2016 Toyota Highlander problems

Filed Oct 1, 2026 · Seat belts · MA · 1 injury

The component involved was the vehicle's seat belt/restraint system. While my daughter was wearing the seat belt, it became stuck around her waist/abdomen and became extremely tight. The belt continued to tighten and would not loosen or release normally. The seat belt had to be cut in an emergency to free my daughter. My daughter was sitting in the second row to the right. The seat belt became stuck and extremely tight around her waist/abdomen. After she moved the shoulder portion of the seat belt behind her shoulder and then unbuckled the seat belt. Even after she unbuckled it, the belt did not loosen or release. Instead, belt continued retracting/tightening and pulled her body upward toward the seat-belt anchor point. It pulled her upward until her stomach/abdomen was near the point where the seat belt comes out of the vehicle. Her neck/head became pressed against the vehicle roof, her feet remained on the seat, leaving her body hanging from the belt. She was screaming that she could not breathe. We had to cut the seat belt off to free her then took her to ER Due to visible bruises. The problem has NOT been reproduced or confirmed by a dealer or independent service center. I contacted IRA Toyota dealer @ Danvers Mass and specifically requested that they inspect the seat belt, but they refused. I also contacted Toyota Corporate and requested an inspection, but they refused because the vehicle is outside of its warranty period. The vehicle/component has NOT been inspected by the manufacturer, dealer, police, or insurance company, to my knowledge. Toyota Corporate and the dealer were notified of the incident but did not inspect the seat belt. There were no warning messages that I noticed before the incident. The first symptom was when the seat belt became stuck and began tightening around my daughter's waist/abdomen. The belt continued to tighten and could not be released normally. UNKNOWN as to what caused the seat belt to malfunction.

Filed Sep 10, 2026 · Lights · 70,200 miles · MS

The contact owns a 2016 Toyota Highlander. The contact stated that while the vehicle was parked, the rear taillight covers cracked due to the high outdoor temperatures, and there was condensation inside the taillight housing. The vehicle was taken to a dealer where it was determined that the rear taillight covers needed to be replaced. The vehicle was then taken to an independent mechanic, where it was determined that the rear taillight covers needed to be replaced. The failure mileage was 70,200.

Filed Feb 22, 2026 · Steering · GA

Steering column can become worn prematurely causing loose steering and possibly loose control

Filed Feb 5, 2026 · Steering · FL

I was on Hwy 27 headed south bound at Bellecita Rd in Davenpoerrt, Fl. This is a busy four way intersection. I moved into the left hand turn lane. When the left turn green light came on I began my U-Turn to head north bound. The steering wheel would not respond to my input and the vehicle kept going straight into oncoming traffic. It took a great deal of bodily force to get the vehicle to respond. When it did respond there was loud popping noise. I had noticed in the past, that when Iwas turning or changing lanes on the hwy, the steering had a small glitch before it centered. I thought this was strange but figured this was normal for this vehicle. This incident left me badly shaken. I thought for the grace of God that I was not involved in a serious , possibly deadly accident. I've lost my confidence in the vehicle and the brand. I will be taking it to a Toyota dealer to get it diagnosed the first chance I get.

Filed Jan 20, 2026 · Transmission, Wheels · MA · crash

I was driving on a 2-lane road early in the morning with light snowfall. There was about 1" of snow on the road, with the roads not yet plowed or treated as it was the beginning of the snowfall. About 15 minutes into my trip, I was on a relatively flat and straight stretch of the road and let up on the gas paddle to avoid going too fast -- was probably traveling ~35 mph. Although the road was straight and flat at that point, my car suddenly started fishtailing, slowly turned 180 degrees and sliding to the other side of the road, ending up on the opposite edge of the road. When it hit the edge of the road, it tipped over on its right side, as apparently the dirt at the edge of the road was not as slippery as the road, and the SUV having a high center of gravity. Since my car was an AWD hybrid vehicle, I believe that the triggering event was the vehicle shutting down the gas engine and switching to EV mode when I started coasting (that usually happens when I'm driving <40 mph and the vehicle is sufficiently warm). But I did not look at the dashboard to see if the EV mode switched on at that point. In addition, while I did not sense any skidding prior to this event, it's possible that there may have been a slick spot right at that point in the road. But it seemed to me that when the power to the front wheels was reduced from the gas engine shutting down (as I believe was the case), the transition to electric motors taking over the front drive created some perceived traction issues which triggered the electric motors in the back to try to compensate for the perceived traction issues in the front. But the rear drive ended up creating a significant differential where the right rear wheel was driving much harder than the left rear wheel, creating the car spin and slide, which the traction control did not correct. I did not apply the brakes nor gas once the car started skidding. The car was 10 years old and was a total loss as a result of tipping on its side.

