2019 Chevrolet Silverado 1500: engine stalls while driving

Filed Nov 2, 2026 · Electrical · TX

My 2019 Chevrolet Silverado 1500, VIN [XXX], with 137,640 miles, experienced repeated Battery Saver warnings, severe charging voltage fluctuations dropping as low as 9 volts, and intermittent reductions in engine power and RPM while driving. Upon inspecting the alternator, I discovered severe overheating at the positive battery cable (B+) connection. The plastic insulation surrounding the alternator terminal had melted away, and the charging cable insulation was brittle and heat-damaged. I have photographs documenting the damage. I reviewed GM safety recall N192273510 (the federal safety agency 19V888), which describes loose alternator B+ connections causing intermittent electrical failures, arcing, overheating, possible engine stalling, and fire hazards. The symptoms and physical damage described in this recall closely match what occurred on my vehicle. However, both Chevrolet and the federal safety agency indicate that my VIN is not included in the recall. I contacted GM Customer Assistance and received case number [XXX] after requesting escalation. GM advised that my case would not become active until a dealership inspected the vehicle. A Chevrolet dealership quoted $1,345 to replace the alternator and positive charging cable without physically inspecting the truck. Towing and diagnostic expenses are estimated at an additional $400. I am concerned that other 2019 Silverado vehicles excluded from recall 19V888 may experience the same potentially dangerous electrical failure. I request that the federal safety agency investigate whether the existing recall population should be expanded to include additional affected vehicles. The vehicle has not been repaired, and the damaged components remain available for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 23, 2026 · Engine · MI

The contact’s husband owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving, the vehicle lost power while depressing the accelerator pedal. The failure persisted, and the vehicle started to shut off while driving with the check engine warning light flashing. The vehicle was towed to a dealer, and it was confirmed that there were no open recalls or warranties associated with the VIN. The vehicle was then towed to an independent mechanic and was diagnosed with engine failure. The owner was provided with an estimate for the repair. The manufacturer was notified of the failure, and the contact was provided with a case number.

Filed Aug 31, 2026 · Engine · 23,600 miles · TX

The contact's husband owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving approximately 35 MPH, the check engine warning light illuminated but disappeared the following day. The contact stated that approximately four days later, after refueling the vehicle, while stopped at a red light and attempting to make a right turn, the vehicle stalled. The vehicle was pushed to the side of the road and towed to the residence. The vehicle was then towed to a dealer where it was diagnosed and determined that the fuel pump module needed to be replaced. The contact stated that DTC: P129F was retrieved. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 23,600.

Filed Jul 29, 2026 · Fuel system · 71,969 miles · SC

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the vehicle lost power and stalled in the middle of the road. The check engine warning light was illuminated with the message "Fuel Low" displayed. The vehicle was pushed to the side of the road, and the contact later returned to the vehicle and added a small amount of fuel to the fuel tank. After starting the vehicle, the vehicle operated normally and was driven to the residence and parked. The following day, the vehicle was started, and the fuel gauge indicated that the fuel tank was half full. The vehicle was driven to the local dealer, who diagnosed the vehicle with fuel pump power control module failure. The contact was informed that the fuel pump power control module needed to be replaced. The fuel pump power control module was replaced. The cause of the failure was not yet determined. The manufacturer was not contacted. The failure mileage was 71,969.

Filed Jul 25, 2026 · Electrical, Steering · OH

I was camping at a state park outside of Kenton Ohio. On Sunday July 19 2026 while backing up my travel trailer I lost power steering to my 2019 Silverado 1500. then a message came on my display saying service power steering soon and then a check wiring harness warning. I turned off truck and restarted it and warnings cleared and power steering came back. The following morning July 20th started the truck, no power steering and service engine light was on drove to Kenton and had codes read. Had multiple codes for different control modules. Power steering came back and I was able to drive home. Called my dealer and was able to get appointment on July 24. Tried to start truck and it would crank, start run rough for a few seconds then stall out. Had to have it towed to dealer for repair. End result faulty ground strap from body to frame, loss of electric power steering ability while driving due to a ground cable could have been a very dangerous situation for everyone in the vehicle and on the road

