2021 Chevrolet Silverado 1500: ball joint or control arm failure

Filed Oct 19, 2026 · Suspension · FL

last October 2025 while going a slow rate of speed my passenger front ball joint severed and this past 17 oct 2026 my driver side ball joint broke also going a slow rate of speed after turning onto a highway.

Filed Oct 5, 2026 · Suspension · LA

Ball joint Failure of front passenger wheel assembly Wheel literally folded under truck . Both ball joints broke . 64k miles luckily I was only doing about 20 mph .

Filed Jun 6, 2026 · Engine · TN

I have fighting this issue since January and have not gotten any help or relief from Chevrolet. This issue caused a significant safety risk and has cost me $12,000. I am writing to formally report a serious safety issue involving my 2021 Chevrolet Silverado that resulted in a sudden loss of power while merging onto an interstate highway. On XXX, I brought my vehicle in for service to replace the upper and lower ball joints, as well as the control arms. I retrieved the vehicle from the repair shop on XXX, and departed the same day for travel to [XXX]. Later that evening, while traveling southbound on [XXX] near [XXX], I stopped at Exit XXX. Upon re-entering the highway and accelerating to merge into traffic, the vehicle began shifting through gears abnormally. While in approximately 6th gear at around 2,900 RPM, a loud banging noise occurred, followed immediately by a significant loss of engine power. At the same time, the check engine light illuminated. Due to the sudden and unexpected loss of power while actively merging into highway traffic, I was nearly rear-ended by another vehicle. I was forced to take immediate evasive action and pull onto the shoulder to avoid a collision. This incident created a highly dangerous situation not only for myself but for surrounding motorists. This failure occurred without warning and directly impacted my ability to safely operate the vehicle in a high-speed traffic environment. I believe this presents a significant safety concern that warrants investigation. Please let me know if any additional information is required. I appreciate your attention to this matter and request that this incident be formally documented and reviewed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 12, 2026 · Engine · TN

On January 2, 2026, I brought my vehicle in for service to replace the upper and lower ball joints, as well as the control arms. I retrieved the vehicle from the repair shop on [XXX] and departed the same day for travel to Mississippi. Later that evening, while traveling southbound on [XXX] near Columbia, Tennessee, I stopped at [XXX]. Upon re-entering the highway and accelerating to merge into traffic, the vehicle began shifting through gears abnormally. While in approximately 6th gear at around 2,900 RPM, a loud banging noise occurred, followed immediately by a significant loss of engine power. At the same time, the check engine light illuminated. Due to the sudden and unexpected loss of power while actively merging into highway traffic, I was nearly rear-ended by another vehicle. I was forced to take immediate evasive action and pull onto the shoulder to avoid a collision. This incident created a highly dangerous situation not only for myself but for surrounding motorists. This lifter failure occurred without warning and directly impacted my ability to safely operate the vehicle in a high-speed traffic environment. I believe this presents a significant safety concern that warrants investigation. There have been over 600,000 recalls for this and Chevrolet's solution was an entire engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 9, 2026 · Electrical, Engine · TX

I am filing this safety complaint regarding a documented engine wire harness chafing defect in my 2021 Chevrolet Silverado 1500 with the 2.7L L3B Turbo engine. While driving, my truck experienced erratic acceleration, engine throttling to 3,000 RPM without returning to idle after releasing the accelerator, engine misfires, sudden loss of engine power, stalling, and multiple simultaneous warning lights. These conditions created immediate safety and collision risks on public roads. GM issued TSB 21-NA-149 in June 2021 and a second bulletin September 17, 2021, both before my November 2021 purchase, identifying wire harness chafing in the L3B engine caused by a manufacturing error. A wire harness clip was removed during production creating an uncontrolled harness branch that contacts sharp edges on the ECM/TCM bracket, upper control arm, and shock tower during normal engine vibration. This defect was built into the vehicle at the factory and was never disclosed to me at point of sale. The defect manifested after warranty expiration causing cascading failures; wire harness, catalytic converter, and transmission, all within five weeks. Vehicle has been inoperable since January 8, 2026. Defect confirmed by independent mechanic and by Ancira-Winton Chevrolet (authorized GM dealer) in their own repair documentation referencing GM Bulletin 21-NA-149. Dealer documented catalytic converter failure as consequential damage from wire harness repair. GM created Customer Satisfaction Program N192219370 for this exact defect. My VIN was excluded despite experiencing identical symptoms. No safety recall has been issued. Loss of throttle control and stalling at highway speeds represents an imminent collision risk. I request the federal safety agency investigate a formal safety recall for 2019-2023 Silverado 1500 and Sierra 1500 vehicles equipped with the L3B engine.

