2022 Volkswagen Atlas Cross Sport problems

Filed Oct 26, 2026 · Fuel system · GA

Certified warranty-extension charcoal canister failed, completely collapsed my fuel tank, and damaged the fuel pump. AutoNation Volkswagen in Savannah, Ga and Volkswagen Corporate are refusing to address a structurally compromised, hazardous fuel system.

Filed Oct 26, 2026 · Airbags · GA

The passenger airbag off-light stays illuminated on the center console even with a passenger. I just took a road trip to Florida, where I drove, and my brother drove. One of us was always in the passenger seat. We are each 250 lb. The passenger airbag off light remained illuminated throughout as well as in any short trips while we we down there. and the airbag warning lights on the dash the yellow light or orange light would illuminate and beep periodically throughout the entire trip.

Filed Oct 26, 2026 · Engine · PR

The car stalls at low speeds causing a safety concern for me and my kid. Reading in the VW Atlas Forum, this could be caused by a failed vapor (or carbon) canister. VW has not issued a recall on this as far as I know. This happens randomly. When this happens, the check engine light comes out.

Filed Oct 21, 2026 · Fuel system · PA

COMPONENT FAILURE: Gas tank “sucked in”. Faulty EVAP vapor charcoal canister. Safety Issue: July 2026 while driving during Rush Hour on a two lane street and approaching a stoplight my vehicle stalled and shutdown. Problem reported to Volkswagen dealership service center: 07/09/2026 I informed them that my vehicle’s air conditioner was not cooling the interior cabin and of the stalled incident. VW test and diagnose: Air/C System checked, A/C system flushed and nitrogen leak check. Cost: $355.60. Component Issue: October 2026 check engine light came on. Manual stated light meant exhaust system malfunction. Vehicle serviced at VW Service Center 10/02/2026. Diagnosis summary invoice: Fault Code FL03 Fuel Tank. Replace causing p0441 fault and sucking tank inward. It was determined that the fuel tank was sucked inward. Explanation: gas tank vapors were not dissipating properly. Mechanic/Dealership recommended replacing fuel tank. In addition, I was provided a video stating this recommendation. Estimated cost $2,075.00 plus tax. I was provided a loaner while my vehicle was in the Service Center. Picked up my vehicle 10/08/2026. Cost: $218.31. Check Engine Light: October 2026 check engine light came on. Problem was the same. 10/06/26 Fault with EVAP System Vent Citric /Circuit. Diagnosis summary invoice: Replace the EVAP Canister assembly with LDP, N80 and clean purge line of compressed air. Cost: $37.29 Same Component Issue: October 2026 check engine light came on evening of 10/12/2026. Returned vehicle to VW Service Center and I provided another loaner vehicle. Diagnosis summary invoice: Found Radiator Grill Shutter failed. Radiator Grill Shutter replaced and necessary systems recalibrated. Cost: $257.33. VW Service Center determined that there were no cracks in the gas tank, therefore the Service Center did not replace the gas tank because my vehicle is out of warranty. This “sucked in” gas tank is through no fault. I am seeking full compensation to replace my gas tank.

Filed Oct 10, 2026 · Lights · AZ

I am submitting a formal safety complaint regarding the repeated premature failure of the LED daytime running light (DRL) on my 2022 Volkswagen Atlas Cross Sport, which currently has approximately 80,000 miles. This is the second occurrence of a daytime running light failure on my vehicle, despite having previously replaced the failed component. The repeated failure raises serious concerns about the reliability and durability of Volkswagen’s LED lighting system and suggests a potential underlying manufacturing or design defect. Daytime running lights are an important safety feature intended to improve vehicle visibility to other motorists, pedestrians, and oncoming traffic. When one of these lights fails, the vehicle loses part of its intended daytime visibility system, potentially increasing the risk of an accident, particularly during cloudy weather, reduced visibility, or other challenging driving conditions. It is especially concerning that this issue has occurred again after a previous replacement. Vehicle owners should not have to repeatedly replace expensive lighting components that are designed to provide reliable, long-term operation. I am requesting that the federal safety agency investigate these recurring LED daytime running light failures in Volkswagen Atlas vehicles to determine whether a widespread safety-related defect exists and whether a recall or manufacturer-funded corrective action is warranted.

