Bin- Storage
- Actuator-Multiaitr
- Warranty Operations Newsletter ? Volume 5, Issue 5
- Safety recall U74 & V44 ? tailgate latch (updated) wic article 2688- recall related damage 2015-2017MY ram...
- Sensor-nitrous oxlde
- Run-Front Door Glass
- Power Transfer Unit
- Molding-Wheel Plane
- Latch- Front Door
- Safety Recall V47 / the federal safety agency 19V-325 Backlite Glass Parts Ordering Information
- Damper-Steering
- Head-Cylinder
- Tube- Fuel Filler
- Vehicles Eligible For CSN U07 And V08, V11 or V16 Important Update To U07 Dealer Instructions
- Engine Oil- OW20
- Adapter
- Outlet- Air conditioning & heater
- Module-Parking Assist
- Tailpipe - exhaust
- Transmission ? With Torque Converter
- Power distribution center - intelligent power
- Panel Assembly-Door Trim
- Fascia - rear
- Ash receiver - instrument panel
- Warranty Operations Newsletter Volume 5, Issue 4
- Job aid
- Intake Grid Heater, Grid Heater Relay 2012
- USB Charging port.
- Flash: 6.7L Diagnostic and System Improvements
- Flash: 6.7L Diagnostic and System Improvements
- SCR Converter
- RA3 and RA4 Radio Over The Air Software Updates
- Rear Door Fixed Glass Cover is Loose
- Gap at Center Stack at the Instrument Panel
- EGR Cooler If a customer comes in with a check engine light for P0401, P2281 or P0234 and the,technician...
- Thermal Expansion Valve (TXV), H-valve For D trucks only; When diagnosing an A/C system leak at the TXV...
- This bulletin provides information regarding the latest Flash Over The Air update (FOTA) and provides a...
- This bulletin involves replacing the transmission assembly.
- Flash: Dosing Control Unit (DCU) Diagnostic and System Improvements
- Oil Pan 2012-2017 Cummins engines with oil pan leaks, please inspect the shallow area of the oil pan for...
- Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter...
- Rear Crank Shaft Oil Seal and Retainer Plate For Cummins equipped vehicles only; If you are working on a...
- Flash: BCM Diagnostic and System Improvements
- Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures...
- RA3 and RA4 Radio Enhancements
- Brake Pedal Sensor For vehicles with DTC's P0572 or C0042, or complaints of brake lights staying on or...
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Shop Certification Program Guidelines
- Door Hinge Assembly Side door hinge noisy
- Park Assist Sensor 1) Active or Stored DTC of Signal Shape / Waveform Failure fault: B128E-25, B128F-25,...
- Recliner
- Housing Assy
- Cover
- 04627694AA
- Molding Assy ?Frt door day light opening Rt/Lt: Return You have been identified as either having stock, or...
- Flash: Dosing Control Unit (DCU) Diagnostic And System Improvements
- Vehicle Restriction Program
- 55395241AG
- 04589131AG, 04589243AG
- Essential Flash Management
- RA3 And RA4 Radio Over The Air Software Updates
- Gasket, Rocker Cover If you are replacing this gasket for an oil leak, please call Steve Alvarado @ (866)...
- Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for...
- R4801865AC
- Flash: 6.7L Diagnostic And System Improvements
- Power Fold Rearview Mirror Prior to replacing this part for a loose mirror, please first follow this...
- Restraints Remove I-Sheet from packaging
- Diesel Exhaust Fluid
- Restraints Information Sheet (I-Sheet) has been added to Star Parts
- Customer Satisfaction Notification T13 Manual Transmission Shift Lever The manual transmission shift lever...
- DAPAP Requirements
- Flash: BCM Diagnostic And System Improvements
- Flash: Air Suspension Control Module (ASCM) System Enhancements
- Remote Start Antenna Replacement
- A/C compressor Before replacing the AC compressor for noise or in-op. call one of the individuals below.~...
- USB Charging Port Before replacing this part
- Flash: Radio Frequency Hub Module (RFHM) Enhancement
- RA3 And RA4 Radio Enhancements
- Rear Crank Shaft Oil Seal and Retainer Plate For Cummins equipped vehicles only;~ If you are working on a...
