The contact owns a 2004 Toyota Tacoma. The contact stated upon taking the vehicle to an independent mechanic for a tire replacement, he was informed that the passenger’s side subframe was severely corroded. The contact notified several unknown dealers of the failure. The dealers informed the contact that there was no recall associated with the VIN. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 233,000.
2004 Toyota Tacoma body complaints
Page 2 of 8: complaints 11 to 40 of 203, newest first, as owners wrote them.
Excessive Corrison through out the frame.Was informed bu certified mechanic really it is unsafe to drive. What can I do I still owe money on this vehicle.
Financed a 2004 Toyota Tacoma and found that frame of truck is rusted out and not sure what to do, can't afford new frame and still owe a little over 9 grand for it....please advise what to do next. Thank u
The frame has rusted and broke behind the cab
The contact owns a 2004 Toyota Tacoma. The contact stated that the underside of the vehicle started to flake and fall off in pieces. The vehicle was taken to a local dealer where it was diagnosed with needing the frame replaced however, the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 165,000.
Frame rust
This vehicles frame has rusted and broken. I feel lucky to have made it home just as the frame cracked wide open on one side making the truck un-drivable. Had this happened on the freeway or somewhere out in a rural setting I may have been killed, caused a problem for other drivers or been stranded away from any help. I have sent a photo of the damage to a frame shop but an independent inspection is not, in my opinion, needed since the rusted, broken member is clearly visible to any lay person. There were no warning lights or anything associated with this problem. What I did feel was some serious shaking and bumping as I moved down the road toward my house.
2004 toyota tacoma. Constituent writes regarding a cracked frame on vehicle. *ld the consumer stated the manufacturer was notified but, denied any assistance. The consumer stated the manufacturer advised there was a recall in 2010 that expired in 2019. The previous owner did not have the repair completed.
Frame rot on the mid chassis up to the front chassis where the frame begins to curve inward towards the engine. Frame rot is on left and right side of the vehicles inner frame. Failed state inspection.
Called toyota 2 years ago about rust on my trucks frame near the rear leaf spring mounting area. Was blown off by toyota customer care. In december was driving and the frame rails literally snapped an bowed, the only thing that saved my life while driving 70mph, on the interstate 70 between hagerstown md and hancock md, home from work was the bed contacting the cab of the truck and miraculously holding holding it up and allowing me to get it safely off the road and call my mechanic. The sheet metal of the truck is rust free and in good condition. The frame is a total loss. The truck was at toyota in 2010 and 2011 for frame inspections. This is a known issue with these trucks and now im told that toyota wont do anything about it. If they would have fixed it or addressed my concerns in 2018 or even 2019 I wouldnt have nearly crashed my truck. The idea of a safety campaign is that they know there is an issue, their was a class action suit, they have frames available and they need to replace my frame on my truck and make it safe again. It is the only truck I have I used it to take care of my dogs and my the roads to my home are very steep and a 2wd or front wheel drive will not make it in snowy or rainy weather. Toyota's case # is 2102242008, phone number to call is 1800-331-4331.
Re: defective frame on 2004 toyota tacoma extend cab dear sir or madam: I am reaching out to you for assistance regarding the defective frame on my 2004 toyota tacoma extended cab. I purchased this vehicle used in 2012 from a private owner. I did not know at the time, nor did the previous owner advise me that he received a manufacturer's recall on the truck from toyota in 2010 regarding a cracked frame because the vehicle was not treated during manufacturing to prohibit rust corrosion. Please see attached letter.
2004 tacoma frame so rotted that upon hitting a large hole would finish off the rusted frame. This type of rust and erosion is not from normal wear.. This is due to the manufacturing of the vehicle and they will not replace. They say they are aware of it.. But time lapsed to get it fixed?? So what now I am out $15k on a 16 year old truck. Since when did recalls have an experation date??
Purchased 2004 tacoma in 2016. Dealership of purchase said vehicle was not affected by frame recall and did not inform me that it was under warranty for frame related issues. Since purchasing vehicle I've encountered countless frame related issues and have put thousands into frame related repairs. I contacted toyota in 2018 on several occasions to ask about frame warranty. Toyota said vehicle was not covered. Did not look up VIN or any other information related to vehicle. I contacted toyota again this year to see if there's anything that can be done as frame issues were becoming significant and beyond my financial means to keep fixing. Toyota notified me at this time that the vehicle had in fact been under warranty but that now the warranty had expired 6 months prior (which was within the timeframe that I had initially contacted toyota). Toyota told me that frame had been undercoated with corrosion resistance treatment in 2010 and warranty was good for 10 years (until 2020). Because dealership of purchase failed to comply with a warranty letter and toyota also failed to notify me as I was not the original owner, I was not aware that I could have had the frame fixed. Which I would have if I had known. Now because of no fault of my own, the warranty window has closed and toyota is not willing to rectify the situation. I still owe over $3k on a vehicle I paid over $11k for and have put $4k-$8k into for repairs. Frame is rotting faster than I can fix it and is now unsafe to drive and ineligible for trade-in or sale because the vehicle is essentially worthless at this point. Frame bolts are now rotted, tailpipe and exhaust fell off just this morning due to corrosion, suspension is corroded, brackets are rotting off frame, flakes of corroded metal are in piles beneath vehicle- and these are just the most recent issues.
Tl* the contact owns a 2004 toyota tacoma. The contact stated that approximately 12 years the vehicle was treated with a rust inhibitor however, the subframe was severely rusted. Additionally, there were several rust holes to the subframe. The contact contacted toyota of vineland (650 n delsea dr, vineland, nj 08360, (856) 559-7690) who stated that they were unable to provide the repair under a recall. The dealer also stated that the subframe needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the issue and opened a case. The approximate failure mileage was 120,165. *ln the consumer submitted photos.
