2004 Toyota Tacoma body problems

Filed Mar 25, 2026 · Body · CT

Immediately after the manufacturer recall requiring full frame replacement (completed November 2017 by the same dealership referenced below), the vehicle developed abnormal handling not present before the repair, including improper tracking and rear end instability. No warning lights/diagnostic messages were present. These issues were reported to the servicing dealership within weeks and repeatedly over the following years. Despite multiple short initial inspections and two extended service periods—totaling approximately fourteen months in the dealership’s possession—the dealership repeatedly reported no defect found and continued to advise that the vehicle was safe to operate. Due to ongoing safety concerns, an independent inspection was recently obtained. It confirmed measurable rear axle offset and a thrust angle deviation outside acceptable tolerances. The defect is visually apparent: the rear wheels are not symmetrically aligned, and the vehicle exhibits a noticeable “crab walking” effect when viewed from behind. The root cause remains undetermined and would require further diagnostic work and significant disassembly. All documentation and inspection findings are available upon request. Safety risk: The vehicle does not track correctly and shows instability, especially in low traction conditions such as rain or snow, increasing the risk of loss of control. The manufacturer has been formally notified through repeated outreach, including ongoing contact with the Brand Engagement Center since December 2025 and multiple certified letters to Toyota North America Legal/Consumer Affairs between January and March 2026. The only response received was a generic statement from the Brand Engagement Center indicating that the vehicle is out of warranty and an offer to return it to the same dealership that performed the frame replacement and failed to identify the defect. No other response, investigation, or resolution has been provided by Toyota North America.

Filed Sep 18, 2025 · Body · NH

The frame broke

Filed Dec 16, 2024 · Body, Suspension · NY

The vehicle has an open recall (the federal safety agency Recall #12V542) for the spare tire carrier lift plate. I brought the vehicle to a Toyota dealership to have the recall addressed, but the dealership refused to perform the repair, stating that the frame is too rusted to proceed safely. They recommended a full frame replacement due to severe rust damage, which includes holes and significant structural weakening. Toyota has refused to provide a replacement frame under any existing recall or warranty program. This means the recall cannot be completed, and the vehicle remains unsafe to drive. Additionally, I cannot locate a replacement frame for this vehicle through Toyota or the aftermarket, leaving no practical solution to address the safety risks. The refusal to honor the recall and the lack of available replacement parts put me and others at significant risk. The problem has been confirmed by the Toyota dealership during inspection, and the rust damage makes the vehicle structurally unsound. The unresolved recall, combined with the excessive frame rust, has created a double safety hazard that needs urgent resolution

Filed Jan 30, 2024 · Body · WI

Vehicle was taken to dealer with frame rust, crack and holes. Toyota refused to fix , repair or offer parts to repair.

Filed Mar 23, 2023 · Body, Suspension · 51,641 miles · WI

The contact owns a 2004 Toyota Tacoma. The contact had taken the vehicle to Kolosso Toyota (3000 W Wisconsin Ave, Appleton, WI 54914) to have his exhaust replaced. While there, he was informed that the entire sub frame was corroded with several cracks and holes had formed around both front leaf springs. The mechanic informed him that the vehicle was unsafe to drive due to the failure. Prior to the failure, the contact took the vehicle to another local dealer where the vehicle was inspected under the federal safety agency Campaign Number: 05V225000 (Suspension). The contact was informed that a special coating was sprayed onto the sub frame to prevent corrosion; however, the recall remedy failed to prevent the corrosion. The manufacturer was contacted but provided no assistance. The vehicle was not repaired. The failure mileage was 51,641.

Filed Mar 12, 2023 · Body · CT

Bought the vehicle in May 2022 from a dealer. By November of 2022 it was discovered that the frame was totally rusted. The dealer won't help so I paid $10,000 for a truck that lasted 6 months. I then found out this was a common problem that Toyota knew about so I called them for assistance. They would not help. I have been renting a vehicle at a cost of $800 a month because I don't have the money to buy another vehicle.

Filed Feb 16, 2023 · Body · IN

What component or system failed or malfunctioned, and is it available for inspection upon request? The whole frame, the chassis, it is rusty specially in the front How was your safety or the safety of others put at risk? when the rusty becomes worse, it will compromise the entire vehicle estructure, even the suspension and wheel parts. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, I can see Toyota run a recall process until 2019 Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, just regular shop service, on which they reported high damage for the suspension and frame parts. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?. It is making bad noises and suspension parts are difficult to replace

Filed Jan 13, 2023 · Body, Electrical · 150,000 miles · VA

The contact owns a 2004 Toyota Tacoma. The contact stated while driving 20 MPH and making a right turn, the vehicle lost motive power and stalled. There was no warning light illuminated. The contact was able to veer to the side of the road. The vehicle failed to restart after several attempts. The vehicle was towed to the dealer, where it was diagnosed that the Electronic Fuel Injection (EFI) main fuse had blown due to a short circuit. The dealer replaced the Electronic Fuel Injection (EFI) main fuse; however, the failure persisted. Additionally, the dealer diagnosed that the subframe was severely corroded, including transmission components and fuel system components. The manufacturer was notified of the failure and informed the contact that they could not assist as unknown recalls had expired. The vehicle was not repaired. The failure mileage was approximately 150,000.

Filed Dec 6, 2022 · Body · NY

Frame is badly rusted as a result truck is not driveable..

Filed Oct 31, 2022 · Body · 176,000 miles · FL

The contact owns a 2004 Toyota Tacoma. The contact stated that while looking underneath the vehicle, he noticed that the subframe was rusted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 176,000.