- Thermal Expansion Valve (TXV), H-valve For D trucks only; When diagnosing an A/C system leak at the TXV...
- Service
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Flash: Instrument Panel Cluster (IPC) Enhancement
- Transmission Torque Converter Replacement Due To Dislodged Snap Ring
- High Pressure Connector Tube/Fuel Injector For 2016 6.7 Cummins
- Intake Grid Heater Grid Heater Relay 2012
- Rear Crank Shaft Oil Seal and Retainer Plate For Cummins equipped vehicles only;~ If you are working on a...
- Inspect and Return: Lamp Assy
- Inspect and Return: Relay Assy
- P/n 68111384AB
- P/n 04573460
- 68103256AGReturn: Line Assy
- 68160775AB
- Transmission Torque Converter Replacement Due To Dislodged Snap Ring
- Rear Crank Shaft Oil Seal and retainer plate For Cummins equipped vehicles only;~ If replacing Rear Main...
- Housing: Oil Filter Adapter Cummins equipped trucks ONLY; If you are replacing the oil filter adapter as a...
- MY16 RA3 & RA4
- Flash: 6.4L Powertrain Diagnostic And System Enhancements
- Flash: Diagnostic And System Improvements
- Transmission Torque Converter Replacement After Drone Noise Verification
- Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable...
- Fan support assembly, fan support bearing, fan pulley if you are replacing this part due to fan hub...
- AS69RC transmission for dd, df, and dp models only; code P2757 tcc pressure control solenoid control...
- RamBox Lid Left Applique Loose
- Fan Support Assembly, Fan Support Bearing, Fan Pulley If you are replacing this part due to fan hub...
- AS69RC
- Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- Return: ALTERNATOR
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- 68085119AE,Inspect and Return: Exhaust Pipe Assy
- You have been identified as either having stock, or have stock in transit to your dealership
- Ignition Node Module Replacement
- Battery
- Hands Free Module
- A/C Compressor This applies to 2015 and 2016 UF and PF. Before replacing the AC compressor for noise,...
- Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold...
- Diagnosing A Urea Module That Is Exposed To Diesel Fuel
- Flash: 6.7L Diagnostic And System Improvements
- Power Fold Rearview Mirror Prior to replacing this part for a loose mirror, please first follow this...
- 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH...
- Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the...
- Center Console Lid Binding
- Flash: 6.7L Diagnostic And System Improvements
- Cable assy
- Cable assembly
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free...
- Subject: RA3 RA4
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- RA3 RA4
- Subject
- Subject
- Subject
- Flash: Air Suspension Control Module (ASCM) System Enhancements
- Headlamps May Be Out Of Adjustment Or Alignment
- This Bulletin involves updating the (ASCM) software.
- Headlamps May Be Out Of Adjustment Or Alignment
- Subject
- Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar...
- Flash: Radio Frequency Hub Module (RFHM) Enhancement
- Flash: Radio Frequency Hub Module (RFHM) Enhancement
- Symptom/condition
- Symptom/condition
- Center Console Lid Binding
- Roof Damage Repair
- This bulletin involves adding a rubber bumper to the console lid to prevent the lid from binding.
- The customer may describe scratches on the driver?s side of roof.
- Center Console Lid Binding
- Summary to be provided on a future date.
- Flash: 6.7L Diagnostic And System Improvements
- Diagnostic And System Improvements.
- Flash: 6.7L Diagnostic And System Improvements
- Flash: 6.7L Diagnostic And System Improvements
- Urea tank shell Trucks equipped with a 6.7L Cummins Turbo Diesel only; If vehicle comes in with a P207F...
- Actuator Motor, Front Axle Locker If you are replacing the front axle locker actuator on a D2, DD or DJ...
- Inspect and Return: Latch Seat, and Latch Seat Back You have been identified as either having stock, or...
- RE2 RE6 RB5 RB6
- Flash: 2.4L Powertrain Diagnostic and System Improvements
- Headlamp Bulb
- Rear Crank Shaft Oil Seal and retainer plate For Cummins engines only If replacing Rear Main Seal for oil...
- Sunroof Water Leak Replace sunroof glass to repair a water leak from the sunroof
- An insufficient urethane bead around the metal bracket results in water leaking into the vehicle at one or...
