2022 Ford Bronco visibility problems

Filed Aug 26, 2026 · Visibility · NJ

Windshield is leaking water/rain inside vehicle. I have it at All American Ford Old Bridge,NJ, for 15 days now and they want to charge me portion $256.76 plus tax. BUt, the Bronco has recall 222c12 or 25C52. I was willing to pay not knowing that there as a recall but they said if it breaks or cracks or chips while doing work they are not responsible to cover new windshield. please advise. They show on Ford recall website the recall complete, but my windshield was never removed, resealed and reinstalled. So that is a lie/fraud on All American Ford part. Please help. I have 2 other major issues with Bronco as well which are recalls that they made me pay for or did not resolve as of yet. I already paid for a middle roof panel and now front passenger roof panel must be replaced (recall 26S32) and they say it is not part of recall. And, the safety concern is the car just turned off on major highway 2 different episods one in May on NJ Turnpike I was almost hit from behind and the other was on Route 35 in Seaside Park, NJ in August. Same dealership said they can't experience it so they cannot diagnose and repair it. It is the fuel pump/loss of power issue #26V236000. the car has to be restarted and there is no warning. I am very worried about this.

Filed Jan 16, 2026 · Visibility · NV

The windshield washer fluid reservoir cracked along its seam and drains completely after a few hours. This was not due to an accident and I have not done off-roading. I live in a snowy environment and not having an operating windshield washer is a MAJOR safety hazard as road salt quickly builds up on the windshield dramatically reducing forward visibility. It also affects the rear window washer, but that’s not as troubling an issue. The defective reservoir is available for inspection. My local mechanic confirmed that the reservoir is cracked. My photo shows the fluid leaking onto the ground. The component has not been inspected by the manufacturer, police or insurance, but has been inspected by a mechanic at my local Chevron station. A “washer fluid low” warning and idiot light appears after the reservoir drains, goes off when fluid is added, and goes on again when the fluid drains out again. I have ordered a replacement reservoir from Ford (which has been revised from the original) plus two required hoses for $477.28 (without installation). An internet search suggests this is a common problem for my vehicle.

Filed Jul 29, 2025 · Body, Visibility · TX

The rear hardtop panel on my 2022 Ford Bronco has developed serious cracking and surface separation after only three years of light, garage-kept use. The fiberglass is fracturing near the seams, exposing the underlying material. Water is now visibly collecting in the openings, which will lead to internal moisture intrusion, mold, and eventually corrosion of structural components underneath the hardtop mounting area. This poses a serious long-term safety concern, especially in the event of rear impacts or rollover situations. A Ford dealer inspected the issue and submitted a warranty claim, which was denied. The Ford representative acknowledged the damage but said they could not act without a recall or broader investigation. No warning lights or messages appeared; the issue is external and has progressed gradually. The damage began well before my bumper-to-bumper coverage expired, but has recently worsened. Ford’s own General Service Bulletin GSB 23-7174 lists rear hardtop panel cracking and edge delamination as warrantable conditions. My panel clearly fits those descriptions. Still, I was quoted nearly $10,000 for a full replacement, which is unreasonable. This is not an isolated case. Many 2021–2022 Bronco owners have posted identical problems online. Ford is clearly aware of this issue—which is why they issued that bulletin—but is denying claims unless pressured through complaints. I believe this is a materials or manufacturing defect and ask the federal safety agency to investigate this clear and ongoing failure.

Filed Jun 25, 2025 · Visibility · 39,000 miles · NJ

The contact owns a 2022 Ford Bronco. The contact stated that upon entering the vehicle and closing the door, the driver's side rear quarter panel window separated from the vehicle and fell on the ground. A Safelite mobile technician replaced the driver's side rear quarter panel window at the residence. The vehicle was repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not under recall for the failure. The contact was referred to the federal safety agency Hotline for assistance. The failure mileage was approximately 39,000. The VIN was not available.

Filed May 20, 2025 · Visibility · MD

See attached document for complaint.

Filed May 5, 2025 · Visibility · 49,000 miles · CT

The contact owns a 2022 Ford Bronco. The contact stated while driving approximately 40 MPH in the rain and attempting to clean the windshield, the windshield washer fluid failed to operate as intended, and the windshield wipers became inoperable while driving approximately two weeks later. Additionally, the contact stated that she had noticed a fluid leak on the rear passenger's side interior door. The vehicle was taken to New Canaan Auto Body Inc., where it was diagnosed that the windshield wiper motor had failed, and the windshield washer fluid was leaking on the rear passenger's side interior door. The contact stated that additional diagnostic testing was being performed. The vehicle was not yet repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 49,000.

Filed Jan 20, 2025 · Visibility · MA

There is a bulletin that ford sent out that includes wipers intermittently not working properly when detecting rain. The issue happens when the normal steady wiper speed is selected and the issue isn’t resolved until the wipers are turned off and on again then the issue persists. Ford will not cover this issue even with a bulletin for a car 2,000 miles over their warranty. Further more fords extended warranty they offer at their dealerships will not cover this issue as well even though it extends the manufacturer warranty. This is a safety issue while driving in the rain

Filed Jan 10, 2025 · Visibility · NC

Drivers side front door window vibrates and shakes significantly when in the open half-way position or less. When driving over bumps, rough roads, offroad it is very present. Window has to remain closed or fully open position. Hall Ford Dealer in Elizabeth City NC has been aware and confirmed it's an issue but they don't have a fix for it.

Filed Sep 25, 2024 · Visibility · NJ · 1 injury

I was sitting in my car and the back wind shield exploded over my dog and I. Ford was made aware of the issue, and apparently the Bronco's rods hyper extend and cause the tempered glass to break. Ford wont cover any damages done, and says it isn't covered by warranty. Although the dealership and Ford acknowledge no pressure was existenet to cause the window to burst randomly. In addition, Ford is aware the plastic placer screws in the removable hardtop is defective and cracks over time. However, they are not warrantying this repair.

Filed Jun 4, 2024 · Visibility · 33,000 miles · OH

The contact owns a 2022 Ford Bronco. The contact stated that while the vehicle was parked, she became aware of a crack at the very beginning of the windshield on the passenger's side. The vehicle was taken to an independent mechanic who advised the contact to reach out to the manufacturer because he believed that the failure was related to a recall. The vehicle was not repaired. The contact related the failure with the federal safety agency Campaign Number: 22V451000 (Visibility); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and referred the contact the federal safety agency Hotline for assistance. The failure mileage was approximately 33,000.