Tl* the contact owns a 2004 toyota tacoma. The contact noticed that the rear frame of the vehicle was corroded. The vehicle was taken to a dealer. The technician diagnosed that the frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 90,000. The VIN was unavailable.
2004 Toyota Tacoma body complaints
Page 6 of 8: complaints 131 to 160 of 203, newest first, as owners wrote them.
Tl* the contact owns a 2004 toyota tacoma. While the vehicle was being serviced for an unrelated repair, the mechanic discovered that the entire frame had rust corrosion. The vehicle was not repaired. The manufacturer was notified of the issue. The approximate failure mileage was 56,000. Updated 04/07/15*lj updated 11/3/2015
2004 toyota tacoma. When recall came out for vehicle, it was sent to wrong address and that campaign ended in 2012 and they (toyota) won't do anything for customer. *ta the consumer stated during a safety inspection, he was the frame on his vehicle was severely rusted. At that time, he was informed a recall had been issued for the problem. Toyota informed the consumer it was not a recall, but a campaign.
Frame slightly bent in accident. When body shop went to pull frame to straighten out they would not do it because how badly rusted the frame was. Truck had 88,000 miles on it. Toyota will do nothing. This is my second tacoma this has happened too. They recalled my 97 tacoma because of the same issue, at least they treated me fairly on that. I was assured when I bought the second truck rust problem was fixed.
My low mileage toyota truck has both front and rear bumpers rotting through from the back to the front . There is a hole coming through the chrome and the back side is completely full of crumpling rust. These bumpers are going to offer little to no protection in a accident situation . I believe this should be included in the rust recalls of these trucks please make it happen before someone gets seriously injured. Thanks , [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Called toyota after pa state inspection was told that the frame was rusting out. Got the run around from toyota stating that there was a preventative coating recall that my fianc didn't have performed. When I called toyota they didn't have her information and she owned the truck four years prior to the call. After they blew me off. She got her first recall notice for the spare tire, took it to toyota on 1/13/15. They can nt perform the recall saying the frame is rotting to bad and the truck is unsafe. Look at the post on line look at edmunds look on google this is a huge safety and consumer protection issue why wont the government step in and address this or do people need to die first.
Purchased this vehicle in june of 2014. The carfax report only listed a recent recall dealing with the spare tire hanger. The carfax report did not show any other recalls, including the frame treatment, the frame replacement or the truck buy back offered by toyota. We completely unaware of the recalls. Two weeks ago, the rear right shock rotted/completely broke away from the severely rusted frame. Toyota says they will do nothing because "we" didn't have it treated. However, we had no knowledge of the recall and had no way of knowing that there was a frame problem because the dealer indicated no issues, the carfax report showed nothing and we have only owned the truck for 6 months. We don't know what to do. Are we stuck with this or can we hold someone accountable for help?
I own a 2004 toyota tacoma pickup witch was included in the frame recall. At the time of this recall I was having health issues that prevented me from following though on the recall. After I got back on my feet I called the toyota dealer in berlin vermont and was told it was to late to have it done. I then called toyota and spoke with a gentleman, I told this person all about my health issues that had prevented me from getting this taken care of. He also told me it was to late to have it looked at and repaired. I then asked him what would happen if the frame broke when driving and caused a crash or a death and he told me that was my problem. I now have a recall about a spare tire hanger that may rust off allowing the spare tire to fall off. It would seem to me that this is just a continuation of the frame problem that I was told I was to late for..I have run my own auto repair shop for over 30 years so I am note unfamiliar with autos or dealer. Thank you for hearing me out and any help you could give me would be very nice. *tr updated 1/7/16
The toyota tacoma trucks had a customer service advisory for the frame rusting on the vehicle. The csa advised the current owner that the frame could rust and needed to be inspected. If the vehicle was inspected toyota would either spray the frame or replace it if rusted. I purchased this vehicle from an authorized toyota dealer I was assured the frame had been checked and taken care of. A week later I had to install a blown out muffler and come to find out the frame was not looked at and the fix was not completed. Being the new owner of the truck I was told that the csa had expired december 2011 and there is nothing that can be done. I was hoping toyota would have a program in place for people that purchase a vehicle like I did that did not have the frame fixed. They do not. Therefore I now own a truck that is unsafe to drive. Toyota needs to make this a recall instead of a csa.
