2021 Chevrolet Silverado 1500: engine stalls while driving

Filed Oct 29, 2026 · Engine, Transmission · MS

The lifter on my cylinder one is failing. This is a known issue with the Chevrolet 5.3L 8cylinder engine and 2021 models are known for being notoriously bad with lifter issues. My safety and the safety of other drivers that own 2021 Chevrolet models is impacted due to this issue can cause the engine to completely fail and shut off while driving which could cause severe injuries up to death. The problem is a widespread issue and mine was confirmed by an independent service mechanic. The vehicle is now being inspected by the dealership. The issue did not arise until I reached 104,000 miles.

Filed Oct 6, 2026 · Engine · 172,000 miles · PA

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving approximately 35 to 40 MPH, the vehicle stalled and failed to restart. The contact retrieved DTC: P228C and P030 after scanning the vehicle. The vehicle was towed to a service center, where the contact was provided DTC: P228C, P0340, and P0C6. The contact was informed that the timing chain and guide had failed and that the engine needed to be replaced. The vehicle was not repaired. The failure mileage was approximately 172,000.

Filed Sep 27, 2026 · Fuel system · FL

Truck stalled out while driving as if it had run out of fuel. Had to be towed to my house

Filed Sep 9, 2026 · Electrical, Engine · FL

My 2021 Chevrolet Silverado 1500 RST with the 6.2L engine experienced an engine seizure. The engine was replaced by a Chevrolet dealership under a GM safety recall. Immediately after picking up the vehicle following the recall engine replacement, the truck stalled while still in the Chevrolet dealership parking lot. There was no warning before this first stall. We continued our trip because we did not realize at the time that the stall could indicate a problem following the engine replacement. During the drive from [XXX] to [XXX], the problem continued. In [XXX], the check engine light illuminated and the truck began malfunctioning. The vehicle subsequently stalled again. The problem continued after returning to [XXX]. A Chevrolet dealership in [XXX] inspected the vehicle and reproduced/confirmed a problem involving the camshaft position sensor wiring/connector. The dealership demonstrated the problem by manipulating the connector/wiring and recorded a video of the diagnostic procedure. The vehicle is currently at the Chevrolet dealership and is available for inspection. The affected component should also be available for inspection because it has not yet been repaired. The [XXX] dealership has characterized the wiring/connector condition as normal wear. However, the first stall occurred immediately after the GM recall engine replacement, while the vehicle was still on the repairing Chevrolet dealership's property. Unexpected engine stalling creates a serious safety risk because the vehicle can lose propulsion without warning while driving, including at highway speeds or in traffic. I am concerned that the camshaft position circuit/wiring/connector problem may be associated with the recall engine replacement procedure or replacement engine. I am requesting that the federal safety agency investigate whether other vehicles receiving this GM 6.2L engine recall remedy have experienced similar camshaft position circuit failures or unexpected stalling after engine repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FO

Filed Aug 28, 2026 · Electrical · OH

The check engine light came on and my engine would stall sometimes, it would stall at start up so no safety issue. I took my truck to the dealer a week later where they said a wire was corroded from rubbing on something causing the issues and that it was a common issue.

Filed Jul 30, 2026 · Engine, Transmission · AL

On or around XXX a my 2021 Silverado started making a rattling sound from the engine. The truck began to stall and the engine shut off three times while driving. I attached scanner the next day and the track showed P00011 and P00016 codes. Those codes are for the Camshaft Sensor and the Crankshaft Sensor. I went online and did research about the two codes and discovered there had been a couple recalls for these codes concerning my year model truck: (Recall Number 25V‑274; GM: Campain N252494000). the federal safety agency Engineering Analysis EA25007 or RQ26001 I spoke with the Dealer I purchased vehicle from (Lynn Layton Chevrolet - Decatur, Al)and they said they will not begin repairs until they receive payment from GM or myself. I then spoke with Tyler at GM Corporate Customer Service. He said my VIN was not included in the GM Campaign|Recall. I asked why not because it is a 2021 Silverado and I’m having the exact same problems as vehicles included in the recall. He said because they checked their system and the parts used on my truck were from a different manufacturer than those included on the recall. I said that shouldn’t matter because my truck is having the same exact problems. I asked him to check and see if GM would be able to provide financial assistance to have motor repaired or replaced. Tyler told me that GM will not do repairs - they will only replace the engine. He said GM would not provide any financial assistance because my truck has 170k plus miles on it. I informed Him that I had previously taken my truck to Lynn Layton Chevrolet about these symptoms and it was diagnosed as transmission/torque converter problem. They changed transmission fluid and charged me ~$700. I then asked if GM would authorize a “Goodwill Replacement”. He said they would not. I called Lynn Layton Decatur back and asked how much would engine and reps if I have to pay for it. They said 10k -12k A local mechanic said he will fix for $6,000. Please help me get this resolved. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Filed Jul 22, 2026 · Engine · 120,000 miles · MN

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while his wife was driving approximately 65 MPH, the vehicle lost power and stalled. The vehicle failed to restart. The vehicle was towed to a dealer where it was diagnosed with an internal engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

Filed Jul 14, 2026 · Electrical, Engine · TN

Loss of engine power while merging or passing traffic. * Reduced acceleration making it difficult to enter highways safely. * Engine overheating if the active grille shutters fail in the closed position. * Unexpected limp mode causing sudden speed reduction in traffic. * Increased risk of a rear-end collision due to loss of power or reduced speed. * Check engine light and warning messages distracting the driver. * Vehicle stalling while driving or at intersections. * Reduced visibility if the defroster or HVAC performance is affected by engine temperature issues. * Potential engine damage from overheating, creating a hazard if the vehicle becomes disabled on the roadway. The active grille shutter system malfunctioned and caused warning lights to illuminate. I am concerned that the shutters remaining closed could lead to engine overheating or reduced vehicle performance while driving, increasing the risk of an accident due to loss of power or unexpected vehicle behavior in traffic.