Filed Nov 20, 2025 · Tires · WI

**Nature of Safety Defect Within 13,000 miles of normal mixed highway and light off-road use on a Toyota Highland, one tire developed a sidewall bubble and all four tires exhibited extreme and uneven tread wear—far below the advertised 50,000-mile treadwear warranty. The remaining tread depth on all four tires is already under 2/32" in multiple locations, with severe cupping and feathering that makes the vehicle vibrate violently above 50 mph and causes unpredictable handling, especially in wet & snowconditions. These conditions render the tires objectively dangerous and unfit for continued highway or street use. Manufacturer Response Pirelli warranty claim #2194927 was summarily denied as “impact damage” with no physical inspection. Pirelli has refused any prorated adjustment, replacement, or refund, and has kept possession of the failed tire. On November 17, 2025, Pirelli Consumer Affairs closed the case stating: “Pirelli considers this claim to be closed and will not take any further action regarding the claim or the subject tires.” Request to the federal safety agency I am asking the federal safety agency to open a formal defect investigation into the Pirelli Scorpion All Terrain Plus line for: Premature and excessive tread wear (tires effectively worn out in under 13,000 miles vs. 50,000-mile rating) Widespread reports of sidewall bubbles and sudden structural failures Potential violation of Federal Motor Vehicle Safety Standards relating to tire strength, endurance, and treadwear labeling (49 CFR Part 571.139 and Part 575) These tires present a clear safety hazard—severe uneven wear and structural defects can lead to loss of vehicle control, hydroplaning, or catastrophic blowouts. Hundreds of owners have posted identical failures online in the past 18–24 months. Please investigate this tire model for possible safety recall or enforcement action. I am happy to provide the tires, in

Filed Oct 27, 2025 · Airbags · WA · crash · 1 injury

I was traveling on an interstate going home from work. My speed was approximately 65mph. I noticed traffic slowing up ahead. I began to drop my speed (cost down), as I was approaching the traffic the car in front of me was applying their brakes; I had already began to apply mine. I was applying more pressure to my brakes to slow down more as the person in front of me began to slow more quickly. The person in front of me then had to slam their brakes on and I was not able to stop in time to avoid collision with the car in front of me. That driver did not come in contact with any other vehicle. The impact was at approximately 50mph. I was then very quickly hit from behind by the car behind me. The vehicle behind me hit of center and more on the right back corner of my car. My vehicle sustained significant front-end damage; the hood was folded, the grill was gone, the radiator was pushed back. As I looked up after the impact and saw my hood folded I then noticed that my air bag had not gone off. How could the air bag have not gone off in an impact such as that. My safety was compromised by the possibility of hitting the steering wheel or worse such as impacting the windshield if the crash had been worse. I do not remember if my vehicle had side curtain air bags as well. NO air bags deployed. Law enforcement was called by the driver of the car I rear ended as we agreed that she would. The driver of the vehicle that hit me I believe also called 911. Highway Patrol responded along with state incident response vehicles to protect the scene. I have filed a claim with my insurance, and the vehicle was looked at and deemed a total loss. It is not available for inspection and was taken to a salvage yard per the insurance company. I did not notice any lights on on the dash after. I also did not encounter any issues before this. I had the vehicle just over a year.

Filed Aug 15, 2025 · Tires · CA

P245/55R19 103T Nitto Crosstek2 BW. Vehicle pulls to different directions when the tires are cross swapped. I have taken the vehicle to 4 to 5 wheel alignments within 3 months and 3 different shops after the purchase of the tire. Recently I took the vehicle Big O Tires and they _verified the tires have "Radial Pull" / Tire Conicity due to Manufacturing Defect of the a belt separation within the tire's structure. _The shop also verified that the alignment is performed correctly. I believe those tire are unsafe and they could fail suddenly causing crash.

Filed May 13, 2025 · Driver assistance · MD

On multiple (3-5), but not all, occasions at the same location my pre collision warning and automatic breaking appear to have been triggered as I approached an expansion plate at the edge of a bridge. The pre collision warning sounded, then the brakes were automatically applied. After a few seconds the braking stopped and my car proceeded normally. If a car had been following closely I may have been struck in the rear.

Filed Jan 13, 2025 · Tires · 61,000 miles · GA

The contact owns a 2016 Toyota Highlander equipped with Cooper Tires, Tire Line: Evolution H/T, Tire Size: 245/55/R19, DOT Number: UPPIILE. The contact stated that while his wife was driving approximately 55-65 MPH, the rear driver's side tire unexpectedly had a blowout. The contact's wife pulled over to the side of the road. The contact arrived on the scene and replaced the rear driver's side tire with the spare tire. The vehicle was taken to a tire retailer, where it was determined that the tire blowout was caused by a road hazard. The tire was not replaced. The tire manufacturer was made aware of the failure. The tire failure mileage was 30,000. The vehicle failure mileage was 61,000. The VIN was unavailable.