- This bulletin involves reprogramming the Instrument Panel Cluster (IPC) with the latest
- Powertrain Control Module If a PCM/ECM is being replaced due to liquid being present inside of the PCM/ECM...
- NAG1 (5A580)
- Radio Software Enhancements
- Flash: Transmission Shift And Drivability Enhancements
- Flash: 5.7L Diagnostic And System Improvements
- Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code
- Flash: Anti Lock Brake (ABS) Module System Enhancements
- Anti Lock Brake (ABS) Module System Enhancements.
- Flash: 6.4L Powertrain Diagnostic And System Enhancements
- Radio Software Enhancements
- This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest
- RA1 Radio Enhancements
- Title 68245351AB: Switch
- Title Filter
- Title 05182600AC: Molding Assy
- Title 68260866AB: Module Kit
- Title 68146401AA: Tube
- Title Control Module
- Title MasterShield Products Start Date: 10/28/2015 7:00 AM End Date Message You have been identified as...
- Title Inspection and Return: Hydro-Booster
- Ram 3500 pickup: customers may experience a malfunction indicator lamp illumination
- Flash: 6.7L Diagnostic And System Improvements
- Windshield Wiper Blade/Element Maintenance
- Title Win Kit
- Message You have been identified as either having stock, or have stock in transit to your dealership
- Title Latch Assy
- Title Inspection and return of PN 68210332AA
- Replacement Seat Covers And Seat Cover Repairs
- Inspection and Return: 68261532AA: Evaporator
- Molding Sill-Rear
- Inspection and Return: Motor
- Taillight.
- Mopar Trailer Tow Mirror Kit After installing the Mopar Trailer Tow Mirror Kit, configure the vehicle for...
- Spare Tire Kit For vehicles with Alloy Wheels, an adapter is required (not included) to connect the alloy...
- Stop sale
- 2014 KL 9-Speed service transaxle with 2015 common hardware This 9-speed transaxle must be ordered thru...
- Safety Recall R23
- RA3/RA4
- Inspection and Return:Brake Rotor-52121050AA
- Safety Recall R35 Reprogram Occupant Restraint Control Module
- HVAC Blower and Wheel HVAC blower motor is inoperative
- HVAC blower assembly Blower Motor either making noise or is inoperative (even intermittently)
- Inspection and Return:MOLDING ASSY-RR DOOR DAYLIGHT OPENING RT:04805838AD,MOLDING ASSY-RR DOOR DAYLIGHT...
- Tire pressure monitoring module Prior to replacing tire pressure monitoring module, for DTC's C151D,...
- Inspection and Return: Brake Rotor
- Shifter
- Fuel tank Before replacing this part, please call Keith Kerby on his Cell (248) 420-5540 OR Manuel Gandara...
- Headlamp Assembly If the headlamp assembly is being replaced, please also replace the harness attached to...
- Inspection and Return: Brake Rotor
- Compressor HVAC compressor is inoperative
- Power Transfer Unit Prior to replacing the PTU, please review the following .~ Check if the service 4WD...
- Inspection and Return: Brake Rotor
- Camshaft Position Sensor If replacing a camshaft position sensor for P0340 and/or P0344 fault codes,...
- Crankshaft Position Sensor Before replacing this part due to a P0335 fault code, please contact Andrew...
- Cruise Control Switch Before ordering or replacing this part please contact Dennis Gauthier at cell (248)...
- Battery Please call Bob Horn at cell (248) 231-3315 prior to replacing any battery
- Bumper Step Pad
- Radiator If vehicle comes in for transmission fluid leaking from trans-oil cooler fittings on the...
- Return: Molding Kit
- Pump
- Camshaft Position Sensor If replacing a camshaft position sensor for P0340, P0344, P0345, P0349, P0365,...
- Evaporative System Integrity Monitor switch (ESIM) Prior to replacing this component on a 2015 Dodge...
- Element Assy- Heated Seat If any of the Front Heated Seats are Inoperable
- Warranty Operations Newsletter Volume 1, Issue 6
- Seat belt retractor
- STAR receives on average 1,000 contacts per day ? that?s 300,000 annual contacts for technical assistance
- 82212076, 82203694
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ram 3500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history