2019 Chevrolet Silverado 1500: ball joint or control arm failure

Filed May 8, 2026 · Steering, Suspension · TX

in beginning of January of 2026 my vehicle had lifter issues. Brought it to Chevrolet Group 1 in Spring Texas. Three weeks without transportation. Beginning of February the vehicle stopped in the middle of the feeder. Vehicle lights up but goes dark for five seconds and will not start. Had it towed back to the same dealership and told it was the battery cable that needs to be replaced. Three weeks passed no transportation. In the middle of April 16 2026 I was driving on the feeder in the far right lane and the front right wheel came off hanging by only the tie rod. the vehicle slid a good 700 to 900 almost crashing into a muffler shop gate. Upon inspection the muffler shop mechanic notice that the front right upper control arm bolt threads are not damaged and the nut is missing.

Filed Oct 20, 2025 · Suspension · 83,000 miles · TN

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 50 MPH, the front driver’s side upper control arm detached, causing the brake pads, rotors, and axle to fail. An independent mechanic was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was repaired, and the upper control arm control, brakes pads, and rotors were replaced. The contact stated that the failure had occurred several times. The contact related the failure to the federal safety agency Campaign Number: 21V718000 (SUSPENSION); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 83,000.

Filed Sep 4, 2024 · Suspension · SC

While driving within the neighborhood, the upper control arm ball joint failed and the wheel folded under. After some research, it appears that this truck purchased new from the dealership where it was upfitted with a suspension leveling accessory as shown in the photo. It should have been included in the federal safety agency Recall 21V‑718 as it clearly is premature failure of the OEM upper control arm ball joint due to the dealer installed Suspension Level Kit. Vehicle was purchased new at Vaden Chevrolet in Pooler GA.

Filed Jan 11, 2024 · Steering, Suspension · IN

In August 2023 I was hearing a popping noise coming from my truck. Took it to Hare dealership for diagnosis and repair. They had my truck until September 8, 2023. I was told Hare service couldn't reproduce the noise, ran multi-point inspection and was informed that everything was fine. Few days later, I returned to dealership and reported still hearing the popping noise. But service Mgr. said they found nothing wrong that wasn't repaired. Approximately 10 weeks later, while my wife was driving to pick up dinner, after stopping at a stop sign, she started moving and all the sudden steering the vehicle was impossible, and the truck collapsed in the middle of the dark road! See photos. I believe the safety risks to my family and other travelers on the roads speaks for themselves in this situation. I went to the scene with my father-in-law, where I saw my wife visibly terrified and shaking! As for the condition of the truck at the scene, see photos. I had the truck towed to my home, then called Hare Chevrolet the next morning and my truck was then towed to them. Hare reported that, Upper ball joint failed. Multiple damaged components. Recommend replacement of Upper Control Arm, Lower Control Arm, Axle Shaft, Steering Gear, RF Outer Tie Rod End, RF Brake Line, & Wire Repair for Speed Sensor. 4 Wheel Alignment: Required with ball joint replacement. [Primary]: D11 : Multi-Point Inspection (I), Wheels/Rims: Wheel repair. After waiting 6 weeks for Hare to provide a required written estimate detailing the costs of parts, labor, fees and taxes, I finally had my truck towed to another shop a few days ago. Excluding Sep. 8 to Nov 26, 2023, I have not had use of my family vehicle since August 15, 2023!

Filed Aug 14, 2023 · Electrical, Steering · FL

There is a vibration that is randomly felt. Over the last year I have replaced struts shocks control arm control arm bushings sway bar link sway bar link bushings tires twice and the vibration just keeps increasing to the point it's doing it now when I turn or take bends in the highway. There is now a flat spot in a tire feel when going it slower speeds to be added to the vibration that happens later on obviously related. This is either from my understanding going to be axle or driveshaft it's going to get looked at today since there's nothing left underneath to repair. This has ruined a pair tires I bought last year for $1,500 in September and probably well on its way to ruining the tires that I've just put on last week for $2,400. There is a hesitation a lack of response and a vibration. As far as the electrical goes it makes this very weird buzzing sound very randomly it's only happened about four times it's loud and it can't be explained. Also sometimes the radio and the AC just turns on and there's no key in the car and I've had the door open for a few minutes. Sometimes after turning it off he'll turn everything off but turn it all back on again no key in. Sometimes I can turn the stereo off and it makes a whistling buzzing sound and it's not even on. As far as any light indicators on the dash for any of this no never had a one. I have completely taken care of this vehicle with the transmission flush and will changes and everything that it's supposed to have and I put a lot of money in it since I've had it in a year but I shouldn't have to on 2019 and it's still experiencing the same problems and I have plenty of documentation. As far as date of occurrence it's been continual and random since I bought the truck in June of 2023 from a local dealership called Lokey

Filed May 5, 2023 · Suspension · AR

On my 2019-Chevrolet Silverado 1500, the ball joint in the front upper control arm broke and caused the wheel to separate from the truck while driving. The truck is available for inspection where I had to have it towed to the dealership repair center. Fortunately, no other vehicles were on the same road as me when it happened, and I was on a local road not going very fast, but it could have killed me and others. It most definitely put our safety at risk. Because of a faulty control arm causing the ball joint to break, it also broke my CV Axle, Tire Rod End, cut the brake lines and ruined the tire and wheel. Because the brakes did not work, I am fortunate the tire/wheel on the ground helped the truck to stop. The dealership says there is no GM recall so it is not covered and the federal safety agency Recall 21V718 is not real which I never received a notification about either. We are waiting on insurance and dealership to complete the full inspectection with an estimate and they too agree I am lucky to be alive. There were no warning lamps or messages. This must be addressed with GM immediately before more people die from this faulty control arm.

Filed May 4, 2023 · Suspension · MI

The front driver side upper ball joint broke. I was going down the highway at 70 miles an hour, pulling a trailer when it broke, I was lucky to keep it on the road. It ruined the rim,tire,brake lines and CV boot. Just fortunate there wasn’t a car next to me or we would’ve hit it and nobody died, especially with my young son in the car. Also when I got it towed the tow truck driver said he picked about the same year truck up three weeks prior for the same issue a broken ball joint on the driver side. In my opinion they should not be an issue with a newer truck with only 42,000 miles on it. This is a huge safety concern and has done a lot of damage to the truck and cost me a lot of money especially being six hours away from home when it happened.

Filed Oct 11, 2022 · Suspension · 59,867 miles · GA

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving 55 mph, the upper control arm and the ball joint detached from the passage side tire. The contact stated no warning light was illuminated. The contact stated he lost control of the vehicle and drove into a ditch. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic, where it was stationed for three weeks. The vehicle was not repaired. The contact towed the vehicle to the local dealer and it still had not been diagnosed. The vehicle was not repaired. Upon investigation, the contact associated the failure with the federal safety agency Campaign Number: 21V718000 (Suspension), however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was 59,867.

Filed Mar 21, 2022 · Brakes, Steering · NE

The ball joint for the front left tire broke while driving on a straight road and caused over $2,100 worth of damage to the wheel, axle, brake, etc. I had no warning or anything when this happened. It felt like my tire popped and when I pulled over, the wheel was still attached but was sitting at an awkward angle. The shop quoted me at $2,154 as there were 5 or 6 different parts they needed to repair including the ball joint, axle, brakes, brake sensors, rim, etc.