Our driver told us that he lost steering. At 35 mph on a open highway (which is confirmed by our gps). He also has a clean driving record and has been driving box truck for decades with no incident. Once steering was lost the box truck to slam in into the barrier twice , than roll onto its side. There where no other cars involved in the accident and the truck is now totaled. There is so much damage done to the truck it is hard to pinpoint the failure point. The center link is broken and the tie rod end is snapped off. The truck only has 38,000 miles on it. The air bags weren't deployed and the driver had to be pulled out of the truck. The police confirmed the steering failure point on the police report. There was no warning of the failure. Until the accident.
The worst 2022 Ram 5500 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Transmission21
- Steering3
- Fuel system2
- Acceleration1
- Electrical1
- Wheels1
Specific symptoms reported on the 2022 Ram 5500
Recalls 4
Steering: steering control module
- What is wrong
- Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
- Risk
- A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
- Remedy
- Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800‑853‑1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on beginning November 13, 2025.
Recall number 25V765000 · Recall details
Electrical system: wiring: relays/solenoids
- What is wrong
- Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.
- Risk
- An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.
- Remedy
- Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1‑800‑853‑1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V‑798.
Recall number 23V060000 · Recall details
Engine and engine cooling: engine: engine control module (ecu/ECM)
- What is wrong
- Chrysler (FCA US, LLC) is recalling certain 2022 Ram 3500, 3500 Cab Chassis, Ram 2500, and 4500 and 5500 Cab Chassis vehicles equipped with Cummins 6.7L turbo diesel engines. The engine control module (ECM) may have been built with a misaligned capacitor that can short-circuit, resulting in an internal loss of communication.
- Risk
- An internal loss of communication can result in a loss of drive power, increasing the risk of a crash.
- Remedy
- Dealers will replace the ECM, free of charge. Owner notification letters were mailed October 20, 2022. Owners may contact FCA US, LLC customer service at 1‑800‑853‑1403. FCA US, LLC's number for this recall is Z87.
Recall number 22V642000 · Recall details
Electrical system: wiring: relays/solenoids
- What is wrong
- Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.
- Risk
- A vehicle fire increases the risk of injury.
- Remedy
- Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (the federal safety agency Recall ID 21V‑163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1‑800‑853‑1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.
Recall number 21V798000 · Recall details
See all 4 recalls for the 2022 Ram 5500
Defect investigations
2022 RAM Transmission Snap Ring Failure
The Office of Defect Investigations (ODI) has received 82 complaints alleging loss of motive power due to an internal transmission failure of the K1 snap ring in model year 2022 Ram 3500, 4500, and 5500 vehicles. Of these complaints, 16 describe a complete loss of motive power at speeds greater than 25 miles per hour, without the ability for the vehicle to resume normal operation. The subject vehicles can be up-fit as an ambulance and other emergency response vehicle or may be heavily loaded when used for towing. During the failure event, the snap ring becomes dislodged and forward gears 1-4 are no longer functional, potentially leaving the vehicle disabled in or near the roadway and/or negatively affect the emergency mission. ODI contacted the manufacturer, FCA US, LLC d/b/a Stellantis North America (FCA), and learned that technical service bulletin (TSB) TSB-21-002-23 is related to the alleged defect condition. Additionally, FCA has conducted dynamometer and field testing and has explained to ODI that during the event a warning message will display to the operator, and gear 5 and reverse will remain available. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to
PE24009
Technical service bulletins for the 2022 Ram 5500 436
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- D-25-18 (XW1)
- ID-25-15 (XW1)
- FCA Caribbean Warranty Newsletter – Volume 11, Issue 6
- FCA Caribbean Warranty Newsletter – Volume 11, Issue 4
- Warranty Newsletter – Volume 11, Issue 4
- Warranty Bulletin D-24-16 (XR1) Urea Delivery Module – Select 2019
- WARRANTY BULLETIN D-24-15 announces the addition of the Rear Axle Assembly replacement for 2019
- FCA Caribbean Warranty Bulletin ID-24-16 Rev. Announces the addition of the Rear Axle Assembly replacement...
- Cummins 6.7L Air Filter Replacement For DTC P0299 Customers must experience a Malfunction Indicator Lamp...
- Radiator - engine cooling
What 2022 Ram 5500 owners say
Most recent owner complaints, unedited.