The frame is so rotted it wont pass state inspection, this truck was recalled for this problem a few years ago, I took it to the dealer for inspection at that time and they said it was fine, now like two years later its totally rotten, I contacted toyota head quarters and filed a case # 1411101661 and they basically told sorry its to late recall is over, I told them it was at the dealer for this recall and they did nothing but look at it, can you help and there are 1000s of these rotten trucks on the road today a major safety issue thanks [xxx]. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
The frame is rusted through.I called toyota they said they sent a recall.I told them I didn't receive one.they said it was not there fault.it was the post office fault.I can't have any work done on the truck because of the rust.I don't have a lot of money I expected this truck to last a while.they knew they were making substandard frames.by just looking at my frame.
The frame on the truck is rusted through.I have opened 2 complaint cases and toyota will not repair or replace.
I was driving down the road and noticed some unusual rattling. I stopped and upon inspection found that the frame on both sides had cracked all the way through directly above the rear tires. This rendered the vehicle extremely unsafe to drive. I had it towed to a repair shop and they told me that a complete frame replacement needs to be done and that the vehicle is unsafe to drive as is. They said the frame is completely rusted out. I understand the vehicle came out of new york and has high salt concentrations but the rest of the truck is virtually rust free. I can?t believe that a frame rusting completely out is normal in just 10 years. I have contacted toyota (case number 1409290440) and they are telling me that any recalls pertaining to this have expired. I can?t believe they will not step up and fix what is obviously shoddy craftsmanship. My main concern is this could have caused a serious accident. They stepped up to the plate with the 1995-2000?s that had the exact same issue and obviously was not fixed in the 2001-2004 models. I am very disappointed with toyota and very concerned for the safely of other tacoma owners as this seems to be a pretty common issue with these trucks.
Tl* the contact owns a 2004 toyota tacoma. The contact received a recall notification for the federal safety agency campaign number: 12v542000 (tires). The contact stated that the frame where the spare tire was located was corroded. As a result, the dealer declined the recall repair due to the frame being rusted. The dealer stated that the frame needed to be repaired prior to the recall remedy. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 110,000. Updated 11/14/14*cn updated 4/29/2015
I was at shell station getting a oil change, when they went to lift my truck on their lift the technician noticed frame corrosion in 2 places. The technician told me if I do not fix it the spring leaf could fall off. Further more it is a safety issue. I do not the money for a new vehicle. Just because I did not get a notice does not mean they should include a certain batch of trucks it should be all toyota's regardless. I called the dealership and they said forget about it if I did not a letter. I should not have to die just to get this fixed.
I just wanted to tell how utterly useless I think this administration is. I wrote in with a complaint on my 2004 toyota tacoma which has a rusted frame and too dangerous to drive. There were numerous complaints just like mine and still are all over the internet and you have done absolutely nothing. Toyota refuses to fix my truck and I never received a notice for my truck frame as well as a lot of others. If I had kept driving this truck me or others could have been killed. I have a conscious unlike this office and toyota. I contacted my senator and asked him how many complaints do you people need to do something. I guess somebody has to die first which is sinful and sad!!!
Tl* the contact owns a 2004 toyota tacoma. The contact stated that during a routine inspection, it was discovered that the sub frame had holes. The vehicle was taken to the dealer for diagnostic testing however no results were available. The manufacturer was notified of the failure. The approximate failure mileage was 124,000.
Frame is rusted through in many places. It will not pass state inspection.
Tl* the contact owns a 2004 toyota tacoma. The contact stated that while having maintenance performed on the vehicle, the independent mechanic discovered rust and corrosion on the sub frame of the vehicle. The contact indicated that the rusting and corrosion had created 4 holes that extended approximately 5-6 feet and were approximately 4-6 inches wide. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was 147,000.
Tl* the contact owns a 2004 toyota tacoma. The contact stated that the frame of the vehicle was extremely rusted. The vehicle was not diagnosed or repaired. The manufacturer was notified. The failure mileage was 136,000.
