I am a hazardous-materials tanker driver for Pilot Company / Pilot Flying J, based at [XXX]. This complaint concerns a new replacement orange seatbelt installed by my employer in truck unit 50757, Tennessee plate [XXX]. During normal driving, the belt unexpectedly locks or tightens against my neck and pins me back, restricting movement and creating unsafe driving conditions. I have experienced similar problems in other company trucks, and colleagues report comparable problems affecting their necks. I have repeatedly documented defects in pre-trip and post-trip reports and notified management and safety. Yard lead [XXX] said the belts were fine and defect entries were being dismissed. I have not been informed of a satisfactory repair. The concern is unexpected locking during normal driving. I understand seatbelt use is required and want a functioning restraint. Exact belt manufacturer, model, part number, installation date are not yet confirmed. My records and recordings document the reported problem. In truck 50757, this occurs daily since approximately the beginning of 2026 and continues to the present. XXXis an approximate onset date, not a confirmed installation or first-incident date. Prior neck and dental injuries occurred in a different truck, unit 50750, which is no longer at the yard; its VIN and plate are unavailable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The worst 2024 Volvo VN problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Seat belts1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Seat belts1
Recalls 7
Engine and engine cooling: engine: diesel
- What is wrong
- Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2025 Volvo VN and 2025 New VN trucks. The idler gear bracket fasteners may have been improperly tightened, allowing the idler gear to detach from the engine.
- Risk
- A detached idler gear can damage the engine, resulting in a stall and increasing the risk of a crash or injury.
- Remedy
- Dealers will inspect and replace the turbo compound units as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Volvo Trucks' customer service at 1‑800‑528‑6586. Volvo Trucks' number for this recall is RVXX2504.
Recall number 25V257000 · Recall details
Electrical system: software
- What is wrong
- Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
- Risk
- Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may have diminished or lost functionality, increasing the risk of a crash.
- Remedy
- Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1‑800‑528‑6586. Volvo Truck's number for this recall is RVXX2409.
Recall number 24V790000 · Recall details
Vehicle speed control: throttle: throttle position sensor (TPS)
- What is wrong
- Volvo Trucks North America (Volvo) is recalling certain 2022-2024 Volvo VN vehicles. When the Controller Area Network (CAN) communications are interrupted and the vehicle is in limp mode, an incorrect accelerator pedal signal can result in unintended acceleration. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 124, "Accelerator Control Systems."
- Risk
- Sudden unintended acceleration can increase the risk of a crash.
- Remedy
- Dealers will update the electronic control unit (ECU) software, free of charge. Owner notification letters were mailed November 26, 2024. Owners may contact Volvo Customer Service at 1‑800‑528‑6586. Volvo's number for this recall is RVXX2408.
Recall number 24V741000 · Recall details
Equipment: other: labels
- What is wrong
- Volvo Trucks North America (Volvo Trucks) is recalling certain 2024 VN and VHD vehicles equipped with size 295/75 or 385/65 Continental tires on the front axle. The Gross Axle Weight Rating (GAWR) listed on the vehicle certification label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
- Risk
- An overloaded vehicle can increase the risk of a crash.
- Remedy
- Dealers will remove and replace the label, free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Volvo Trucks customer service at 1‑800‑528‑6586. Volvo Truck's number for this recall is RVXX2314.
Recall number 23V816000 · Recall details
Vehicle speed control
- What is wrong
- Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2024 VN vehicles. The engine may not return to idle within 2 seconds if the accelerator pedal position sensor becomes disconnected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 124, "Accelerator Control Systems."
- Risk
- An engine that does not return to idle quickly enough can cause a loss of vehicle control, increasing the risk of a crash.
- Remedy
- Volvo Trucks will replace the throttle pedal and update the vehicle software, free of charge. Owner letters were mailed February 27, 2024. Owners may contact Volvo Trucks customer service at 1‑800‑528‑6586. Volvo Trucks number for this recall is RVXX2313.
Recall number 23V793000 · Recall details
Seats: critical fasteners
- What is wrong
- Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2024 VN and VHD vehicles. The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seatbelt Assembly Anchorage."
- Risk
- The attachment points may fail, allowing the bench seat to shift and increasing the risk of injury during a crash.
- Remedy
- Dealers will replace the weld nut with two nuts and a washer, free of charge. Owner letters were mailed February 29, 2024. Owners may contact Volvo Trucks customer service at 1‑800‑528‑6586. Volvo Trucks number for this recall is RVXX2312.
Recall number 23V769000 · Recall details
Steering: critical fasteners
- What is wrong
- Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2024 VN, VHD, and VAH trucks. The steering gear fasteners may not be properly tightened.
- Risk
- Loose steering gear fasteners may result in a loss of vehicle control, increasing the risk of a crash.
- Remedy
- Dealers will tighten the steering gear fasteners, free of charge. Owner notification letters are expected to be mailed August 18, 2023. Owners may contact Volvo Trucks' customer service at 1‑800‑528‑6586. Volvo Trucks' number for this recall is RVXX2307.
Recall number 23V441000 · Recall details
Technical service bulletins for the 2024 Volvo VN 150
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- TSB
- Overheating has been observed at the alternator power cable and ground cable connection, resulting in...
- This CBR solution addresses the issue of binding between the outer air filter housing and inner HVAC box...
- The purpose of this CBR is to provide steps on how to correct a customer complaint of DTC P107B86...
- If you have received
- Cbr
- Cbr - z
- Cbr
- Cbr
- Sc
What 2024 Volvo VN owners say
Most recent owner complaints, unedited.
This Person hit my SUV and would not Stop, USDOT # 923849 I had to chase him down for a mile before he stopped. He destroyed my New Car 2025 Subaru Forester. I would like this person NOT be able to drive a BIG RIG again.
Compare the 2024 Volvo VN
Other model years
199619981999200020012003200420052006200720082012201320142018202020212024
Questions about the 2024 Volvo VN
Is the 2024 Volvo VN reliable?
Owners have filed 2 complaints about the 2024 Volvo VN, close to a typical VN model year.
What is the most common problem with the 2024 Volvo VN?
Seat belts, with 1 complaint.
How many recalls does the 2024 Volvo VN have?
7 recalls, covering engine and engine cooling, electrical system and vehicle speed control.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2024 Volvo VN?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history