Filed Jun 26, 2026 · Engine · 42,000 miles · NH

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 25 MPH and approaching a red traffic light, the vehicle stalled. There was an oil message flashing on the screen instructing the driver to pull over. The vehicle was towed to an independent mechanic, and the contact was informed about the GM Customer Satisfaction Program: N212326940. The local dealer was contacted and referred the contact to the manufacturer for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not under recall. The contact was referred to the federal safety agency Hotline for assistance. The failure mileage was approximately 42,000.

Filed Jun 16, 2026 · Engine · TN

Purchased 2019 Chevrolet Silverado High Country Edition with the 6.2L engine and 143K miles for my son. The vehicle had a clean service history on Car Fax. On the day we purchased the vehicle, we drove it home and noticed it was shuttering at times. I used my computer scanner and it came back with a misfire cylinder #5. I troubleshot the issues and noted that the most common thing was a spark plug. Therefore, I replaced the spark plug and it drove much better. Two weeks later, my son was driving vehicle on I-40 near Nashville TN and without warning, vehicle stalled, locking steering wheel in place! Check engine lights came on and instructed him to place in neutral and restart, which he promptly did. The vehicle started, but went in limp mode making loud noises in engine before shutting off again. Luckily, traffic was minimal at 8 pm and he was able to get it over to the shoulder and avoid any injuries or accident. Towed it to Nick Mayer Chevrolet in Dickson, TN where they diagnosed it with catastrophic engine failure and needed to be completely replaced. This is the same issue that GM is being sued for and have somehow managed to take the stance that the lifter/cam/DFM issue only existed in 2020-newer models. The 2019 is when they changed to the newer body style and the new Gen V L87 engine in the 6.2. Despite the clean vehicle history, dealership reached out to GM and they stated they would not help cover any repairs but would gladly take 14K to fix it. The 2019-2026 models all need to be recalled due to this safety issue and fixed before catastrophic engine failure claims another victim financially or worse!

Filed May 13, 2026 · Acceleration, Engine · NM

On Sunday, April 12, 2026, at approximately 5:00 PM, I experienced a sudden and complete engine failure while driving my 2019 Chevy Silverado equipped with the 6.2L V8 engine. Without warning, the vehicle lost all ability to accelerate, creating an immediate and dangerous situation for myself, my family, and surrounding drivers. I was forced to rely on the vehicle’s remaining momentum to maneuver to the side of the road, all while other drivers honked as I attempted to merge with no engine power. This incident caused significant stress and posed a serious safety risk. My vehicle had to be towed home and then to [XXX] Casa Chevrolet at [XXX] . After inspection, the dealership informed me that the engine requires a full rebuild, despite the vehicle having only 115,697 miles. According to the dealership, the engine shows **no compression on all cylinders**, **crankshaft and camshaft compression failure**, **pistons coated in oil and fuel with visible damage**, and a **non‑functioning timing chain likely due to a broken guide**. These findings mirror the exact symptoms currently under investigation in GM’s **EA25007** inquiry involving the 6.2L V8 (L87) engines in 2021–2025 GM trucks and SUVs GM has already issued a major recall affecting nearly **600,000 vehicles** due to defective connecting rods and crankshafts that can cause sudden engine failure, stalling, and potential fire hazards. Although my 2019 Silverado is not included in the recall, it is experiencing the same catastrophic engine failure associated with the defective components identified in the investigation. The dealership has quoted me $10,000 for an engine rebuild and has refused to assist with the cost. I have also filed a complaint directly with GM, as this failure presents the same safety risks and mechanical defects acknowledged in the recalled models. This sudden engine failure placed my family and other motorists in immediate danger, and the lack of w INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 22, 2026 · Engine, Fuel system · MN

I Was traveling home one night and the truck shut off while driving and lost all power, loosing all steering, braking power aswell as all my lights while traveling down the road in the dark. . When I went to start it again all I would get was a cranking noise but no firing. After 30 minutes of waiting the truck started again. In which I drove it 3 more miles before it shut down again. After that it would not crank nor start. I then had the vehicle towed to my local Chevrolet dealer, and they had notified me that the engine had failed and locked up. In the process it had also taken out the FPCM (fuel pump control module) aswell as the high pressure fuel pump located on top of the motor. Causing me to have a new motor from GM installed. I had no previous problems or lights before this had happened.