My 2004 toyota tacoma has frame damage underneath (picture enclosed) I learned of a 15 year manufacturer extended warranty on the frame of my truck within the last few months. I put in a complaint to toyota (I lost claim number) and was told the warranty had expired in may of 2019 and was out of luck, he also said that 15 year warranty extension were mailed out in the past but ,trouble is my wife and I do not recall seeing this information do to this I was unable to get my frame fixed under the warranty and I cannot afford out of pocket fee to fix myself. What issue I do have is I had my vehicle at a toyota dealership being worked on for a "safety recall " july of 2018 and I was wondering at least as a customer courtesy why I wasn't made aware of this frame recall while under repair for the safety recall, I would have got the work done had I known and as stated earlier known by receiving information in the mail about this. The toyota rep said since it expired I was out of luck and that is why I'm reaching out to you about this matter.
Tacoma purchased feb.2019 with some rust found on frame.truck sent to body shop apr. 2020 to address rust.truck had become unrepairable due to "severe rust in multiple locations on frame","rust holes and cracking bad on driver side frame near fuel tank" and "frame is rusting bad from inside out"(quotes from mechanic). Truck will not pass inspection.
Tl* the contact owns a 2004 toyota tacoma. The contact stated that while in for inspection it was discovered that the front driver side sub frame of the vehicle had sustained severe rusting and corrosion. The vehicle was deemed unsafe to drive and failed the state inspection. The cause of the failure was not determined. The local dealer was not notified. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 150,000.
Tl* the contact owns a 2004 toyota tacoma. The contact stated that upon inspection of the vehicle, it was discovered that the undercarriage showed extensive corrosion to the sub frame of the vehicle. The vehicle was taken to two independent mechanics who informed the contact that they were unable to fix the sub frame of the vehicle. The manufacturer was contacted and the contact was informed that the prior owner declined to have the corrosion repaired on the vehicle. The vehicle was not repaired. The failure mileage was 141,000.
Frame and some associated components are rusted almost thru. Truck appears to be very unsafe. Toyota does not show it in recall list. Please help.
2004 toyota tacoma frame issue frame was inspected and passed they said they would contact me when it was time to seal it but never did when I went back they said I was too late and only fixed tire carrier recall. Now frame is rusting out had to be repaired and toyota said it's my problem and they won't give me the extended 15 year warranty I contacted them last year and again this year
Through no fault of our own, the frame on our toyota truck has been discovered by our mechanic as rusted or corroded to an extend of unsafe driving conditions. Toyota in response to my complaint replaced the spare tire carrier as a safety recall that never expires, however, they are telling me the frame is no longer under a warranty and is not a safety recall issue. The suggested I lodge a complaint with the federal safety agency as they are unable and unwilling to do something for us. I uploaded 5 pictures, not sure if they are all there
Tl* the contact owns a 2004 toyota tacoma. The contact received a recall notice for the federal safety agency campaign number: 12v542000(suspension). The contact took the vehicle to cumberland toyota (1540 interstate dr, cookeville, tn 38501, (931) 272-3719) and was informed that her vehicle did not need a remedy and was safe to operate. The contact took the vehicle back to the same dealer a few years later and was informed that the vehicle would not be serviced due to the corrosion that had accumulated. The manufacturer was notified of the failure and informed her that they could not assist. The vehicle had not been repaired. The failure mileage was unknown. *pm
Extreme rust on left side of the frame with extensive loss of metal. Contacted two toyota dealerships and toyota corporation. They refuse to fix the problem. All documented here: https://www.facebook.com/groups/1637547983201647/
The frame has many holes in it. Was just told by mechanic when went in for rear differential work. They as I were surprised as the body shows no signs of rust. They did not complete work as they said frame so bad it is unsafe. I have owned other 2003 and 2004 tacoma's over the years which had frames recalled. This one does not have the frame recall and I am wondering is this a mistake or why not?
Frame is rusty beyond usage. As I accelerate the bed of the truck flexes so I can see it in the rearview mirror
The frame is rusting out
I had tires rotated,technician told me frame is extremely rusted(tacoma problem) big safety problem.toyota told me they would check it out for 98,-- dollars. I don't think that's right. Toyota problem
The dealer discovered holes in the frame on 3/26/19. Actually it was in for repair of a gas tank strap and I believe they used a hammer on the frame to make the holes. They wrote it up as my truck was unsafe to drive. It only has 81,000 miles on it and other wise in great shape. I had it in for a recalled rusted spare tire holder on 2/11/15 and the service manager told me that the frame looked ok and if the frame develops holes they can recommend a good welder.
Tl* the contact owns a 2004 toyota tacoma. While the vehicle was undergoing an oil change, the contact was informed that the frame was rusted. There were no warning indicators illuminated. The vehicle was taken to autoland (170 us-22, springfield township, nj 07081, (800) 288-6526) where it was confirmed that the frame was rusted. The vehicle was not repaired. The manufacturer was contacted and provided case number: 1904301385. No further assistance was provided. The failure mileage was 67,000.
Takata recall, I own a 2004 toyota tacoma that came from west virginia when originally purchased, this trucks leaf springs have now broke lose and is very unsafe to drive for my 17 year old son, we have contacted toyota and they were very rude so I have now came to this, there is rust holes in the frame of his truck the size of baseballs and scares me for him to ever drive it at all please help us figure out what we can do, his uncle that owned the truck before we got it was very sick he lived in west virginia and was never told or called about a recall for the frame my son just recently got the truck painted and was told that he needs a new frame very badly.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Toyota Tacoma?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history