About 3 weeks ago now I opened my driver door and heard a loud cranking followed by a poo, the arm bar weld on the door just broke, had to shut the door from the outside and as a result I don't have control over my driver side window and all the power locks in the vehicle are shot. In addition to this my electrical is going crazy, I have the dash lights set to off but when I remove key or open door all the lights come on and I have to click the button back and forth to get the lights to shut off. This has resulted in a dead battery once for not catching it acting up. I'm extremely concerned about the safety on this vehicle I have had it less then 3 years and it's had several recalled issues fixed already. I can't afford a whole new door so please recall this spot weld!!
2020 Ford Escape body complaints
Page 13 of 24: complaints 341 to 370 of 671, newest first, as owners wrote them.
Drivers Side door Welds broke inside door. And door doesn't lock. Door check broke and window goes down less than half way. Bought it in 2021 with 14, 000 miles now has 30,000 Went to my dealership and they said Ford would give me 1000.00 towards repairs leaving me with a balance of 1500. This should be a recall.
Sheet metal piece attached to CHECK ARM ATTACHMENT(PN LJ6Z-7823552-B)detached. 5 spot welds failed. See TSB [XXX]. Door would not close. David McDavid Ford wanted $31000 to replace door. I pop riveted sheet metal piece in 5 places. I will continue driving car but will check rivets every week. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
hello the driver door makes a loud clicking sound when opening all the way
The spot welds on the interior door assembly for the check arm broke off. Causing damage to my power window motor. And many other components. Car is at 50,000 miles. Not high wear. The welds are poorly done and ford is making me buy a new door as a result of their error.
The contact owns a 2020 Ford Escape. The contact stated that while opening the front driver's side door a popping type noise was present and the door would swing open. Also the contact indicated that the front driver's side window would not roll completely down. The vehicle was taken to the local mechanic who diagnosed that the front driver's side door spot welding was faulty and needed to be repaired. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 48,000.
Out of nowhere my front driver side door started making this awful, loud clanking sound whenever I would open or close it. Took it to the mechanic I usually go to and they said that the "door check broke off the door because the spot weld failed" and that I would have to call a Body Shop. Called the dealership and they said that it is a well known and well documented issue with the year, make and model of my vehicle (2020 Ford Escape), but so sorry I would have to pay appr. $2600 to replace the door.
Driver's door hinges failed causing the door to swing open unexpectedly while I was trying to exit. Pulled both shoulders while trying to control it. Orthopedic surgeon says I need rotator cuff surgery - he suspects the injury was due to the door failure.
Door stop on both the driver side as well as the passenger side have broke off making it hard to actually open and close the door. As of 11/16/2023 the window is also stuck due to the door stop damaging the motor. After searching the Internet this is a very widespread issue when I took it to the dealership they said since it was out of warranty it wouldn't be covered. I don't believe this is anything but bad workmanship because the weld apparently breaks as low as 8000 miles. Well within the warranty period.
My driver door started making a loud cranking sound out of the blue when opening and closing the door. After several days, it became clear that the door hinge/catch was no longer secured and was loose. This was not the result of a gist of wind forcefully blowing the door open or something like that; it just broke on its own. Now the door swings wildly when opening and the window won’t roll all the way down. My vehicle was just a few months out of warranty so Ford won’t offer any assistance for fixing the problem. I have not yet repaired it because they say the whole door needs to be replaced and, at this time, I can’t afford the expense.
Driver side door weld broke allowing door to possibly open while driving
Drivers door check arm broken at spot welds rendering it ineffective and making drivers door window inoperable.
When opened front driver’s side door, heard creaking, rattling, and pop. Now door will not close as well as problems with the window not working in that door! The frame on car is also loose due to bad door pulling on the frame. I’m concerned door may open when driving. Ford dealership will not pay due to the fact warranty expired April 2023 with only 33,000 miles on vehicle. An inspection by an independent service center confirms the issue and estimates a $2,400.00 cost of repairs. Inspector indicates poor spot welding and rivets in check arm defective. Insurance will not cover any expenses since it is not a result of a collision!! There was no warning messages indicating any issue. Door noises were heard on a Saturday (11/11/2023) and on Sunday (11/12/2023) door popped and couldn’t be closed’
Driver side door will not close tight. Will sometime open while driving on highway
The drivers front door began making a popping sound as the door opened and closed. By the next day the door began to have trouble closing fully. I noticed the weld points had broken where the door check/limiter attached to the door. It sounds like the same issue as the federal safety agency investigation PE23013. In order to fully close the door the door had to be disabled and the broken part removed.
The Check Arm Attachment on the driver side door for my 2020 broke off because of poor welding, I have read it is a common issue with the 2020 ford escape
Front side driver’s door starting making popping noises on Saturday. By Sunday of the same week only a day later the door made a crunching and breaking noise when opening, now the door has to be forced closed and the window will only go down about 4 inches.