Filed Mar 10, 2026 · Engine · VA

I am reporting a catastrophic internal engine failure in a 2019 Chevrolet Silverado 1500 at 87,600 miles. Prior to this event, there were NO warning lights or symptoms. While traveling alone during the holiday on a remote, one-lane road with no shoulder, the vehicle suddenly suffered a loss of power. Every warning light on the dashboard illuminated at once, followed by shaking, misfiring, and loud knocking from the engine. Because I was on a one-lane road with no place to pull over, this created an immediate safety hazard for me and oncoming traffic. I had the car towed to the dealership ( where I bought the truck) confirmed the failure was a collapsed lifter and scored camshaft (which i found out to be a known design flaw in the 5.3L DFM engine). The dealer said it was not under warranty. I felt held over a barrel by the dealership; they initially provided an inflated quote and told me it would cost approximately $1,200, not including tax and shop fees, just to put the engine back together if I wanted to tow it elsewhere for a second opinion. I was forced to pay over $8,395 under protest just to regain use of my primary vehicle after 42 days of downtime. Upon completion, the dealer provided a "Lifetime Warranty" on the replacement parts. This is a tacit admission that these components were never intended to fail during the life of the vehicle. GM refuses to include this vehicle in its coverage list, treating a dangerous engine stall as a simple "out of warranty" repair. This is a systemic safety defect that requires a mandatory recall expansion before it results in a terrible accident. My understanding is that a Class Action lawsuit, Harrison vs. General Motors, for this same thing, but they say my car is not in it, i should have been put on notice for this so I could protect myself.

Filed Mar 5, 2026 · Engine · AL

Incident Description: While driving at highway speeds, the oil cooling lines on my vehicle suffered a catastrophic failure, resulting in a total loss of engine oil within seconds. To ensure my safety and avoid being stranded in high-speed traffic, I proceeded less than a quarter-mile to reach the nearest exit. During the cooling process after the vehicle was stopped, the engine seized due to extreme thermal damage caused by the sudden lack of lubrication. Safety Risk: The sudden and total loss of engine oil at highway speeds presents a significant safety hazard. It creates an immediate risk of sudden engine stall or seizure while in traffic, which could lead to a high-speed collision. Furthermore, a high-volume oil leak onto hot engine components represents a severe fire risk. Technical Evidence & Manufacturer Response: There are existing Technical Service Bulletins (TSBs) for this specific vehicle model that explicitly identify these oil cooling lines as a known failure point. These TSBs state that failure to replace these lines can lead to the engine becoming non-functional. Despite this documented manufacturing defect and the clear safety implications of a sudden engine failure on a highway, Chevrolet has refused to provide a remedy, insisting that the engine replacement be paid for out-of-pocket. Requested Action: I am requesting that the federal safety agency investigate this known defect for a potential safety recall, as the failure of these lines constitutes a predictable and dangerous loss of vehicle power and potential fire hazard.

Filed Feb 20, 2026 · Acceleration, Electrical · AR

My 2019 Chevrolet Silverado has experienced repeated engine issues, including a confirmed timing chain failure. The vehicle has been taken in for repairs approximately 6–7 times for the same or related engine problems. Most concerning, the vehicle has stalled while driving, creating a serious safety hazard. Loss of power while in motion puts me and others at risk of an accident. Despite multiple repair attempts, the issue has not been permanently resolved. The timing chain failure is a major engine defect and not expected for a vehicle of this age and mileage. I am filing this complaint due to the safety risk associated with engine stalling and failure.