Filed Oct 10, 2026 · Electrical · IL

The 5F module for the infotainment system became defective at ~52,000 miles causing the reverse camera to not be functional. Due to how common this issue appears to be, the part is on backorder leaving many drivers without a backup camera for extended periods of time. My vehicle was without a backup camera for approximately two weeks.

Filed Sep 27, 2026 · Electrical · MN

I was on day trip (XXX) and car worked fine in the morning. After a lunch stop, started the car, infotainment system would not turn on, had multiple errors on my dash including road sign recognition system not being available, error message for SOS system, handsfree phone connectivity was non-functional, no back up camera displayed on screen, no charging ports functional below the infotainment unit, wireless charging system failed, etc. VW dealer which has done 99% of the service to my car diagnosed on XXX the "5F module and the back up battery" had both failed. They indicated they could get the back up battery but the 5F module was on national backorder with "no ETA on when the parts will become available". To date I am now over one month since the issue occurred with zero ETA on the parts to repair the issue. I still have no backup camera, no phone connectivity, no radio, no navigation, the advanced drivers aid for road signs recognition is still not working, nor do I have the SOS emergency safety feature. In addition, I've learned this is a frequent point of failure on multiple lines of Volkswagen automobiles, not just the Atlas (confirmed via discussions with other VW owners whom have experienced the same issues as well as via dealer service employees). I have reached out to Volkswagen Customer Care and all they continue to ask me a laundry list of basic questions which is frustrating as they have all the history on Atlas as my vehicle has been serviced since new at their dealership in [XXX]. I just want my cars safety features back and for Volkswagen to accept responsibility for this being a failed component / design of their own doing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 14, 2026 · Engine · 82,933 miles · LA

The contact owns a 2022 Volkswagen Atlas Cross Sport. The contact stated that overnight 1/3 of the engine oil had leaked onto the ground. While starting the vehicle, there was an abnormal oil burning odor and visible smoke coming from the engine. There was no warning light illuminated. The vehicle was towed to an independent mechanic to be diagnosed, and the contact was informed that the VVT sensors, timing cover gasket, and timing cover needed to be replaced. The parts were replaced; however, the oil leak persisted, and the parts were replaced a second time. The contact was informed that the PCV was inoperable as per the Emissions Service Action Code: 10LP. The contact was referred to the manufacturer for assistance. The manufacturer was notified of the failure; however, the contact was advised that the repair would be an out-of-pocket expense, minus the PCV. The vehicle was not repaired. The failure mileage was 82,933.

Filed Apr 27, 2026 · Engine · WI

I am filing a safety complaint regarding my 2022 Volkswagen Atlas Cross Sport, VIN: [XXX] The vehicle was purchased new in October 2021. Volkswagen issued Recall 13i4 / the federal safety agency Campaign 22V‑753 for certain Atlas Cross Sport vehicles due to an engine connecting rod/connecting rod bearing manufacturing defect that can cause engine failure, loss of motive power while driving, and potential safety risks. My vehicle was inspected by an authorized Volkswagen dealer under Recall 13i4 in 2023. I was told the recall condition was not present and the recall was marked completed. On or about [XXX], the vehicle developed the exact issue covered by Recall 13i4. I brought it to an authorized Volkswagen dealer, and the dealer confirmed that the failure is the same engine connecting rod/connecting rod bearing issue identified in the recall. The required repair is engine replacement. Volkswagen is refusing to reopen or reauthorize the recall repair because the recall was previously marked completed after the 2023 inspection and because the factory warranty expired in October 2025. I am now being told I may be responsible for the engine replacement cost, even though the dealer has confirmed this is the exact safety defect covered by the recall. I believe this is a failed or inadequate recall remedy. The 2023 inspection did not permanently remedy the defect and appears to have missed a latent manufacturing issue that has now manifested. This is not a normal out-of-warranty mechanical failure. It is the specific safety-related defect Volkswagen reported to the federal safety agency. I am asking the federal safety agency to review whether Volkswagen’s Recall 13i4 remedy process is inadequate, especially for vehicles that passed the initial inspection but later develop the same covered engine defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 13, 2026 · Lights · FL

The daytime running light on the passenger side is out. The entire headlight assembly and bumper have to be removed to repair this. It will cost $1400 to repair. This is a safety issue and should be covered by Volkswagen.