I purchase my toyota tacoma used in jan. 2013. I noticed last month that the frame was getting holes in it. The information I looked up said that toyota did a recall on this particular truck. I was told by toyota that it is now too late to get it taken care of. I was not aware of the recall or an arbitrary ending date. Can you help me get toyota to take care of this problem. The truck is now worth nothing with the frame as it is. [xxx]. Thank you for your assistance in this matter. This is the case # that toyota has assigned to my situation: #[xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
I got a letter from toyota motors stating that certain model years of tacomas had rust damage to the frame and I was informed to bring it to the dealership where they would perform a rust test on it. Mine is a 2004. They said the rest wasn't bad enough to replace the truck,of course and kept it to spray on a rust preventative on the frame. Within one year the coating they applied began to fall off peel off and obviously didn't work like planned. My sister had a 98 tacoma with the same issue and you could put your finger through the frame. They bought her truck back at the corporate office at 150% of bluebook value. That's what should happen now also. I've paid 20k$ for the vehicle brand new and a major reason was everyone likes the tacoma and its fairly easy or lets say was easy to resale before all the problems they are having. Now I've gotten another letter saying there is more than one recall and now have problems with the spare tire holder plate possibly rusting and falling off. Its pretty obvious to me and all the customers who have had the problems, that toyota must be forced into actually replacing the vehicle or pay the 150% book value without argument. Is anyone going to make this right? I have had 2 mechanics tell me the truck is unsafe and not road worthy. Luckily I have a company vehicle otherwise I would be very challenged. The bumper all the way to the front is totally rusted out and I don't wanna hear lip service saying its due to salt or something I just want a billion dollar company to be responsible for their product. I haven't driven the truck but 10 times since getting the coating applied and the sad thing is I love the truck and cant drive it. Please help us.
Tl-the contact owns 2004 toyota tacoma. The contact stated t while the vehicle was inspected the subframe was found severely corroded. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure and current mileage were 108,000. Rk
Tl* the contact owns a 2004 toyota tacoma. The contact received notification of the federal safety agency campaign id number: 12v542000 (tires). The dealer advised that contact that the repair could not be performed due to extensive rusting of the wheels. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 44,000. Updated 08/11/14*lj the consumer stated the frame was rusted. Updated 8/13/2014
Tl* the contact owns a 2004 toyota tacoma. The contact stated that the vehicle was taken to an independent mechanic for an unrelated repair when they noticed that the entire frame was covered with rust. There was a voluntary recall issued by the manufacturer however, the recall had expired. The vehicle was not repaired. The manufacturer was notified of the defect. The approximate failure mileage was 78,000. The VIN was unavailable.
Tl* the contact owns a 2004 toyota tacoma. The contact stated that while driving on uneven pavement, a loud banging noise was heard from the rear of the vehicle. The contact also indicated that when making turns, the vehicle would become unstable. The vehicle was taken to the dealer, who diagnosed that the rear sub frame was corroded and rusted. The vehicle was not repaired. The manufacturer was notified. The failure mileage was 162,000. Updated 7/7/14*cn updated 07/11/2014
Frame is perforated due to rust just in front of rear axle on both sides of vehicle. About a 1.5" x 6" hole on driver's side with a fracture of about 12" going toward rear axle. Passenger side has a fracture about 18" long in same area. Rear suspension mounts and springs are compromised. Toyota had a program to deal with issue but deadline had passed by the time I purchased vehicle. Dealer told me toyota had checked out frame issue and it passed. According to toyota I was misinformed. Toyota will not fix what is obviously a manufacturing defect that I never had the opportunity to deal with properly. Body and bed are rust free and in excellent condition. I paid 11,700 for the truck with 88,000 mi., have owned it for one year and put approx. 9,000 miles on it. It is unsafe to drive and for all intents and purposes totaled.
Attempted to trade vehicle in. Inspection by dealer reported hole in frame. Dealer refused to take my truck. Estimated cost to replace frame at $9,000-$10,000.
I purchased my 2004 tacoma as the second owner. The vehicle had the frame replaced. Upon my initial inspection prior to the purchase, everything underneath looked fine aside from what I considered normal rust on other parts such as the skid plates. Today while driving down the road, the gas tank fell out of the bottom, ran into and drive-shaft, and came 3 inches from scraping across the pavement. A line split on the top of my tank, leaking gas all over. I've contacted toyota, and they set me up with a case number, informing me that someone will be in touch tomorrow to discuss further.
I have a 2004 toyota tacoma pickup truck. This has had a very bad for a year. The other day the mount for the right rear broke and the front end of the rear spring was rusted away from the frame. This is the same problem my 1996 toyota pickup had. That one the bought back and I now have this one. The rest of the truck is pretty good. The rack and pinion steering also rusted away and started to leak fluid. This leak was under the right mount of the rack. This was also fixed by me. This is my work truck and personal way of getting around. These are both very serious safety problems !!! I contacted the ceo of toyota, toyota sales in califorina and girard toyota. They said I slipped through the cracks and I did not get any notices !!! They are putting tons of frames on for other peoples but I have been singled out some how and I cannot get one. This problem has been going on for 20 years !!! This with out question should be a recall and all items concerned should be replaced free of charge. Please help with this serious problem. Thank you.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Toyota Tacoma?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history