Filed Feb 26, 2026 · Suspension · CA

On 2-23-2026, while traveling at highway speeds on the freeway, the front upper and lower A-arms (control arms) suffered a complete structural failure. This caused an immediate loss of steering control, forcing the vehicle off the road. By sheer luck and reactive maneuvering, I was able to avoid a multi-vehicle collision; however, the failure resulted in over $4,000 in mechanical and body damage.

Filed Feb 23, 2026 · Brakes, Suspension · 98,000 miles · IN · crash

The contact owns a 2021 Chevrolet Silverado 1500. While driving 43 MPH, the message "Brake Failure" was displayed. The contact then lost control of the vehicle, and the vehicle drove from the right side to the left side of the road, the vehicle drove off the road and crashed into a ditch before coming to a stop. The driver had not sustained any injuries. There was no property damage. The air bags did not deploy. The check engine, the ABS and several unknown warning lights were illuminated after the failure. A tow truck driver who was also a mechanic inspected the vehicle and informed the contact that the driver's side front suspension had fractured from the upper ball joint and the wheel was folded in underneath the vehicle. The vehicle was towed to the dealer, where it was being diagnosed. A Police Report was filed. The manufacturer was not notified of the failure. The failure mileage was approximately 98,000.

Filed Jul 24, 2025 · Engine · ID

Purchased a 2021 Chevy Silverado in Dec 2020. At 4600 miles had first engine failure requiring lifters and tie rods to be replaced, bank 1/Cylinder 5. Looking back this repair was a bandaid for an engine (6.2L) with problems known to GMC. On May 3, 2025 @ 79,000 miles truck started making loud noises and all dash lights started flashing including engine lights while driving, dangerous because we were on a busy roadway. Pulled over to shoulder and had towed to dealership. Diagnosis was a crank bearing failure, scored cylinder, push rod bent and lifters were damaged. Engine is not repairable. Here we are just short of 3 months and still no truck, no ETA on replacement engine. Even though our Silverado is a 2021 it is not part of the current GMC recall because the engine was manufactured in 2020. We know that NHSTA is investigating 6.2L engines for years 2019 and 2020 and urge the federal safety agency to broaden the current recall. Our truck was our only vehicle and the expenses we have incurred through no fault of our own are a strain on our budget, we are retired and on a fixed income. This is our 2nd Complaint filing on our truck to provide NHSTA with additional information.

Filed Mar 17, 2025 · Suspension · OH

Upper control arm ball joint separated from the control arm causing steering loss.

Filed Dec 13, 2024 · Suspension · TX

The upper ball joint on the passengers side failed or separated. This caused the truck to lose brake pressure and put the occupants lives in danger. The vehicle is currently at a GMC dealership in Killeen, TX being repaired. There were no warning signs or lamps.

Filed Mar 22, 2024 · Steering, Suspension · AZ

I purchased a used 2021 Chevrolet Silverado from a dealership 5 months ago. Almost immediately after purchasing the truck, I would hear and feel an intermittent pop that originated from near the floor of the front passenger side. The sound became more frequent and would happen mostly when making sharp turns but also when making softer turns. I took it to the dealership to investigate. They had it for a week and supposedly examined the entire vehicle. They were able to replicate the pop sound when driving it but were unable to diagnose the problem. They claimed that sometimes trucks just make noise and assured me that the vehicle was safe to drive. I asked how they knew it was safe if they didn't know what the problem was and how was I to know that whatever is causing the sound isn't causing internal damage. The service manager again assured me that the certified mechanics looked at every detail of the vehicle and found nothing to be concerned about and sent me on my way. After taking the truck home, I continued normal use of the truck, taking it on 3 long distance trips on the highway. The sound continued as it had before, occurring intermittently when turning. 2 days ago, I was backing out of my driveway. I heard a very loud pop and got out of the vehicle to find that the front passenger wheel had completely broken at the ball joint of the control arm and was lying nearly flat on the ground, held suspended by the brake line and CV boot and other attached components. The truck was towed to the dealership, where it currently is. The service manager told me that the mechanics did everything that they were supposed to have done and that unfortunately this is a mechanical part that can fail and that he has seen this issue in 7-8 other vehicles like mine. If this is a common problem, there should have been a red flag when presented with this issue. If this would have occurred on the highway at a high rate of speed, my family and I could have been killed.

Filed Sep 24, 2023 · Steering, Suspension · LA

Upper control arm ball joint failed causing me to lose stealing control, luckily I was only driving 10MPH, if I had been on the interstate this could have been more serious possibly fatalities involved, I have read reports this is a common thing, my truck is a 2021 Silverado, I never received a recall notice