The contact owns a 2020 Ford Escape. The contact stated that while opening or closing the driver's side front door, the door made an abnormal popping sound. The contact stated that he checked the door and became aware that the hinge appeared to be separating from the frame of the vehicle. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the driver's side door needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 22,000.
The front driver's side door is making a loud popping noise when opening and closing the door. We have not yet taken the car to our local dealership yet, but have spoken with them over the phone and their body shop has confirmed that this sounds like an issue we've identified in online forums, which poses a significant safety risk, as the door may open while the car is moving. We will be taking the car in for a formal diagnostic next week. There are no warning indicators of the issue, just the noise, which has started suddenly over the past week.
Per the dealership the driver side door hinge is failing. It also has caused the window track to bind that resulted in window breakage. The door hinge failure is growing worse with time and I'm afraid the door may come loose at some point. The hinge problem first appeared around December 2022.
The contact's husband owns a 2020 Ford Escape. The contact stated that after the vehicle was turned off, the contact opened the door and heard an abnormal clunking sound coming from the door. Additionally, the contact stated that while parked the door was unlatched and swung open inadvertently. The vehicle was taken to a dealer where it was diagnosed that the door welds and spot welds needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 22,600.
I have only had my car for three years and it is well taken care of, but the door suddenly started popping. The same day, my door became difficult to open and extremely hard to close once I got it open. I contacted Ford Corporate the next day. I was told my car was out of warranty because I have 38981 miles. The only thing that was covered under the 5 year warranty in regards to safety would be the seat belts and the airbags. I said, "Ford doesn't think that the car door being able to open or close in the case of an emergency is a safety issue?!?" The chat operator said she could open a case for Ford to review the issue. I asked her if that meant Ford would help with my door and she said no. They gave me case number CAS-46112899-L1F3M7 for my records. I asked how to track that case number to see Ford's response - but of course there is no way to track or check the status - making that case number useless for me. I took my car to Thoroughbred Ford to see if it could be covered under warranty and if they could also fix my radio which is now magically malfunctioning after the 3 year warranty lapsed, they told me I had to pay $155 EACH to have them to diagnose the door and radio problem before they could even give me a cost. Then I was told Ford had a TSB regarding the issue - so correction - it would be covered by Ford and the door has be replaced. I was happy - but not for long. They came back and apologize and said, no that TSB was just for rust and corrosion - they will cover that but not the popping door even though they admittedly were aware that this was a known issue. Then I was told no doors are available, so they can't quote me until it comes in so they will call me. So I look stupid in my car when I get in or out because I open just barely, turn to the side, slide in and then pray I can get it closed. Found out the window now doesn't want to come down because that door is messed up - so I could not even crawl out the window in an emergency.
The driver side door makes a cracking sound when opening and closing and doesn’t shut correctly. Feels unsafe to be driving it around because I’m worried about door popping out at anytime.
The contact owns a 2020 Ford Escape. The contact stated that while the vehicle was parked, the driver's side door failed to remain closed. The contact inspected the door and noticed three holes in the door hinge with missing screws which prevented the door from securely closing. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 104,000.
The drivers side door - the weld on the arm has fractured. Causing a loud clunking noise every time the door is opened or closed. This 'break' has caused the window to only be able to roll down about 6 inches. Also, because of the break, the interior lights don't recognize that the door is closed and will stay on as if there is a door open. When called local Ford Dealership, I was advised it is a common problem and the whole door needed to be replaced. Currently, I am out of warranty but upon investigating online, this is a very common problem in the 2020 Ford Escape Drivers side door.
Driver side door hinge/weld breaks. The metal pops, makes a loud sound, door then has to be forced shut. Due to this the window and lock does not work properly. It goes down particularly then stops. Was taken to New Brighton Ford and spoke with Dan who diagnosed the problem. Was told needed new door. The car was purchased brand new from Freeway Ford in October 2020. Was told no warranty and extended warranty does not cover body.
Loud popping noise when opening driver side door, feels like the door is starting to slip, at times have trouble closing, now the window when rolled down will not roll back up. Popping, cracking noise started 3+ months ago, have call into dealership at this time. Not able to use the window at all now and not sure the door will stay continue to be usable.
A weld in the driver's side door assembly has failed. I am concerned that the door may inadvertently open while driving. The problem has been confirmed by a dealer. I had no warning of the problem until the door mechanism failed and continues to fail with each opening/closing. I do not have the funds to repair/replace the door of the vehicle.
The contact owns a 2020 Ford Escape. The contact stated while opening the front driver's door, she heard an abnormally loud popping sound. The vehicle was taken to the dealer where it was diagnosed with a fractured front driver's door weld. The contact was informed that the front driver's door needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 50,000.
The driver door makes a popping noise when opening and closing. Door now has problems closing and sometimes will not shut properly. Also, the window is not going up and down as fast as it should. Both problems happened around the same time and are believed to be related.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Ford Escape?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history