Dealership confirmed K1 and K2 snap ring failure on a 22 Dodge Ram under warranty with 15933 miles. Transmission was manufactured in August of the truck build. On [XXX] while driving my 22 Ram 5500 the truck lost all forward gears while coming down the mountain with a loaded truck camper and pulling a trailer with an ATV. Truck was below GVWR. This truck had 15933 miles and 24 months old. All servicing intervals were met and serviced at a certified Dodge dealership. The truck was traveling at 25 MPH down hill in steep terrain on a dirt road. The exhaust brake and tow haul mode was selected and operational. The vehicle shuddered and made a thump and had an associated check engine light with an Adaptive Cruise Control caution indication. The vehicle started to rapidly speed up downhill and I gently applied the brakes to regain control. I coasted approximately 2 miles to find a safe pull off point in the mountains with no forward gears. After the vehicle was safely stopped I was able to confirm the malfunction with no forward gears and reverse only. I was fortunate to be able to flag a ride after hiking out to the [XXX] to get my wife and I out of the National Forest and get cellular service. The nearest service provider was the Ram dealership in Lewiston Idaho. I made arrangements and the Truck was delivered the next day by a semi tow vehicle. We incurred a two night stay at the Hampton Inn to get repairs lined up and arrange travel home. After multiple conversations with the dealership and a trip down there to discuss the issue with the dealership they finally diagnosed and fixed the problem after 33 days sitting on the lot. The truck was delivered back to me on 9 October. The diagnosis of the K1 and K2 snap ring poses a serious safety issue for owners and operators of this vehicle. This malfunction caused some significant financial burden as well due to the truck being inoperative and away 140 miles from home. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(
The contact owns a 2022 Ram 5500. The contact stated while driving at approximately 40 MPH, the vehicle was losing forward momentum. The contact stated that the check engine warning light was illuminated. The contact depressed the accelerator pedal and the engine was revving but the vehicle was not gaining any forward momentum. The contact pulled the vehicle over and turned the vehicle off and on, however, when the contact had shifted the vehicle into drive (D) the vehicle was not moving. The contact determined that he only had reverse (R) gear functioning. The contact had checked online and read that he would be able to manually shift to 5th gear. The contact was able to return to his workplace and had the vehicle towed to a local dealer. The vehicle was diagnosed and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The contact had researched online and related the failure to the federal safety agency Action Number: PE24009 (Power Train). The manufacturer was not informed of the failure. The failure mileage was approximately 105,000.
The contact owns a 2022 Ram 5500. The contact stated while driving 50–55 MPH, the vehicle lost motive power due to the transmission failure. There were no warning lights illuminated. The vehicle was towed to the local dealer but was not diagnosed or repaired. The vehicle was towed to another local dealer, Speck Chrysler Jeep Dodge Ram (125 E Allen Rd., Sunnyside, WA 98944), where it was diagnosed that the snap ring was fractured. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the local dealer for assistance. The failure mileage was approximately 8,000.
The transmission failed at approximately 3000 miles. Reverse was the only gear to function properly. The truck has been at the dealership for over 2 months and they have not fixed it yet.
K1 snap ring failure
This is a 2022 Dodge Ram 5500. The wheel studs broke off while driving on the interstate, and the dually tires came off. This is a major safety issue and the driver had a narrow escape. This same issue persisted through the 2012-2021 model years and RAM had a recall (Y26) for those years. I do not believe the issue has been fixed for the 2022 model year. When I asked RAM for reimbursement for the replacement studs and labor, they turned it down saying my model year was not on the list I am looking to escalate this matter before someone else gets impacted by this issue.
Truck has 6500 miles, went to put it in reverse from drive in busy intersection and transmission started to slip. Truck ultimately wouldn't drive at all. Started throwing codes (P0731-00 in particular) and found out that it needs a new K1 clutch snap ring repair. There are more than 300 people with this issue, this has not only happened with me from my research on forums about this code being thrown. This is a 2022 with 6500 miles, there are too low of miles on this truck for it to be having a problem like this!
The contact owns a 2022 Ram 5500. The contact stated while driving 50 MPH, the vehicle lost motive power, with the 4-WD unavailable message displayed. Additionally, the check engine warning light was illuminated. The vehicle was towed to the dealer and the contact was informed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 1,973.
The contact owns a 2022 Ram 5500. The contact stated while driving at an undisclosed speed, the vehicle failed to shift into the intended gear, and started to coast while the accelerator pedal was depressed. No warning light was illuminated. The contact stated that he veered off the roadway to safety and notified a towing company. The vehicle was towed to the dealer where it was diagnosed that the snap rings failed and needed to be replaced. The contact stated that he had previously informed the dealers of TSB: 21-002-23 but was informed that the vehicle needed to experience a complete failure to receive the repair under the TSB. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 1,000.
Compare the 2022 Ram 5500
Other model years
Questions about the 2022 Ram 5500
Is the 2022 Ram 5500 reliable?
Owners have filed 26 complaints about the 2022 Ram 5500, 2.0 times a typical 5500 model year.
What is the 2022 Ram 5500 year score?
The 2022 Ram 5500 scores 48 out of 100 (below average). The score compares it with the other model years of the Ram 5500: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2022 Ram 5500?
Transmission and drivetrain, with 21 complaints, typically around 8,000 miles. Next is steering (3).
How many recalls does the 2022 Ram 5500 have?
4 recalls, covering steering, electrical system and engine and engine cooling.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Ram 5500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history