2025 Toyota Tacoma problems

Filed Nov 8, 2026 · NC

The drivers side door handle broke under normal use and leaving me trapped and unable to depart the vehicle from my drivers seat.

Filed Nov 5, 2026 · CA

Both front drivers and front passenger interior door handles became inoperable. First the passenger side. Dealer replaced defective part. Now the driver side leaving the driver and passenger inside the car without being able to exit the vehicle. The occurrences did not happen luckily during a roadside event, otherwise the passengers would have experienced the inability to exit the vehicle.

Filed Oct 28, 2026 · NE

Door Handle on inside broke, preventing normal egress. Yes is has been verified by dealership and they wait for parts for repair. No lamps or warnings. Door just quit functioning. As I am disabled this may be more alarming for me than others.

Filed Oct 28, 2026 · PA

2025 Toyota Tacoma SR5 passenger inner door handle is broken and will not open the door. This is a big safety concern as you cannot open the door from the inside if there is an emergency. Driver side inner door handle was replaced by the dealer due to the exact same problem. The issue is well known and this needs to be recalled,11,500 miles on vehicle.

Filed Oct 23, 2026 · TX

Interior drivers door handle no longer opens door. Making it impossible to open from the inside. Dealer claims replacement parts are on a 4-6 week backorder and hinted toward it being a common issue.

Filed Oct 22, 2026 · Transmission · 5,000 miles · MI

The contact owns a 2025 Toyota Tacoma. The contact stated that while driving 65 MPH and accelerating and switching lanes, the vehicle failed to respond and maintained the desired speed. Additionally, the vehicle hesitated continuously. The contact associated the failure with the federal safety agency Campaign Number: 25V656000 (Power Train). The contact stated that the vehicle was previously repaired under the recall, but the failure occurred. The dealer was contacted but was unable to duplicate the failure. The service advisor associated the failure with the recall. The manufacturer was contacted and made aware of the failure. The failure mileage was approximately 5,000.

Filed Oct 21, 2026 · TX

Inside door handles continue to break at random . Small internal piece will snap and door handle no longer functions from the inside. Almost every other owner of the same year and model has had the same issue on every single interior door handle, on MULTIPLE occasions!

Filed Oct 20, 2026 · Body · WY

I own a 2025 Toyota Tacoma, and the interior driver’s door handle assembly has failed, preventing me from opening the driver’s door normally from inside the vehicle. The failure occurred at around 11000 miles during normal use without any accident, impact, or unusual force. The Tacoma had routine maintenance done at dealership at around 10682 miles. The handle became suddenly inoperable, leaving me unable to open the driver’s door from inside the cabin using the interior door handle. I must roll down the window and operate the exterior handle to exit through that door. This presents a potential safety hazard because, in an emergency such as a vehicle fire or collision, I may be unable to exit promptly through the driver’s door. The failure occurred suddenly without adequate warning. I contacted an authorized Toyota dealership, which determined that the handle sub-assembly needed replacement under warranty. However, the replacement part has been on backorder, and I have been informed that the estimated arrival date is December 7, 2026. This leaves me waiting months for a repair to a component that is essential to exiting the vehicle safely. I am concerned that this may represent a recurring defect affecting other Toyota Tacoma owners. I am requesting that the federal safety agency review reports of interior door handle failures in 2024–2026 Toyota Tacoma vehicles to determine whether a broader safety defect exists and whether further investigation is warranted.

Filed Oct 20, 2026 · Body · TX

Inner door handle broke under normal use and toyota cant replace this due to mass failures across the country in all 4th generation tacomas. Mass backorders. I have been driving for at least 2 months with no way to exit my vehicle in case of emergency.

Filed Oct 17, 2026 · CA

My Toyota Tacoma door handle fails to open from the inside. My truck has around 13,000 miles on it and I’ve only opened that door maybe 100 times over the past year. Toyota claims it’s a wear issue but multiple posts have similar incidents with no damage to them. They just fail to work. If I had a medical emergency with my type 1 diabetes or an accident and couldn’t get out of the car it could be extremely dangerous.