Filed Jun 8, 2026 · Engine · TN

On June 3, 2026, my 2021 Chevrolet Silverado 1500 LT Trail Boss, which has a 6.2L L87 V8 engine, stalled and shut off unexpectedly while I was stopped at a traffic light on a public highway. The engine died without warning, leaving me stranded in traffic and creating a serious safety risk for me and other drivers because of the chance of a collision. I had to call the police to come and sit behind me to keep myself safe from a collision while I waited for a tow truck. A dealer diagnosed the vehicle with DTC P0016, indicating a crankshaft/camshaft position correlation fault. This points to either an engine timing problem or an internal engine failure. The dealer confirmed the issue and gave me a repair estimate of about $11,000. Both the vehicle and repair records can be inspected if needed. Before the failure, the vehicle showed signs of an engine timing or internal issue and eventually triggered the check engine light with code P0016. After researching, I discovered many reports from other owners with the same 6.2L L87 engine who faced similar problems, including P0016 faults, engine stalling, internal engine damage, and complete engine replacement. While some vehicles with this engine have been part of recalls or special coverage programs, my vehicle is not included, even though it shows the same failure pattern. At the time of the failure, the vehicle has about 140,336 miles. I believe my vehicle has the same defect affecting other 6.2L L87 engines. I ask that the federal safety agency look into whether more vehicles should be added to any current or future recalls or defect investigations. Thank you for your attention to this matter.

Filed May 19, 2026 · Transmission · 64,900 miles · GA

The contact owns a 2021 Chevrolet Silverado LD Crew. The contact stated that while reversing the vehicle, the rear end locked up. Also, when accelerated, the vehicle jerked forward and stalled. When the vehicle is shutdown and restarted the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage. 64,900.

Filed May 14, 2026 · Electrical, Transmission · MO

I am submitting a formal safety complaint regarding an electrical system failure on my 2021 Chevrolet Silverado with approximately 61,000 miles. I brought the vehicle to Taylor Grubaugh Chevrolet of Waynesville after the check engine light illuminated. The dealership diagnosed a premature wiring harness failure caused by chafing. They also stated that this issue is known to affect multiple GM vehicles and is documented in Technical Service Bulletin 21 NA 149. Wiring harness failure presents a significant safety concern. A compromised harness can lead to erratic electrical behavior, reduced engine performance, stalling, or sudden loss of power while driving. With that the concern a possible vehicle malfunction or losing power in traffic came to light. The dealerships service department confirmed the problem, verified the wiring harness failure, & referenced the applicable GM technical bulletin. The vehicle was inspected by the authorized Chevrolet dealership. GM declined to cover the repair. No police, insurance, or other third party inspections have been conducted. Despite acknowledging that this is a documented & recurring issue across GM models, the GM informed me that the repair would not be covered under warranty or recall. At only 61,000 miles, a wiring harness failure due to chafing is not consistent with normal wear & tear & instead suggests a premature defect. Given that this is a known and documented defect, I believe it should be recalled. After further research, I discovered that this issue is far from isolated. There are more than 1,500 complaints filed with the Better Business Bureau and approximately 800 complaints submitted to the federal safety agency reporting the same or similar wiring harness failures across GM vehicles. The volume of complaints strongly suggests a widespread defect that may pose ongoing safety risks to consumers.

Filed May 2, 2026 · Transmission · WY

Vehicle: 2021 Chevrolet Silverado VIN: [XXX] Mileage at time of incident: Approximately 68,000 miles Date of incident: April 24, 2026 Approximate speed: 75 mph Weather/road conditions: Clear, sunny day Was the vehicle towed? No Did the engine restart? Yes My 2021 Chevrolet Silverado experienced a sudden loss of power and stalled while I was driving on the highway at approximately 75 mph. The weather was clear and sunny, and road conditions were normal. This created a serious safety concern because the vehicle lost power while traveling at highway speed in traffic and could have caused a crash. The vehicle did restart after the incident and was not towed, but it had to be taken in for service after the power loss/stalling event. The dealership later advised that the oil was low on the dipstick and stated they would change the oil and complete a recall/service update. However, I have maintained the vehicle with regular oil changes, and at the time of the incident, the vehicle’s oil life monitor still showed approximately 50% oil life remaining. I do not believe this should be dismissed as a simple lack-of-maintenance issue. I am concerned that the sudden loss of power/stalling may be related to an engine, fuel, oil pressure, electrical, ECM, or recall/service campaign issue. I am also concerned that the vehicle was low on oil despite regular oil maintenance and the oil life monitor still showing about 50%. The vehicle is currently at Tyrell Chevrolet for inspection/service. I have not yet received a clear explanation of the cause of the power loss, whether diagnostic trouble codes were found, whether oil pressure was affected, whether oil consumption was checked, whether any recall or service campaign caused or corrected the issue, or whether the truck is safe to drive. This sudden loss of power while driving at approximately 75 mph presents a serious safety risk and should be investigated. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)